Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Beverage-Air WTR20HC
Summary of Contents for Beverage-Air WTR20HC
- Page 1 INSTALLATION AND OPERATING INSTRUCTIONS for all Hydrocarbon WTR Refrigerators 809-170A REV A 04/13/2022 SEE BACK COVER FOR 3779 CHAMPION BLVD, WINSTON-SALEM, NC 27105 WARRANTY REGISTRATION Phone: (888) 845-9800 | Fax: (800) 253-5168 | Web: beverage-air.com...
-
Page 2: Table Of Contents
If you meets the high standards set by Beverage-Air! You have have any questions, Please call our Technical Service made a quality investment that with proper maintenance Department at (800) 684-1195. -
Page 3: Safety
R290 equipment. • Clean a dirty condenser with a sharp object. • Use ONLY Beverage-Air factory service parts. Use of • Store gasoline, kerosene or any other flammable non OEM parts can be dangerous because of the design material near the cabinet. -
Page 4: Important Information
User Manual for WTR Refrigerators Beverage-Air IMPORTANT INFORMATION This unit is intended to be used in a commercial application. That includes bars and restaurants. If installed in a residence some commercial service companies may not be able to service it on site. -
Page 5: Product Information
Refrigerant Type / Base Model Door Type w x d x h (Inches) Count Amps Plug (NEMA) Charge g /Charge oz WTR20HC 20 x 24 1/2 x 36 1/8 Solid 1 door WTR20HC-25 20 x 25 x 36 1/8 Glass 1 door... -
Page 6: Clearance And Placement
User Manual for WTR Refrigerators Beverage-Air CLEARANCE AND PLACEMENT 0" 3 13/16" 2" LEFT/RIGHT SIDE BOTTOM REAR MINIMUM MINIMUM MINIMUM CLEARANCE CLAERANCE CLEARANCE Placement Consider the following when selecting a location for your Refrigerator: Clearance: • Must not be covered - Top •... -
Page 7: Unpacking And Set Up
User Manual for WTR Refrigerators Beverage-Air UNPACKING AND SET UP Carefully inspect the shipping carton for damage. This is the only time that shipping damage may be claimed. If damage is suspected, open the carton immediately and, if there is damage, retain the carton and contact the shipper to make a claim. -
Page 8: Electrical
User Manual for WTR Refrigerators Beverage-Air ELECTRICAL This is a cord-connected unit, and must be connected to its own dedicated power supply. Check the dataplate on the machine to confirm the voltage and per the dataplate use the correct fuses or HACR circuit breakers. -
Page 9: Using The Unit - Danfoss Controller
User Manual for WTR Refrigerators Beverage-Air USING THE UNIT - DANFOSS CONTROLLER Operation is simple, just keep it connected to the correct The temperature was set at the factory at 38 F, but º power supply and the refrigerator will maintain the you can adjust it to your own selected temperature. -
Page 10: Sequence Of Operations Refrigerator
User Manual for WTR Refrigerators Beverage-Air SEQUENCE OF OPERATIONS REFRIGERATOR 2 34 5 6 6 2 5 5 54 8 6 ... - Page 11 01 2 3 ÿ 56 78 6 9 ÿ 3 ÿ ÿ 9 ÿ 5 9 ÿ 9 2 3 ÿ 2 2 3 6 2 3 User Manual for WTR Refrigerators Beverage-Air Rev. 04/22 Beverage-Air ÿ...
- Page 12 01 2 3 ÿ 56 7 86 9 ÿ 3 ÿ ÿ 9 ÿ 5 9 ÿ 9 2 3 ÿ 2 2 3 6 2 3 User Manual for WTR Refrigerators Beverage-Air ! " ! # $ % ! & '( # ÿ Beverage-Air Rev.
- Page 13 User Manual for WTR Refrigerators Beverage-Air () * + , ÿ . / ÿ 0 1 0 2 3ÿ 4 5 6 1 7 8 9 : ; ÿ < 9 34 8 ÿ 0 2 4 ÿ 9 ; ÿ = 2 : > 2 4 8 8 ÿ ? @A @ÿ / : 1 C 4 2 ÿ : / ÿ < D 4 ÿ = 0 2 0 34 < 4 2 ÿ < 0 E 1 4 F G ÿ < D 4 ÿ 0 1 0 2 3ÿ 9 8 ÿ ; : < ÿ 8 9 > ; 0 1 4 C H ÿ...
-
Page 14: Using The Unit - Eliwell Controller
User Manual for WTR Refrigerators Beverage-Air USING THE UNIT - ELIWELL CONTROLLER Operation is simple, just keep it connected to the correct The refrigerator will automatically defrost as needed, power supply and the refrigerator will maintain the there is no set time for defrost. Push and immediately internal temperature it has been set to. -
Page 15: Sequence Of Operations Refrigerator
Refrigerator with Eliwell Controller Refrigerator with Eliwell Controller Beverage-Air Beverage-Air User Manual for WTR Refrigerators Beverage-Air SEQUENCE OF OPERATIONS REFRIGERATOR The refrigerator operates based on the air temperature measured by the probe located at the return air. CONTROLLER CONTROLLER COMPONENT... - Page 16 User Manual for WTR Refrigerators Beverage-Air Controller Symbols Reduced SET / Economy Permanently on: Energy Saving Mode Permanently on: Aux Active Flashing: Reduced Set Mode Flashing: Deep Cooling Cycle Active Quick Flashing: Access to level 2 parameters Compressor Defrost Permanently On: Compressor Active...
- Page 17 01 2 3 ÿ 56 7 8 6 9 ÿ 3 ÿ ÿ 9 ÿ 5 9 ÿ 9 2 3 ÿ 2 2 3 6 2 3 User Manual for WTR Refrigerators Beverage-Air ÿ ! " ! # $ % ! & '( # Rev.
-
Page 18: Cleaning And Maintenance
User Manual for WTR Refrigerators Beverage-Air CLEANING AND MAINTENANCE Cleaning Schedule: Cabinet Condenser coil Gaskets Routine maintenance Daily wipe down Quarterly cleaning Daily inspection Annually Weekly interior Daily Exterior Cleaning It is much easier to clean on a regular basis than to have to remove stains once they have built up. -
Page 19: Drawer Cleaning And Maintenance
User Manual for WTR Refrigerators Beverage-Air DRAWER CLEANING AND MAINTENANCE Drawer models are shipped with the drawers already installed in the cabinets. Drawers are designed with slides which have locking mechanisms to prevent drawers from coming off cabinets during normal opening and closing operations. -
Page 20: Condenser Cleaning
User Manual for WTR Refrigerators Beverage-Air CONDENSER CLEANING Keeping the condenser coil clean is critical to efficient the unit. operation. 6. To reinstall the rear panel line up the bottom of the The condenser coil is located right behind the back grille panel to the bottom of the unit keeping the screw of the cabinet. -
Page 21: Methods For Cleaning Stainless Steel
User Manual for WTR Refrigerators Beverage-Air METHODS FOR CLEANING STAINLESS STEEL Cleaning Needed Cleaning Agent Method of Application Affect on Finish Satisfactory for use on all Areal 20, Lac-O-Nu, Lumin Wash Rub with cloth as directed finishes. Smears and fingerprints O’Cedar Cream Polish, Stainless... -
Page 22: Help
User Manual for WTR Refrigerators Beverage-Air HELP Trouble Diagnosis for the User Malfunction Possible Cause Likely Solution Connect to proper voltage circuit Replace Unit not plugged in. fuse or reset breaker. No cooling - unit is silent Fuse or circuit breaker tripped. -
Page 23: For The Service Tech - R290
User Manual for WTR Refrigerators Beverage-Air FOR THE SERVICE TECH - R290 Refrigeration service should only be attempted by a trained trade professional certified to work on R290 systems. Here are some critical service items. Other Information: This list does not qualify anyone to service the unit. It is a Evacuation: It is critical that a refrigeration system be reminder and checklist for the service tech. -
Page 24: For The Service Tech - Wiring Diagrams
01 2 3 ÿ 56 7 8 6 9 ÿ 3 ÿ ÿ 2 2 3 6 2 3 User Manual for WTR Refrigerators Beverage-Air *+,ÿ ./0ÿ 10,23 40ÿ .04/ÿ 5 ÿ 63 ,3 78ÿ 93 :8,:; FOR THE SERVICE TECH - WIRING DIAGRAM DANFOSS CONTROLLER F L? P D N M @ @ ÿ... - Page 25 2 2 3 6 2 3 User Manual for WTR Refrigerators Beverage-Air ,-.ÿ 012ÿ 32.45 62ÿ 0261ÿ 7 ÿ 85 .5 9:ÿ ;5 <:.<=ÿ 2> 5 82> > ÿ 6-90.-> > 2. FOR THE SERVICE TECH - WIRING DIAGRAM ELIWELL CONTROLLER ! "...
-
Page 26: Limited Warranty
(87) months from the date of defective. shipment from Beverage-Air, provided upon receipt of the The labor warranty shall be for self-contained units compressor, manufacturer examination shows the sealed only and for standard straight time, which is defined as compressor to be defective. -
Page 27: Limited Warranty (Continued)
With the exception of Blast Chillers product is designed for LIMITATION OF LIABILITY: maintaining temperature and not bringing food to a desired Beverage-Air Corporation or their affiliates shall not be temperature therefore cannot be held responsible for this liable for any indirect, incidental, special or consequential function under warranty. - Page 28 User Manual for WTR Refrigerators Beverage-Air Warranty Registration Register your product online at beverage-air.com/parts-service or fill out and mail the form below. Cabinet Model Number: _____________________________________________ Date Of Installation: _________________ Cabinet Serial Number: _____________________________________________ Location Of Product Business Name: ____________________________________________________...