Table of Contents
Advertisement
Quick Links
176 MITTEL DRIVE, WOOD DALE, IL 60191
Single Phase and Three Phase, 50 Hz
Included in this manual:
*One Pop Option
*Salt/Sugar Option
*Ansul Option
*Elevator Option
READ and UNDERSTAND these operating, and safety
instructions before operating this popcorn machine
Created on 4/14/2011 8:18:00 AM
MACH 5
16, 32, 48 and 60 oz
POPCORN MACHINE
OPERATION MANUAL
120/208, 120/ 240 Volt,
Single and Three Phase, 60 Hz
230 Volt,
400 Volt, 3N
Three Phase, 50 Hz
1
M5 16/32/48/60-M-A/E-O
BEGIN SERIAL NO. 09010131
Advertisement
Table of Contents
Related Manuals for Cretors MACH 5 M516 Series
Summary of Contents for Cretors MACH 5 M516 Series
- Page 1 M5 16/32/48/60-M-A/E-O 176 MITTEL DRIVE, WOOD DALE, IL 60191 MACH 5 16, 32, 48 and 60 oz POPCORN MACHINE OPERATION MANUAL 120/208, 120/ 240 Volt, Single and Three Phase, 60 Hz 230 Volt, Single Phase and Three Phase, 50 Hz 400 Volt, 3N...
-
Page 2: Table Of Contents
M5 16/32/48/60-M-A/E-O TABLE OF CONTENTS Safety Alert Symbol ........3 Safety First . -
Page 3: Safety Alert Symbol
II. SAFETY FIRST The information in this manual is essential for the safe installation and operation of your Cretors popcorn machine. The manual must be read and understood before installing, or operating this equipment, or equivalent training must be provided. -
Page 4: Purpose Of Manual
IV. PURPOSE OF MANUAL This instruction manual is intended to familiarize owners with the operation, and safety procedures associated with your Cretors popcorn machine. It is important that this manual be kept available to operating personnel. A person who has not read and understood all operating and safety instructions is not qualified to operate the machine. - Page 5 E. Your Mach 5 model Cretors popcorn popper is equipped for a pump, which, when properly adjusted, automatically delivers the proper amount of oil to the popping kettle.
-
Page 6: Control Switches
-Displays and controls kettle temperature. VIII. OPERATING INSTRUCTIONS Do not attempt to operate your Cretors popcorn machine until you have read and understood this manual. Failure to do so may result in serious injury or death. Do not attempt to operate your Cretors popcorn machine unless the installation instructions have been strictly adhered to. - Page 7 Call 1.800.TO ANSUL for the closest representative. To operate your Cretors popcorn popping machine: 1. Fill the corn drawer with corn on floor models. 2. Fill the salt box and hang it on the inside edge of the corn drawer.
- Page 8 M5 16/32/48/60-M-A/E-O Measuring cups have been provided to accurately measure the proper amounts of popcorn, salt and oil. The correct amount for each popping is: SALTED CORN VOLUMETRIC MEASURE Kettle Size Corn Salt 16 oz 16 oz. 5.5 oz. 1.5 tsp. 473 ml 163 ml 7.5 ml...
-
Page 9: Sanitation Instructions
A. Popping Kettle 1. The Cretors kettle is designed to be cleaned in place. There is no need to remove the kettle to clean. Do not immerse an assembled kettle in water. This will damage the electrical components and my cause short circuits resulting in electrical shock hazard if power is applied. - Page 10 Increase frequency as needed. 9. There are two new Cretors cleaners. Carbon OFF in the blue can is to be used with no heat and the red would require the kettle to be heated. Read the directions on the cans.
- Page 11 6. Ventless hood filters need to be cleaned and replaced regularly, see manual for recommended schedule and procedures. Care and caution needs to be taken when cleaning filters as to not damage them, especially the electrostatic filter Cretors’ elevator corn storage option Elevator THEORY AND OBSERVATIONS OF MACHINE OPERATION The elevating corn storage option is designed to allow operators to easily adjust the level of popped corn in the heated storage bin for easy access.
- Page 12 Customer Service Department at C. Cretors and Company. Additional copies of this manual can be obtained from C. Cretors and Company at the address listed below. Please provide model and serial number when requesting additional copies of this manual. There will be a nominal charge for additional copies.
Need help?
Do you have a question about the MACH 5 M516 Series and is the answer not in the manual?
Questions and answers