Electrical connection ........................16 Start-up/Operating manual ......................... 16 General Information ........................16 Requirements for operating personnel ..................17 Overview of the presentation device Beer Marie ................17 Operating modes ........................... 19 Operating of the light-/heating channel ..................20 10.5.1 Control ............................20 Control of the water bath .......................
Page 3
Warranty claims can only be forwarded if all instructions are strictly followed. Version Datum Mutation 1.00 15.05.2019 create Beer Grill AG Beer Grill GmbH Allmendstrasse 7 Tel. +41 (0)56 618 7800 Körnerstrasse 14 a Tel. +49 (0)71 61 659 876 info@beergrill.com CH –...
The Beer Marie is a wet bain-marie with a Culinario glass construction with light-/heating channel. The devices are available either as a drop-in or module unit. With the purchase of your new Beer Marie you have chosen a product that combines the highest technical standards with practical service comfort. We recommend reading these operating and maintenance instructions carefully in order to become familiar with the product quickly.
Children must not be allowed to play with the equipment. Cleaning and operator's maintenance must not be performed by children without supervision. Technical data Mod. Beer Marie 2/1 Beer Marie 3 Beer Marie 4 Beer Marie 5 External dimension mm:...
Any changes or alterations of the appliance or the use of individual spare parts and especially parts essential for the functioning of the appliance that are not original Beer Grill parts as well as non-adherence to notes in the operating manual will cause the lapse of our warranty and the exclusion of liability claims.
The manufacturer accepts no liability for damage or injury to persons caused by not observing the instructions and precautionary measures contained in this handbook. In case of doubt, please contact the DEALER. Beer Grill AG Beer Grill GmbH Allmendstrasse 7 Tel. +41 (0)56 618 7800 Körnerstrasse 14 a...
The bath can be very hot when cleaning (allow for waiting time). Procedure by lamp bursting and breakage of glass Your Beer Marie is equipped with lamp bursting alarm (see operation manual). In case of lamp bursting glass shelves, sneeze screen, front and lateral glasses, proceed immediately as follows: •...
Glazing/Danger of accident Beer counters are equipped with one sheet safety glass (ESG). Incorrect, badly mounted or damaged glass may fall out and cause serious injuries. Be sure to check all glazing before opening the self-service counter, but also after cleaning the glass (especially the front- glass) if: •...
Then you can carefully pull the panel out of its holder towards the front. Take care to pull straight, not sideways or askew, which could damage the holder. • To refit the panels, simply proceed in the reverse order. Beer Grill AG Beer Grill GmbH Allmendstrasse 7 Tel. +41 (0)56 618 7800 Körnerstrasse 14 a...
• Risk of crushing, risk of glass breaking, so for this reason move it slowly and carefully. Beer Grill take no responsibility for damage to glass panels due to improper handling during removal or replacement. Warranty and liabilities Basically, the "General Terms and Conditions" of the Beer Grill AG company, Allmendstrasse 7, CH-5612 Villmergen, apply in which the details of the guarantee claims are regulated.
• The scope of delivery and execution of the elements can be taken from the respective shipping documents. • Beer Maries are delivered on one-way pallets with cardboard wrapping. • The device must be protected against moisture and frost. •...
Installation of Beer Marie Setting up and moving the device • Solid substructure The devices are not self-supporting, that means, tabletop and built-in models need a solid base for transport and installation with the dimensions corresponding to those of the devices.
Max. tolerance of the mains voltage + 6/- 10 %. Correct installation and commissioning of the device is a prerequisite for trouble- free operation. The installation must comply with the local electrical, safety and hygiene regulations. Beer Grill AG Beer Grill GmbH Allmendstrasse 7 Tel. +41 (0)56 618 7800 Körnerstrasse 14 a...
Water drainage should not be kinked. All water inlets and outlets must be able to flow freely. Sludge water drainage must be fed into an open funnel with a safety distance of 20 mm. Beer Grill AG Beer Grill GmbH Allmendstrasse 7 Tel.
Connection and start-up have to be done by a skilled/trained person only. For connection of Beer Marie proceed as follows: • Check up if electrical data of mains correspond with those on the rating plate of the Beer Marie. •...
- Error reports, malfunctions or damage that cannot be rectified by the maintenance personnel. - Changes in the configuration or work on the live parts may only be carried out by specialist personnel. Overview of the presentation device Beer Marie Illustration 1: Operator side 3/1 Beer Grill AG Beer Grill GmbH Allmendstrasse 7 Tel.
Page 18
Illustration 2: Customer side 3/1 Illustration 3: Technical view with GN 3/1 dimensions (front view) Beer Grill AG Beer Grill GmbH Allmendstrasse 7 Tel. +41 (0)56 618 7800 Körnerstrasse 14 a Tel. +49 (0)71 61 659 876 info@beergrill.com CH – 5612 Villmergen D –...
Caution The device may only be commissioned by qualified and trained personnel. The device must be under zero potential when it is assembled, repaired and opened. Beer Grill AG Beer Grill GmbH Allmendstrasse 7 Tel. +41 (0)56 618 7800 Körnerstrasse 14 a Tel.
Infrared heating: Turn the knob for the desired GN field to the required setting. 0 = Off 1 = Min. power 5 = Max. power Beer Grill AG Beer Grill GmbH Allmendstrasse 7 Tel. +41 (0)56 618 7800 Körnerstrasse 14 a Tel.
Keep a watch on the device and allow to run for 15 – 30 minutes. If there are any leakages, switch off the device. Start-up Beer Marie • Switch on the circuit breaker in front of the device.
The heat sources (infrared lamps on the top and radiation heaters below) reach their operating temperature very quickly. Presentation plates and crockery, as well as the lamp covers and cover sheets, become hot. Beer Grill AG Beer Grill GmbH Allmendstrasse 7 Tel.
Empty the bath and clean carefully. • Rub all STAINLESS STEEL parts with a cloth soaked in Vaseline oil, which then forms a protective film. Beer Grill AG Beer Grill GmbH Allmendstrasse 7 Tel. +41 (0)56 618 7800 Körnerstrasse 14 a Tel.
11 Cleaning Following is some advice on maintenance, care, trouble shooting and service for your Beer Marie. The device must be cleaned inside and outside daily according to the hygiene regulations, because only this guarantees an optimal presentation of the goods.
Page 26
This applies to all glass structures. Important: When cleaning a 1E cabinet, additionally retain the glass panel on the front side with your other hand. Beer Grill AG Beer Grill GmbH Allmendstrasse 7 Tel. +41 (0)56 618 7800 Körnerstrasse 14 a Tel.
Safety check of the system. • Regular visual checking of all the glass. • Cleaning the water bath. Beer Grill AG Beer Grill GmbH Allmendstrasse 7 Tel. +41 (0)56 618 7800 Körnerstrasse 14 a Tel. +49 (0)71 61 659 876 info@beergrill.com...
This heat can destroy the electric installation and increases the danger of burning. Caution Infrared lamps with less than 300 Watt have not enough power and the food cool down very rapidly. Beer Grill AG Beer Grill GmbH Allmendstrasse 7 Tel. +41 (0)56 618 7800 Körnerstrasse 14 a...
Page 29
• Power has been switched on ............self-checking • The electronic has been properly set ..........self-checking Beer Grill AG Beer Grill GmbH Allmendstrasse 7 Tel. +41 (0)56 618 7800 Körnerstrasse 14 a Tel. +49 (0)71 61 659 876 info@beergrill.com CH –...
Page 30
Should the options listed not be the cause of the error, please contact customer service. We are not liable for loss of goods, even if the appliance is still covered by warranty. It is therefore recommended that the temperature of the appliance be checked periodically. Beer Grill AG Beer Grill GmbH Allmendstrasse 7 Tel.
Water level sensor Access to this service hatch is from the operator side. This access must be ensured. Water drainage pipe Valve for water inlet Beer Grill AG Beer Grill GmbH Allmendstrasse 7 Tel. +41 (0)56 618 7800 Körnerstrasse 14 a Tel.
515011 Solenoid valve ¾" to Beer Marie 3605205 Reinforced hose 0.8 – 1 m incl. screw connection 3605206 outside ½" -inside ⅜" Water inlet valve ⅜" to Beer Marie 3605207 Drainage screw connection ¾" 3605212 O-ring for overflow support 3605216...
The different parts (electrical components, rubber hoses, cable sheaths, etc.) have to be separated according to material. In this way, an environmentally friendly disposal will be ensured that meets the legislative regulations. Beer Grill AG Beer Grill GmbH Allmendstrasse 7 Tel.
Beer Grill customer service. When contacting after sales service always indicate serial number and type (on power rating shield) of the Beer Marie. Make sure you are aware of serial number and type (on power rating shield) once you call after sales service department.
Need help?
Do you have a question about the Marie and is the answer not in the manual?
Questions and answers