Related Manuals for progeo CARBOMAX
Summary of Contents for progeo CARBOMAX
- Page 1 S E R V I C E M A N U A L CARBOMAX SERVICE MANUAL Rev. 0 - 06/05/2020 ENGLISH Service Manual CARBOMAX 1 REHATEAM s.r.l.—vicolo Negrelli 5—31040 Castagnole di Paese TV - www.rehateamprogeo.com...
- Page 2 RehaTEAM® disclaims any responsibility for damage to the product or the peo- ple due to any modification that is not properly performed or that, in any case, does not guarantee safety to the user. Service Manual CARBOMAX 2 REHATEAM s.r.l.—vicolo Negrelli 5—31040 Castagnole di Paese TV - www.rehateamprogeo.com...
- Page 3 FOOTPLATE DISTANCE sliding system (until 2018) FLIP BACK FOOTPLATE BACKREST HEIGHT Aluminium or titanium backrest BACKREST HEIGHT Carbon fibre backrest BACKREST ANGLE QUICK RELEASE AXLE (rear wheel) Service Manual CARBOMAX 3 REHATEAM s.r.l.—vicolo Negrelli 5—31040 Castagnole di Paese TV - www.rehateamprogeo.com...
- Page 4 Pay attention to the spacers between caster and fork. It is advisable to spread a drop of mild lock thread glue on the bolts V. Service Manual CARBOMAX 4 REHATEAM s.r.l.—vicolo Negrelli 5—31040 Castagnole di Paese TV - www.rehateamprogeo.com...
- Page 5 It is advisable to spread a drop of mild lock thread glue on the bolts V. Service Manual CARBOMAX 5 REHATEAM s.r.l.—vicolo Negrelli 5—31040 Castagnole di Paese TV - www.rehateamprogeo.com...
- Page 6 Check the perpendicularity again and, if necessary, correct it. It is advisable to pread a drop of mild lock thread glue on all grab screws G. Service Manual CARBOMAX 6 REHATEAM s.r.l.—vicolo Negrelli 5—31040 Castagnole di Paese TV - www.rehateamprogeo.com...
- Page 7 If the wheelchair TURN LEFTT, the cause is one or more of the following: The LEFT fork is tilted inwardly and/or backward The RIGHT fork is tilted outwardly and/or frontward Follows next page Service Manual CARBOMAX 7 REHATEAM s.r.l.—vicolo Negrelli 5—31040 Castagnole di Paese TV - www.rehateamprogeo.com...
- Page 8 Until 2019 the axles had no inserts C0 or C1. There were 0°, 1°rh and 1°lh axles. To adjust the directionality, it is necessary to change the axle. SIDE VIEW Service Manual CARBOMAX 8 REHATEAM s.r.l.—vicolo Negrelli 5—31040 Castagnole di Paese TV - www.rehateamprogeo.com...
- Page 9 The rear height adjustment can also change the point of balance (setting) of the wheelchair. If necessary, adjust the setting. You will never need to modify the side guard. Part of the clamp B leaning against the plate Service Manual CARBOMAX 9 REHATEAM s.r.l.—vicolo Negrelli 5—31040 Castagnole di Paese TV - www.rehateamprogeo.com...
- Page 10 Following the instructions above mentioned, you can reach a particularly prudential setting up to 5 cm (with distance X = 0, rear support in contact with the backrest plate). Service Manual CARBOMAX 10 REHATEAM s.r.l.—vicolo Negrelli 5—31040 Castagnole di Paese TV - www.rehateamprogeo.com...
- Page 11 If the two measures are equal or the front one is slightly narrower (max. 5 mm), you have a good convergence as drawing 2 or 3. If different, you have to adjust the convergence.Se differente, è necessario regolare la campanatura. Follows next page Service Manual CARBOMAX 11 REHATEAM s.r.l.—vicolo Negrelli 5—31040 Castagnole di Paese TV - www.rehateamprogeo.com...
- Page 12 Check the measure from a fix point of the frame to the centre of the tyre on each side. Should there be a difference greater than 2-3 mm, check the distance between clamp and axle as above mentioned. If necessary, correct the adjustment. Service Manual CARBOMAX 12 REHATEAM s.r.l.—vicolo Negrelli 5—31040 Castagnole di Paese TV - www.rehateamprogeo.com...
- Page 13 In that case, it is necessary to move the rear wheel backward (point of balance) as much as necessary (see adjustment sheet ”setting”) Service Manual CARBOMAX 13 REHATEAM s.r.l.—vicolo Negrelli 5—31040 Castagnole di Paese TV - www.rehateamprogeo.com...
- Page 14 Start screwing the two bolts B all the way down and then the two nuts G. Should the brake movement be hard, slightly loosen the bolts B. Service Manual CARBOMAX 14 REHATEAM s.r.l.—vicolo Negrelli 5—31040 Castagnole di Paese TV - www.rehateamprogeo.com...
- Page 15 You can change the support C only if you cut the frame 3 cm and glue, with epoxy glue, the new support. ANTERIORE POSTERIORE Service Manual CARBOMAX 15 REHATEAM s.r.l.—vicolo Negrelli 5—31040 Castagnole di Paese TV - www.rehateamprogeo.com...
- Page 16 The height adjustment of the footplate can affect the directionality of the wheelchair, in fact, if the footplate is slightly tilted on either side, the wheelchair will go right or left. In such case, correct the height of the right or left tube. Service Manual CARBOMAX 16 REHATEAM s.r.l.—vicolo Negrelli 5—31040 Castagnole di Paese TV - www.rehateamprogeo.com...
- Page 17 Note: you can also fix the plate if you drill two holes aligned to the leaning points B and fix it with the two bolts C. At each adjustment, it is advisable to spread a drop of mild lock thread glue on the bolts C. Service Manual CARBOMAX 17 REHATEAM s.r.l.—vicolo Negrelli 5—31040 Castagnole di Paese TV - www.rehateamprogeo.com...
-
Page 18: Backrest Height
Note: if the backrest tube is in carbon fibre, follow the instructions of the adjustment sheet “backrest height—carbon fibre backrest”. The titanium backrest structure includes a plastic adaptor, just follow the same instructions above. Plastic adaptor Service Manual CARBOMAX 18 REHATEAM s.r.l.—vicolo Negrelli 5—31040 Castagnole di Paese TV - www.rehateamprogeo.com... - Page 19 The carbon fibre backrest tube is not suitable to fixing any clamps, such as those used for a postural system hardware. Note: if the backrest tube is assembled on a aluminium or titanium backrest structure, follows these same instructions. Service Manual CARBOMAX 19 REHATEAM s.r.l.—vicolo Negrelli 5—31040 Castagnole di Paese TV - www.rehateamprogeo.com...
-
Page 20: Backrest Angle
Remember that the backrest angle can affect the point of balance of the wheelchair. In fact, with tilted backward backrest (open angle), the wheelchair becomes less stable. Service Manual CARBOMAX 20 REHATEAM s.r.l.—vicolo Negrelli 5—31040 Castagnole di Paese TV - www.rehateamprogeo.com... -
Page 21: Quick Release Axle
Check and if necessary do the same with another half turn. Do not unscrew the button too much: the pin will come off and, consequently, the balls will fall to the ground. Service Manual CARBOMAX 21 REHATEAM s.r.l.—vicolo Negrelli 5—31040 Castagnole di Paese TV - www.rehateamprogeo.com...
Need help?
Do you have a question about the CARBOMAX and is the answer not in the manual?
Questions and answers