Page 1
INSTALLATION AND OPERATING INSTRUCTIONS for all Hydrocarbon BB Back Bar Refrigerator Models 809-183a Rev A. 6/8/2020 SEE BACK COVER FOR 3779 CHAMPION BLVD, WINSTON-SALEM, NC 27105 WARRANTY REGISTRATION Phone: (888) 845-9800 | Fax: (800) 253-5168 | Web: beverage-air.com...
If you meets the high standards set by Beverage-Air! You have have any questions, Please call our Technical Service made a quality investment that with proper maintenance Department at (800) 684-1195.
R290 equipment. • Clean a dirty condenser with a sharp object. • Use ONLY Beverage-Air factory service parts. Use of • Store gasoline, kerosene or any other flammable non OEM parts can be dangerous because of the design material near the cabinet.
User Manual for BB Refrigerators Beverage-Air IMPORTANT INFORMATION This unit is intended to be used in a commercial application. That includes bars and restaurants. If installed in a residence some commercial service companies may not be able to service it on site.
Page 5
User Manual for BB Refrigerators Beverage-Air Air Flow, 36 - 48 inch Models regardles of section, door count or door material. Rev. 06/20 Beverage-Air...
Page 6
User Manual for BB Refrigerators Beverage-Air Air Flow, 58 - 94 inch Models regardles of left or right grille location, section, door count or door material. Left grille shown, right grille similar but air flows in the right front, out the back and right side.
User Manual for BB Refrigerators Beverage-Air PRODUCT INFORMATION Cabinet Dimensions Door Glass or Full Load Power Cord Refrigerant Type / Model w x d x h (Inches) Count Solid Door Amps Plug (NEMA) Charge (g) BB24HC-1 24 x 30 1/8 x 37 3/4...
User Manual for BB Refrigerators Beverage-Air CLEARANCE AND PLACEMENT CLEARANCE Placement Consider the following when selecting a location for your Refrigerator: Clearance: • None required at top, back or sides. Floor Load: the floor on which the Refrigerator is located must be even and level, free from vibrations, and strong enough to support the combined weights of the unit and maximum product load.
User Manual for BB Refrigerators Beverage-Air UNPACKING AND SET UP Carefully inspect the shipping carton for damage. This is the only time that shipping damage may be claimed. If damage is suspected, open the carton immediately and, if there is damage, retain the carton and contact the shipper to make a claim.
4. Install all remaining clips. manner. Contact Beverage-Air customer service if fewer shelves or a different configuration to ensure 5. Install shelves onto clips with the product retention shelf overloading will not occur.
User Manual for BB Refrigerators Beverage-Air SLIDING DOORS, ASSEMBLY Leveling 1. To insure proper operation, the cabinet must be level. 2. Level the cabinet, see page 3. Verify the level condition by putting a level on the header (figure 2a) and side frame (figure 2b) of the door assembly.
Page 12
3. Verify that the frame was not bowed during installation. in between the doors. If the frame is bowed, contact Beverage-Air Technical Service. 2. Self-closing device (a.k.a. "Torpedo· ) is properly located on edge of door and is not "pinched"...
User Manual for BB Refrigerators Beverage-Air KEG INSTALLATION Safety First! If in doubt about how to handle the CO2 system contact your dealer/distributor How to Install a CO2 Regulator and Replace an Empty CO2 Cylinder 1. Shut off gas pressure to dispenser by closing the Cylinder Valve and the Shut off Valve.
User Manual for BB Refrigerators Beverage-Air ELECTRICAL This is a cord-connected unit, and must be connected to its own dedicated power supply. Check the dataplate on the machine to confirm the voltage and per the dataplate use the correct fuses or HACR circuit breakers.
User Manual for BB Refrigerators Beverage-Air USING THE UNIT Operation is simple, just keep it connected to the correct The temperature was set at the factory at 38 F, but º power supply and the refrigerator will maintain the you can adjust it to your own selected temperature. 30 internal temperature it has been set to.
User Manual for BB Refrigerators Beverage-Air SEQUENCE OF OPERATIONS REFRIGERATOR The refrigerator operates based on the air temperature measured by the probe located at the return air. COMPONENT OPERATION CONTROLLER ACTION OPERATION CONTROLLER ACTION Compressor turns The Compressor The Compressor...
Page 17
User Manual for BB Refrigerators Beverage-Air Electronic Controller DEFROST (ESC) SELECT (OK) DOWN Control Panel Display Defrost LED Alarm LED On fixed: Defrost active On fixed: ALARM Present Off: Defrost is off Flashing: ALARM Silenced Off: No Alarm Fan LED...
Page 18
User Manual for BB Refrigerators Beverage-Air Control Panel Connections Changing the Set point Electronic Controller Alarms The alarm condition is always signaled by the alarm icon . To turn off the relative icon will continue flashing. NOTE: If alarm exclusion times are in progress (ALA folder of the parameter table), the alarm is not signaled.
Page 19
User Manual for BB Refrigerators Beverage-Air Alarm Trigger Automatic Outputs Comments Code Clearance "Hi" Air temperature is higher than User Bl ink "Hi" with the highest temperature; If High temperature "ALA->Hat• for "ALA->Htd" configured configured: cut in alarm relay, beep the buzzer alarm "Lo"...
User Manual for BB Refrigerators Beverage-Air CLEANING AND MAINTENANCE Cleaning Schedule: Cabinet Condenser coil Gaskets Routine maintenance Daily wipe down Quarterly cleaning Daily inspection, check Annually that hinges are tight to Weekly interior the cabinet. Daily Exterior Cleaning It is much easier to clean on a regular basis than to have to remove stains once they have built up.
User Manual for BB Refrigerators Beverage-Air CONDENSER CLEANING The condenser coil is located right behind the front grille on top of the cabinet. It should be inspected once a month and cleaned as required. 1. Remove power from the unit.
User Manual for BB Refrigerators Beverage-Air METHODS FOR CLEANING STAINLESS STEEL Cleaning Needed Cleaning Agent Method of Application Affect on Finish Satisfactory for use on all Areal 20, Lac-O-Nu, Lumin Wash Rub with cloth as directed finishes. Smears and fingerprints O’Cedar Cream Polish, Stainless...
User Manual for BB Refrigerators Beverage-Air HELP Trouble Diagnosis for the User Malfunction Possible Cause Likely Solution Connect to proper voltage circuit Replace Unit not plugged in. fuse or reset breaker. No cooling - unit is silent Fuse or circuit breaker tripped.
User Manual for BB Refrigerators Beverage-Air FOR THE SERVICE TECH - R290 Refrigeration service should only be attempted by a trained trade professional certified to work on R290 systems. Here are some critical service items. Other Information: This list does not qualify anyone to service the unit. It is a Evacuation: It is critical that a refrigeration system be reminder and checklist for the service tech.
User Manual for BB Refrigerators Beverage-Air FOR THE SERVICE TECH - WIRING DIAGRAM CNTRL *SEE CONTROLLER DETAIL CONDENSER FAN CURRENT RELAY COMP *SEE CONTROLLER DETAIL COMPRESSOR DETAIL (115V 1PH) EVAP FANS POWER *SEE CONTROLLER DETAIL SUPPLY *NOT ALL MODELS* LAMP L.E.D.
(87) months from the date of defective. shipment from Beverage-Air, provided upon receipt of the The labor warranty shall be for self-contained units compressor, manufacturer examination shows the sealed only and for standard straight time, which is defined as compressor to be defective.
With the exception of Blast Chillers product is designed for LIMITATION OF LIABILITY: maintaining temperature and not bringing food to a desired Beverage-Air Corporation or their affiliates shall not be temperature therefore cannot be held responsible for this liable for any indirect, incidental, special or consequential function under warranty.
Page 28
User Manual for BB Refrigerators Beverage-Air Warranty Registration Register your product online at beverage-air.com/parts-service or fill out and mail the form below. Cabinet Model Number: _____________________________________________ Date Of Installation: _________________ Cabinet Serial Number: _____________________________________________ Location Of Product Business Name: ____________________________________________________...