Heatilator NDV3630 Owner's Manual
Gas fireplace
Hide thumbs
Also See for NDV3630:
- Owner's manual (88 pages) ,
- Owner's manual installation and operation (81 pages) ,
- Specification (4 pages)
Table of Contents
Advertisement
Model(s):
NDV3630, NDV3933, NDV4236, NDV4842,
NDV3630I, NDV3933I, NDV4236I, NDV4842I,
NDV3630L, NDV3933L, NDV4236L, NDV4842L,
NDV3630IL, NDV3933IL, NDV4236IL, NDV4842IL
• Important operating
a n d m a i n t e n a n c e
instructions included.
WARNING: If the information in these
instructions is not followed exactly, a Þ re
or explosion may result causing property
damage, personal injury, or death.
• DO NOT store or use gasoline or other ß am-
mable vapors and liquids in the vicinity of this
or any other appliance.
• What to do if you smell gas
- DO NOT try to light any appliance.
- DO NOT touch any electrical switch. DO
NOT use any phone in your building.
- Immediately call your gas supplier from a
neighbor's phone. Follow the gas suppli-
er's instructions.
- If you cannot reach your gas supplier, call
the Þ re department.
• Installation and service must be performed
by a qualiÞ ed installer, service agency, or the
gas supplier.
In the Commonwealth of Massachusetts installation must be
performed by a licensed plumber or gas Þ tter.
See Table of Contents for location of additional Commonwealth
of Massachusetts requirements.
Installation and service of this appliance should be
performed by qualiÞ ed personnel. Hearth & Home
Technologies suggests NFI certiÞ ed or factory trained
professionals, or technicians supervised by an NFI
certiÞ ed professional.
NOTICE
DO NOT DISCARD THIS MANUAL
• Read, understand and follow
these instructions for safe
installation and operation.
Heatilator • Novus NDV Series • 4055-187 Rev. AA • 10/13
Owner's Manual
Installation and Operation
• Leave this manual with
party responsible for use
and operation.
WARNING
DO NOT TOUCH GLASS
NEVER ALLOW CHILDREN
A barrier designed to reduce the risk of burns
from the hot viewing glass is provided with this
appliance and shall be installed.
This appliance may be installed as an OEM
installation in manufactured home (USA
only) or mobile home and must be installed
in accordance with the manufacturer's
instructions and the Manufactured Home
Construction and Safety Standard, Title 24
CFR, Part 3280 in the United States, or the
Standard for Installation in Mobile Homes,
CAN/CSA Z240 MH Series, in Canada.
This appliance is only for use with the type(s)
of gas indicated on the rating plate. This
appliance is not convertible for use with other
gases, unless a certiÞ ed kit is used.
HOT GLASS WILL
CAUSE BURNS.
UNTIL COOLED.
TO TOUCH GLASS.
1
Advertisement
Table of Contents
Related Manuals for Heatilator NDV3630
Summary of Contents for Heatilator NDV3630
- Page 1 Technologies suggests NFI certiÞ ed or factory trained appliance is not convertible for use with other professionals, or technicians supervised by an NFI gases, unless a certiÞ ed kit is used. certiÞ ed professional. Heatilator • Novus NDV Series • 4055-187 Rev. AA • 10/13...
-
Page 2: Congratulations
As the owner of a new Þ replace, you’ll want to read and Your new Heatilator gas Þ replace will give you years of carefully follow all of the instructions contained in this durable use and trouble-free enjoyment. Welcome to the Owner’s Manual. -
Page 3: Table Of Contents
B. Constructing the Appliance Chase Junction Box Installation C. Clearances G. Wall Switch Installation for Fan (Optional) D. Mantel and Wall Projections 6 Termination Locations A. Vent Termination Minimum Clearances Heatilator • Novus NDV Series • 4055-187 Rev. AA • 10/13... - Page 4 B. IntelliÞ re Ignition System 17 Reference Materials A. Appliance Dimension Diagram B. Vent Components Diagrams C. Service Parts D. Optional Components E. Contact Information = Contains updated information. Heatilator • Novus NDV Series • 4055-187 Rev. AA • 10/13...
-
Page 5: Limited Lifetime Warranty
3 years Firebox and heat exchanger Lifetime All replacement parts 90 Days beyond warranty period See conditions, exclusions, and limitations on next page. 4021-645F 02-18-13 Page 1 of 2 Heatilator • Novus NDV Series • 4055-187 Rev. AA • 10/13... - Page 6 THE EXTENT PROVIDED BY LAW, HHT MAKES NO EXPRESS WARRANTIES OTHER THAN THE WARRANTY SPECIFIED HEREIN. THE DURATION OF ANY IMPLIED WARRANTY IS LIMITED TO DURATION OF THE EXPRESSED WARRANTY SPECIFIED ABOVE. 4021-645F 02-18-13 Page 2 of 2 Heatilator • Novus NDV Series • 4055-187 Rev. AA • 10/13...
-
Page 7: Listing And Code Approvals
A 110-120 VAC circuit for this product must be protected with ground-fault circuit-interrupter protection, in compliance with the applicable electrical codes, when it is installed in locations such as in bathrooms or near sinks. Heatilator • Novus NDV Series • 4055-187 Rev. AA • 10/13... -
Page 8: Requirements For The Commonwealth Of
(1/2) inch in size, “GAS See Gas Connection section for additional Common- wealth of Massachusetts requirements. VENT DIRECTLY BELOW. KEEP CLEAR OF ALL OB- STRUCTIONS”. Heatilator • Novus NDV Series • 4055-187 Rev. AA • 10/13... -
Page 9: User Guide
Failure to operate Þ replace according to operating instructions could cause Þ re or injury. HEARTH CLEAR SPACE (not required) SECTION 2 Figure 2.1 General Operating Parts Heatilator • Novus NDV Series • 4055-187 Rev. AA • 10/13... -
Page 10: Fan Kit (Optional)
For more information refer to the instructions supplied with your decorative door or front. Red or Black Button Figure 2.3 Ignitor Button Heatilator • Novus NDV Series • 4055-187 Rev. AA • 10/13... -
Page 11: Lighting Instructions (Ipi)
See installation and operating instructions accompanying appliance. For additional information on operating your Hearth & Home Technologies Þ replace, please refer to www.Þ replaces.com. Final inspection by Heatilator • Novus NDV Series • 4055-187 Rev. AA • 10/13... -
Page 12: Lighting Instructions (Standing Pilot)
Hearth & Home Technologies Þ replace, please refer to www.Þ replaces.com. 4. Push in gas control knob slightly and turn clock- wise to OFF”. DO NOT force. 5. Close control access panel. Final inspection by 464-903H Heatilator • Novus NDV Series • 4055-187 Rev. AA • 10/13... -
Page 13: After Appliance Is Lit
ß ame burn continually? Some optional control systems available with IPI models may allow pilot ß ame to remain lit. In a standing pilot system the pilot will always stay on. Heatilator • Novus NDV Series • 4055-187 Rev. AA • 10/13... -
Page 14: Maintenance And Service
Carefully set Þ xed glass assembly in place on appliance. Hold glass in place with one hand and secure glass latches with the other hand. • Reinstall door or decorative front. Heatilator • Novus NDV Series • 4055-187 Rev. AA • 10/13... -
Page 15: Maintenance Tasks-Service Technician
Inspect for paint condition, warped surfaces, corrosion or perforation. Sand and repaint as necessary. • Replace appliance if Þ rebox has been perforated. Control Compartment and Firebox Top Frequency: Annually By: Service Technician Heatilator • Novus NDV Series • 4055-187 Rev. AA • 10/13... - Page 16 (Either cobrahead or SIT) Figure 3.1 IPI Flame Patterns Figure 3.2 Standing Pilot Flame Patterns Heatilator • Novus NDV Series • 4055-187 Rev. AA • 10/13...
-
Page 17: Installer Guide
(SECTION 8) FRAMING/HEADER (SECTION 5) OPTIONAL WALL SWITCH (SECTION 13) MANTEL AND MANTEL LEG (SECTION 5 & 14) SURROUND (SECTION 14) GAS LINE (SECTION 12) Figure 4.1 Typical Appliance System Heatilator • Novus NDV Series • 4055-187 Rev. AA • 10/13... -
Page 18: Design And Installation Considerations
Manometer Flat blade screwdriver 1/2 - 3/4 inch length, #6 or #8 Self-drilling screws Caulking material (300ºF minimum continuous exposure rating) One 1/4 inch female connection (for optional fan). Heatilator • Novus NDV Series • 4055-187 Rev. AA • 10/13... -
Page 19: Framing And Clearances
7- /8 19- /8 4 - /8 -1/4 10 7 1102 1194 1092 4842 41-7/8 19- /8 4 - /8 -1/4 1219 10 4 1102 1194 Figure 5.1 Appliance Locations Heatilator • Novus NDV Series • 4055-187 Rev. AA • 10/13... -
Page 20: Constructing The Appliance Chase
19-5/8 in./498 mm 10 in./254 mm 9 in./229 mm 48 in./1219 mm 34-7/8 in./886 mm 19-5/8 in./498 mm NDV4842 10 in./254 mm 9 in./229 mm Figure 5.2 Clearances to Combustibles Heatilator • Novus NDV Series • 4055-187 Rev. AA • 10/13... -
Page 21: Mantel And Wall Projections
Mantel Leg or Wall Projections (Acceptable on both 6-1/4 5-1/2 sides of opening) Measured from top of hood (in inches) Figure 5.3 Clearances To Mantels Or Other Combustibles Above Appliance Heatilator • Novus NDV Series • 4055-187 Rev. AA • 10/13...