Vogelzang International VG1820 Owner’s Instruction And Operation Manual
  1. Manuals
  2. Brands
  3. Vogelzang International Manuals
  4. Wood stove
  5. VG1820
  6. Owner’s instruction and operation manual

Vogelzang International VG1820 Owner’s Instruction And Operation Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

Owner's Instruction and Operation Manual
Model Number:
VG1820
Report Number: F19-552
Tested Per EPA Methods ALT-125, ASTM E2515,
ASTM E3053 and CSA B415
Certified to: UL 1482-2011 (R2015), ULC-628-93
Do not install this heater in a mobile home or trailer.
* All Pictures In This Manual Are For Illustrative Purposes Only. Actual Product May Vary.
SAFETY NOTICE: If this heater is not properly installed, a house fire may result. For
your safety, follow the installation instructions. Never use make-shift compromises
during the installation of this heater. Contact local building or fire officials about
permits, restrictions and installation requirements in your area. NEVER OPERATE THIS
PRODUCT WHILE UNATTENDED.
CAUTION! Please read this entire manual before you install or use your new room
heater. Failure to follow instructions may result in property damage, bodily injury, or
even death. Improper Installation Will Void Your Warranty!
U.S. Environmental Protection Agency
Certified to comply with 2020 particulate
emissions standards.
© 2021 United States Stove Company, 227 Industrial Park Rd., South Pittsburg, TN 37380
R
Save These Instructions In A Safe Place For Future Reference.
THIS MANUAL IS SUBJECT TO CHANGE WITHOUT NOTICE.
CALIFORNIA PROPOSITION 65 WARNING:
This product can expose you to chemicals
including carbon monoxide, which is known to the
State of California to cause cancer, birth defects,
and/or other reproductive harm. For more
information, go to
853653D-1805K
www.P65warnings.ca.gov
Ph. 800-750-2723

Advertisement

Table of Contents
loading

Related Manuals for Vogelzang International VG1820

Summary of Contents for Vogelzang International VG1820

  • Page 1 Owner’s Instruction and Operation Manual Model Number: VG1820 Report Number: F19-552 Tested Per EPA Methods ALT-125, ASTM E2515, ASTM E3053 and CSA B415 Certified to: UL 1482-2011 (R2015), ULC-628-93 Do not install this heater in a mobile home or trailer.
  • Page 2 The instructions pertaining to the installation of your wood stove comply with UL 1482-2011 (R2015) and ULC-628-93 standards. This manual describes the installation and operation of the Vogelzang, VG1820 wood heater. This heater meets the 2020 U.S. Environmental Protection Agency’s crib wood emission limits for wood heaters sold after May 15, 2020.

  • Page 3: Installation Checklist

    INSTALLATION CHECKLIST Your wood stove should be installed by a qualified installer only. An NFI qualified Installer can be found at www.nficertified. org/public/find-an-nfi-pro/ CUSTOMER SERVICE 1-800-750-2723 ext 5050 Text to 423-301-5624 Email to: Customerservice@usstove.com COMMISSIONING CHECKLIST This Checklist is to be completed in full by the qualified person who installs this unit. Keep this page for future reference. Failure to install and commission according to the manufacturer’s instructions and complete this checklist will invalidate the warranty.

  • Page 4: Firebrick Installation

    ASSEMBLY INSTRUCTIONS FOR CUSTOMER SERVICE CALL: 800-750-2723 EXT 5050 FIREBRICK INSTALLATION 1. Lay pieces face down on carpet or other soft surface to protect finish during assembly. The Surround consists of two side panels, a top panel, and a decorative trim CAUTION: RISK OF FIRE! frame.

  • Page 5: Installation

    INSTALLATION SAFETY NOTICE • IF THIS STOVE IS NOT PROPERLY INSTALLED, A HOUSE FIRE MAY RESULT. TO REDUCE THE RISK OF FIRE, FOLLOW THE INSTALLATION INSTRUCTIONS. • CONSULT YOUR MUNICIPAL BUILDING DEPARTMENT FIRE OFFICIALS ABOUT PERMITS, RESTRICTIONS AND INSTALLATIONS REQUIREMENTS IN YOUR AREA. •...

  • Page 6: Outside Combustion Air

    INSTALLATION is a fresh air kit (4FAK) available for purchase from your local stove dealer. When installed properly the 4FAK kit is designed to provide the draft needed for proper operation. To achieve proper draft your chimney must meet the three minimum height requirements (see masonry chimney section of this manual).
  • Page 7 INSTALLATION VENTING (DRAFT) REQUIREMENTS parts that can be easily replaced (i.e. damper parts, screens, doors and side, and back refractory panels) RAIN CAP COVER PLATE are to be removed. These parts must be stored and (non-combustible) STORM readily available for replacement if the appliance is seal cover plate COLLAR with silicone.

  • Page 8: Chimney Draft

    INSTALLATION using a minimum of three (3) screws at each connection. stainless steel adapter and securing with a minimum Chimneys outside of the home or on an exterior wall are of three (3) sheet metal screws. The liner MUST difficult to keep at operating temperatures and may result be attached with the male (or crimped) end of the in increased creosote buildup, less draft, back drafting adapter inside the flue collar of the appliance to allow...

  • Page 9: Importance Of Proper Draft

    INSTALLATION IMPORTANCE OF PROPER DRAFT WARNING: Draft is the force which moves air from the appliance up PERMANENTLY SEAL ANY OPENING BETWEEN THE through the chimney. The amount of draft in your chimney MASONRY OF THE FIREPLACE AND THE FACING depends on the length of the chimney, local geography, MASONRY.
  • Page 10 OPERATION INSTRUCTIONS NEVER OPERATE THIS PRODUCT WHILE UNATTENDED OPERATING SAFETY PRECAUTIONS CAUTIONS: • NEVER OVERFIRE THIS APPLIANCE BY BUILDING CHILDREN SHOULD BE ALERTED TO THE HAZARDS EXCESSIVELY HOT FIRES AS A HOUSE/BUILDING FROM HIGH SURFACE TEMPERATURES. NEVER LEAVE FIRE MAY RESULT. YOU ARE OVERFIRING THE SMALL CHILDREN UNSUPERVISED WHEN THEY ARE APPLIANCE IF IT BEGINS TO GLOW OR TURN RED.
  • Page 11 OPERATION INSTRUCTIONS 5. Waste petroleum products, paints or paint thinners, or burn manufactured asphalt products; logs made of wax impregnated sawdust or logs with any chemical 6. Materials containing asbestos; additives. Manufactured logs made 7. Construction or demolition debris; of 100% compressed sawdust can be 8.

  • Page 12: Fueling Instructions

    OPERATION INSTRUCTIONS learn the burn characteristic of you appliance and burn meet strict 2020 guidelines. To ensure this unit produces well-seasoned wood. Higher burn rates are not always the the optimal minimum emissions it is critical that only best heating burn rates; after a good fire is established a well-seasoned cordwood is burned (see the “Fuel lower burn rate may be a better option for efficient heating.

  • Page 13: Air Tubes

    OPERATION INSTRUCTIONS VISIBLE SMOKE Leave the air control fully open (in the “HI” position) for 15 minutes. After 15 minutes rotate the air control to the The amount of visible smoke being produced can be medium position (midway between the “Low” and “Hi” an effective method of determining how efficiently the position).

  • Page 14: Creosote Formation And Need For Removal

    CHIMNEY MAINTENANCE NEVER OPERATE THIS PRODUCT WHILE UNATTENDED CAUTION: CAUTION: DO NOT OVERFIRE APPLIANCE. YOU ARE OVERFIRING A CHIMNEY FIRE MAY CAUSE IGNITION OF WALL IF ANY PART OF THE APPLIANCE GLOWS RED. CLOSE STUDS OR RAFTERS WHICH WERE ASSUMED TO THE DOOR AND SHUT DAMPER IMMEDIATELY TO BE A SAFE DISTANCE AWAY FROM THE CHIMNEY.

  • Page 15: Glass Care

    CHIMNEY MAINTENANCE SMOKE & CO MONITORS This unit’s door uses a 1” diameter rope gasket. It is recommended that you change the door gasket (which Burning wood naturally produces smoke and carbon makes your stove door air tight) once a year, in order to monoxide(CO) emissions.

  • Page 16: Wiring Diagram

    WIRING DIAGRAM FEMALE MALE BLACK WHITE BLACK BLACK BLOWER MALE MALE RHEOSTAT BLOWER FEMALE MOTOR GREEN FEMALE ATTACH TO BACK OF BLOWER HOUSING CAUTION! WARNING! DO THE BLOWER ASSEMBLY NOT ROUTE THE MUST BE DISCONNECTED SUPPLY CORD FROM THE SOURCE OF NEAR OR ACROSS ELECTRICAL SUPPLY HOT SURFACES!

  • Page 17: Repair Parts

    REPAIR PARTS Part # Description 892294 Hinge Pin 892176 Top Trim 40571 Hinge Block 892177 Hearth Plate Trim 83913 Extension Spring 80857 Assembly, Blower 26269 Top Surround 611008 Right Cabinet 26270 Side Surround 893261 Damper Slide 891992-1 Surround Trim-R 29301 Slide Brace 891992-2 Surround Trim-L 893261...
  • Page 18 REPAIR PARTS Part # Description 893241-VG Complete Door Handle 40881 Medium Sq Cast Door 88324 1” Round Rope Gasket 5.5ft 29211 Side Glass Clamp 29210 Top/Bottom Glass Clamps 893154 Glass 29230 Gasket Clamp 29231 Side Glass Clamp To order parts: Call 1-800-750-2723 Ext 5051 or Email to: parts@usstove.com Part #...

  • Page 19: Service Record

    SERVICE RECORD It is recommended that your heating system is serviced regularly and that the appropriate Service Interval Record is completed. SERVICE PROVIDER Before completing the appropriate Service Record below, please ensure you have carried out the service as described in the manufacturer’s instructions.
  • Page 20 NOTES © 2021 United States Stove Company...
  • Page 21 NOTES © 2021 United States Stove Company...

Table of Contents