Advertisement
SETTINGS
Base se�ngs – Idylle 39 FCV
Type
Rebound
Soft
16 clics
Medium
18 clics
Hard
20 clics
Adjus�ng stanchion posi�on in the crowns
Depending on the bicycle, the posi�on of the fork in the crowns can vary slightly. However, you must maintain ALL the
following measurements to ensure the fork's func�on and your security.
Low speed
High speed
compression
compression
12 clics
14 clics
14 clics
16 clics
16 clics
18 clics
The lower crown height ensures the full use of fork travel and �re
clearance. Use the following measurements to set your lower crown
height (A). This height is measured from the top of the fork leg (the
bo�om of the visible part of the dust seal) to the bo�om of the
lower crown.
Maximum �re diameter : 765mm
Maximum �re width : 80mm
Maximum « shoulder » diameter od the �re : 730mm
The distance between the top of the upper crown and the top of the
stanchion must be between 0mm and 30mm (B). Once you have
assembled the crowns and adjusted the heights to the
measurements above, you may proceed to the �ghtening of the
bolts. USE THE FOLLOWING BOLT TORQUES.
MAINTENANCE
3.1 Service
It is essen�al to clean your fork a�er each day of riding without wai�ng. Nothing is worse for the life of your seals than dirt and
dust. The cleaning process is also extremely simple: clean the stanchions and seals with a clean rag. You can occasionally
lubricate the exterior of the seal with silicone grease.
Do not under any circumstances use degreaser. On the same note, do not power wash the forks! It will only push
the mud inside the forks and get it stuck between the stanchion and the seals.
Cleaning / Checking the pressure / Checking the
tightening of screws (crown+ axle)
Lite service /
Inspection of guide
rings
Full service
Lite service : Oil change, Inspection of guide rings, Cleaning
Full service : Scraper seals, guide rings, internal seals change
Remember to bleed the air from your air cartridge every 5 to 10 rides depending on usage.
12
After each
ride
•
Wet/muddy condi�ons
Racing/Frequent use
Dry/dusty condi�ons
Wet/muddy condi�ons
Racing/Frequent use
Dry/dusty condi�ons
Every 6
Every
Every 2
month
year
years
•
•
•
•
•
•
13
Advertisement
