Kenmore 146.22124910 Use & Care Manual
  1. Manuals
  2. Brands
  3. Kenmore Manuals
  4. Grill
  5. 146.22124910
  6. Use & care manual
Kenmore 146.22124910 Use & Care Manual

Kenmore 146.22124910 Use & Care Manual

Liquid propane
Hide thumbs Also See for 146.22124910:
Table of Contents

Advertisement

Quick Links

Use & Care Guide
Manual de Uso y Cuidado
English / Español
Kenmore
®
Liquid Propane Gas Grill
Parrilla a gas de propano lí quido
Model/Modelo: 146.22124910
Item / Artí culo: 640-01998717-1
P/N 40600050Z
Sears Brands Management Corporation
Hoffman Estates, IL 60179 U.S.A.
www.kenmore.com
www.sears.com
www.kmart.com
®

Advertisement

Table of Contents
loading

Related Manuals for Kenmore 146.22124910

Summary of Contents for Kenmore 146.22124910

  • Page 1 Manual de Uso y Cuidado English / Español Kenmore ® Liquid Propane Gas Grill Parrilla a gas de propano lí quido Model/Modelo: 146.22124910 Item / Artí culo: 640-01998717-1 P/N 40600050Z Sears Brands Management Corporation Hoffman Estates, IL 60179 U.S.A. www.kenmore.com www.sears.com...

  • Page 2: For Your Safety

    CAUTION CAUTION For residential use only. Do not use for commercial cooking. CAUTION: Indicates a potentially hazardous situation or unsafe practice which, if not avoided, may result in minor or moderate injury. 2 • 146.22124910...

  • Page 3: Table Of Contents

    ..2 www.P65Warnings.ca.gov Safety Symbols ..2 Kenmore Grill Warranty ..4 Use and Care ..5-11 Parts List . . .

  • Page 4: Kenmore Grill Warranty

    This warranty applies only while this appliance is used in the United States. This warranty gives you specific legal rights, and you may also have other rights which vary from state to state. Sears Brands Management Corporation, Hoffman Estates, IL 60179 4 • 146.22124910...

  • Page 5: Use And Care

    Check the telephone directory which may become overheated by the sun. under “Gas Companies” for nearest certified LP dealers. • Do not store an LP tank in an area where children play. 146.22124910 • 5...
  • Page 6 5. Hold regulator and insert nipple into LP tank valve. Hand-tighten the coupling nut, holding regulator in a straight line with LP tank valve so as not to crossth- thread the connection. Nipple has to be centered into the LP tank valve. 6 • 146.22124910...
  • Page 7 • If a leak is detected at any time, STOP and call the fire department. • If you cannot stop a gas leak, immediately close LP cylinder valve and call LP gas supplier or your fire department! 146.22124910 • 7...
  • Page 8 Once burners are lit, adjust knobs to desired flame setting. To extinguish an individual burner, turn its knob to OFF. To ignite the Side Burner, follow steps 3-5 using the Side Burner knob. If igniter does not work, follow Match Lighting instructions 8 • 146.22124910...
  • Page 9 Use nonabrasive scouring powder for stubborn stains. • Painted surfaces: Wash with mild detergent or nonabrasive cleaner and warm soapy water. Wipe dry with a soft nonabrasive cloth. 146.22124910 •9...
  • Page 10 9. Attach burners to brackets with cotter pin. See Fig. B next page. venturi assembly should be removed from the grill and cleaned 10. Replace heat diffusers and cooking grates before use whenever the grill has been idle for an extended period. 146.22124910 •...
  • Page 11 • Place food over unlit burner(s). Ground * United States Department of Agriculture **Allow meat to rest three minutes before carving or consuming. 2 Burner Cooking Great indirect cooking on low. Produces slow, even heating. Ideal for slow roasting and baking. 146.22124910 • 11...

  • Page 12: Parts List

    To order replacement parts after using grill, call 1-844-553-6667. NOTES: Some grill parts shown in the assembly steps may differ slightly in appearance from those on your particular grill. However, the method of assembly remains the same. 12 • 146.22124910...

  • Page 13: Parts Diagram

    PARTS DIAGRAM 146.22124910 • 13...

  • Page 14: Before Assembly

    BEFORE ASSEMBLY NOTICE: Once you have unpacked the grill according to the STOP SHEET instructions, check all grill parts against the pictures on this and the following two pages. If any parts are missing or damaged, call 1-888-287-0735. 14 • 146.22124910...
  • Page 15 BEFORE ASSEMBLY 146.22124910• 15...
  • Page 16 BEFORE ASSEMBLY 16• 146.22124910...

  • Page 17: Assembly

    The following hardware is provided in blister pack for convenient use. M4X10 screw AA Battery Qty: 54 pcs Qty: 1 pc M5X10 screw M5 flat washer Qty: 4 pcs Qty: 4 pcs M6X13 screw M6 compression washer Qty: 16 pcs Qty: 4 pcs 146.22124910 • 17...
  • Page 18 □ Attach the other end of Side Upper Rail and Side Lower Rail to the “5B” Leg and tighten the screws. Install and tighten another (1)M4X10 Screw to the Side Upper Rail. (D) M4x10 screws Qty: 10 pcs 18 • 146.22124910...
  • Page 19 □ Attach the other end of Side Upper Rail and Side Lower Rail to the “5D” Leg and tighten the screws. Install and tighten another (1)M4X10 Screw to the Side Upper Rail. (D) M4x10 screws Qty: 10 pcs 146.22124910 • 19...
  • Page 20 □ Attach Bottom Shelf to Right Frame with (3) M4X10 screws. Do not yet fully tighten these screws. □ Attach Bottom Shelf to Left Frame with (3) M4X10 screws. Do not yet fully tighten these screws. (B) M4x10 screws Qty: 14 pcs 20 • 146.22124910...
  • Page 21 Fully tighten other end of bar to the rear Left Frame with (1)M4 × 10 Screws as shown. Install and fully tighten (1) M4X10 screw through the middle screw hole on the bottom of the front panel into the bottom shelf. (D M4x10 screws Qty: 4 pcs 146.22124910 • 21...
  • Page 22 Note: The convex side of the wheel must face to the cart, and the concave side must face outward. □Stand cart right side up and fully tighten the (6) M4X10 bottom shelf screws. (D) Attach Tank Baffle as shown with (2) M4X10 screws. (D) M6X13 screw Qty: 4 pcs M4X10 screw Qty: 2 pcs 22• 146.22124910...
  • Page 23 □ Carefully lower the grill head onto the cart. Make sure the regulator hose and igniter wire are hanging outside the cart. □ Line up control panel so that it is flush with front panels. Attach head to cart with (4) M6X13 screws. M6X13 screw Qty: 4 pcs 146.22124910 • 23...
  • Page 24 □ Attach fascia to control panel with (1) M4x10 screw. (D) M5X10 screw Qty: 2 pcs M5 flat washer Qty: 2 pcs M6X13 screws Qty: 4 pcs M6 compression washer Qty: 2 pcs M4X10 screw Qty: 5 pcs 24• 146.22124910...
  • Page 25 □ Attach fascia to control panel with M4x10 screw. (D) M5X10 screw Qty: 2 pcs M5 flat washer Qty: 2 pcs M6X13 screws Qty: 4 pcs M6 compression washer Qty: 2 pcs M4X10 screw Qty: 5 pcs 146.22124910 • 25...
  • Page 26 □ Unscrew igniter cap from control panel. Insert (1) AA battery (provided in blister pack) into battery slot with positive end (+) facing outward. Screw igniter cap back onto panel. (L) 26• 146.22124910...
  • Page 27 □ Place Heat Diffusers over burners. Diffusers will fit in firebox in either direction. □ Place Cooking Grates onto grate rests at front and rear of Firebox. □ Insert warming rack into brackets at top of Firebox with Curved edge to front as shown. 146.22124910 • 27...
  • Page 28 Fit Drip Cup into Drip Cup Clip. Insert Match Holder Chain into hole in Front Left Leg. (B) □ Place LP tank into hole in bottom shelf with tank collar opening facing to side as shown.(C M4X10 screw Qty: 4 pcs 28 • 146.22124910...

  • Page 29: Troubleshooting

    • Wires are loose or disconnected. • Reconnect wires or replace electrode/wire assembly. • Wires are shorting (sparking) between • Replace igniter wire/electrode assembly. igniter and electrode. • Replace with a new AA-size alkaline battery. • Dead battery. 146.22124910 • 29...
  • Page 30 • Some dealers have older fill nozzles valve. Try a second LP dealer. cylinder. with worn threads. • Clean carry-over tube(s) with wire brush. • Drip buildup or food particles in One burner does not end(s) of carryover tube(s). light from other burner(s). 30• 146.22124910...
  • Page 31 • Has moisture • Use paper towel to remove moisture. accumulated on electrode and/or in burner ports? • Electrode(s) • Inspect electrodes for • Replace cracked or broken electrodes. cracked or broken; cracks. sparks appear where cracked. 146.22124910 • 31...
  • Page 32 Kenmore ® Customer Care Hotline To schedule in-home repair service or order replacement parts Para pedir servicio de reparación a domicilio, y ordenar piezas 1-844-553-6667 www. kenmore. com ®...

Table of Contents