Maintenance Under Severe Usage Conditions - Hyundai 2004 Santa Fe Owner's Manual

5
VEHICLE MAINTENANCE REQUIREMENTS

MAINTENANCE UNDER SEVERE USAGE CONDITIONS

6
F040A02O-AAT
The following items must be serviced more frequently on cars normally used under severe driving conditions. Refer to the chart below for the appropriate
maintenance intervals.
R : Replace I : Inspect and, after inspection, clean, adjust, repair or replace if necessary
MAINTENANCE ITEM
ENGINE OIL AND FILTER
AIR CLEANER FILTER
SPARK PLUGS
BRAKE PADS, CALIPERS AND ROTORS
REAR BRAKE DRUMS/LININGS/PADS, PARKING BRAKE
STEERING GEAR BOX, LINKAGE & BOOTS/
LOWER ARM BALL JOINT
DRIVESHAFTS AND BOOTS
MANUAL TRANSAXLE OIL
AUTOMATIC TRANSAXLE FLUID AND FILTER
TRANSFER CASE OIL (4WD) *
1
REAR AXLE OIL (4WD) *
*1. Transfer case Oil and Rear Axle Oil should be changed anytime they have been submerged in water.
SEVERE DRIVING CONDITIONS
A - Repeated short distance driving
B - Extensive idling
C - Driving in dusty, rough roads
D - Driving in areas using salt or other corrosive materials or in
very cold weather
E - Driving in sandy areas
MAINTENANCE
1
With LSD
Without LSD
OPERATION
R EVERY 3,000 MILES (4,800 KM) OR 3 MONTHS
R MORE FREQUENTLY
R MORE FREQUENTLY
I MORE FREQUENTLY
I MORE FREQUENTLY
I MORE FREQUENTLY
I EVERY 7,500 MILES (12,000 KM) OR 6 MONTHS
R EVERY 60,000 MILES (96,000 KM)
R EVERY 30,000 MILES (48,000 KM)
R EVERY 25,000 MILES (40,000 KM)
EVERY 25,000 MILES (40,000 KM)
R
EVERY 50,000 MILES (80,000 KM)
F - More than 50% driving in heavy city traffic during hot weather
above 90°F (32°C)
G - Driving in mountainous areas
H - Towing a trailer
I - Driving as a patrol car, taxi, other commercial use and vehicle towing
J - Driving over 100 mph
MAINTENANCE
INTERVALS
DRIVING
CONDITION
A, B, C, F, H
C, E
B, H
C, D, G, H
C, D, G, H
C, D, E, F, G
C, E, F
A, C, D, E, F, G, H, I, J
A, C, E, F, G, H, I
C, E, G, I
C, E, G, I