Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Cal Flame P4
Summary of Contents for Cal Flame P4
- Page 1 LTR50001137, Rev. Q 7/29/20...
-
Page 2: Table Of Contents
Troubleshooting . . . . . . . . . . . . . . . . . . . . . 29 without written consent is strictly prohibited. Cal Flame™ is Converting from LP to NG . -
Page 3: Safety Instructions
Do not use an extension cord to supply power to kept clean and free from flammable liquids and your Cal Flame™ grill. Such use may result in fire, other combustible materials such as mops, rags or electrical shock or other personal injury. Do not brooms, as well as solvents, cleaning fluids, and install a fuse in the neutral or ground circuit. -
Page 4: Maintenance And Repair
• Never allow children to sit or stand on any part of it has fully cooled. Never wear loose fitting or the grill. P4, P5, and P6 Barbecue Grills LTR50001137, Rev. Q www.cal amebbq.com... -
Page 5: Proper Location Of The Grill
To reduce the risk of personal injury caused by reaching over a hot appliance, avoid locating cabinet When planning your Cal Flame grill location, access to gas lines and 110V power supplies should be storage space directly above the outdoor grill. -
Page 6: Built-In Construction
The Cal Flame convection grill is expected to be used with a Cal Flame barbecue island. If the convection Failure to follow these instructions may result in voiding grill is not placed in a Cal Flame barbecue island, it your warranty, property damage, injury, or death. Construction materials LMS will not be held responsible for property damage, injury, or death as a result of locating a grill enclosure in a non-approved location or using non-approved construction materials . -
Page 7: Built-In Dimensions
WIDTH DEPTH HEIGHT Minimum WIDTH Clearance 12” Minimum Distance Between Grill and Side Burner The dimensions shown below are for Cal Flame appliances only. DEPTH Model Description Width Depth Height BBQ19P04 P4 Premium Four Burner Grill 22”... - Page 8 DEPTH HEIGHT Minimum Clearance Built-in Dimensions cont . The dimensions shown below are for Cal Flame appliances only. Model Description Width Depth BBQ18953P Side By Side Flat Burner 24 ¼” 19 ¾” BBQ18852P Single Flat Side Burner 11 ½” 17 ¾”...
-
Page 9: Enclosure Ventilation
LP-gas supply square inches (254 square mm). If the ventilation cylinder in place. openings at floor level are in a side wall, there shall P4, P5, and P6 Barbecue Grills LTR50001137, Rev. Q www.cal amebbq.com... -
Page 10: Gas And Electrical Supply Requirements
Gas Requirements Gas Requirements and Connection IMPORTANT: The Cal Flame grill is manufactured to operate on liquid propane (LP). However, it can be converted to operate on natural gas (NG) by an authorized service technician. This barbecue grill does not include the parts for converting to NG. The gas conversion kit can be ordered separately. -
Page 11: Electrical Supply Requirements
0.5 psi (3.5 kPa). P4, P5, and P6 Barbecue Grills LTR50001137, Rev. Q www.cal amebbq.com... -
Page 12: Installation And Connection
Perform the leak test procedure as described earlier • If gas line connections are accessible when the in this manual. grill is installed, slide the grill into the cut out and then attach the gas lines. P4, P5, and P6 Barbecue Grills LTR50001137, Rev. Q www.cal amebbq.com... - Page 13 3.b. Slide the grill forward about six inches and connect the gas line to the grill using the appropriate connection for your gas type. Natural Gas Liquid Propane P4, P5, and P6 Barbecue Grills LTR50001137, Rev. Q www.cal amebbq.com...
- Page 14 Connect the flex line from the T connector to the 1/2” to 3/8” flare reducer fitting on the side burner gas line. No regulator is required for either LP or NG. P4, P5, and P6 Barbecue Grills LTR50001137, Rev. Q...
-
Page 15: Leak Testing Procedure
Do not use the appliance until the leak is corrected. 4. Apply the leak-testing solution by spraying it on joints of the gas delivery system. Blowing P4, P5, and P6 Barbecue Grills LTR50001137, Rev. Q www.cal amebbq.com... -
Page 16: Attaching The Rotisserie Motor
Slide the rotis motor on one of the brackets as shown below. The rotis motor will work on either side of the grill. P4, P5, and P6 Barbecue Grills LTR50001137, Rev. Q www.cal amebbq.com... -
Page 17: Using Your Grill
Do not use grill, side shelves, cabinets, Remember to use your Cal Flame grill safely by or any area around grill to store flammable following these reminders: materials. -
Page 18: Grill Controls
CAUTION: NEVER spray water on a hot gas unit. This may damage porcelain or cast iron components. Grill Controls The controls shown below are for the P4, P5, and P6 drop-in grills. Familiarize yourself with these controls before lighting your grill. -
Page 19: Lighting The Burners
Ensure the propane cylinder, regulator, and rubber it must be replaced prior to using the grill. If you hose are installed in a location not subject to heat- need a replacement hose, contact your Cal Flame ing above 125º F (51º C). dealer. -
Page 20: Proper Burner Flame
Note: Flame that is mostly yellow or golden in color is often due to foreign matter in the burner. You may need to clean your burners. See page 26 for instruction on removing and cleaning your burners. P4, P5, and P6 Barbecue Grills LTR50001137, Rev. Q www.cal amebbq.com... -
Page 21: Heat Distribution On The Cooking Grates
Heat Distribution on the Cooking Grates When you place food your Cal Flame grill, remember that the back of the grill tends to be hotter than the front. As your food cooks, you should periodically shift it to different spots on the cooking grates to ensure everything cooks evenly without burning. -
Page 22: Cooking With The Rotisserie
The rotisserie motor has an ON / OFF switch that controls the single-speed motor. rotisserie rotates in both directions. change direction by turning it off and turning it back on again. P4, P5, and P6 Barbecue Grills LTR50001137, Rev. Q www.cal amebbq.com... -
Page 23: Optional Grill Accessories
Pizza Brick Tray You can use your grill as a pizza oven using the pizza brick tray. Made of stone and stainless steel, it fits on any Cal Flame grill and is large enough to cook a large sized pizza. -
Page 24: Charcoal Tray
Charcoal Tray Use Turn part of your Cal Flame grill into a charcoal and gas grill. Turn off the gas and wait for the grill to cool before setting the Charcoal Tray in place. Placement 1. Remove two grates (left or right side) and the flame tamers (the angular metal pieces covering the burners). -
Page 25: Cleaning And Maintenance
Using a clean terry cloth or paper towel, polish the appliance by rubbing with the P4, P5, and P6 Barbecue Grills LTR50001137, Rev. Q www.cal amebbq.com... -
Page 26: Rust Removal
Sheila Shine or WD-40 as a surface The burners can be removed by removing the protectant. locking pins and lifting them out. The locking pins P4, P5, and P6 Barbecue Grills LTR50001137, Rev. Q www.cal amebbq.com... -
Page 27: Covering Your Grill
(See your just as you would for any cooking equipment. A local Cal Flame dealer for details.) The cover will help stiff wire brush or steel wool may also be helpful in protect your grill from detrimental effects of weather removing grime and food deposits. -
Page 28: Seasonal Cleaning
Inspect each burner for damage, such as cracks and holes. If any damage is found, don’t use the grill until you replace the burner. P4, P5, and P6 Barbecue Grills LTR50001137, Rev. Q www.cal amebbq.com... - Page 29 When you replace the burners, you don’t need to replace the locking pins. 7 . Replace the components Put all of the components back as they were, as shown in step 1. P4, P5, and P6 Barbecue Grills LTR50001137, Rev. Q www.cal amebbq.com...
-
Page 30: Light Bulb Replacement
WARNING: Never touch halogen bulbs with your bare fingers. Use a tissue or a small piece of paper to handle bulbs. Oils from your hands will damage halogen bulbs. Cal Flame grills use two different types of light housings. These instructions describe how to change the bulb in both types. -
Page 31: Appendix
If the flame is golden or yellow in color, the reason could be seasoning salts, oil film, or other foreign matter on the burner. P4, P5, and P6 Barbecue Grills LTR50001137, Rev. Q... - Page 32 Reinstall the orifice, reinstall the burners over the orifices, and seat each burner peg into position hole at the bottom ledge of the firebox. • Replace cooking components and grease collectors. If an obstruction is suspected in the control valve, contact your local Cal Flame dealer for assistance. Problem: Misalignment of Igniter on Burner Solution: •...
-
Page 33: Converting From Lp To Ng
All Cal Flame grills are manufactured as standard liquid propane (LP) grills and can be converted to burn natural gas (NG). However, Cal Flame P4, P5, and P6 grills do not include a conversion kit and it must be ordered separately. - Page 34 You do not need to replace the locking pins. They are used to keep the burners in place during shipping and are not necessary to operate your grill. P4, P5, and P6 Barbecue Grills LTR50001137, Rev. Q www.cal amebbq.com...
- Page 35 Tighten the orifice with the wrench. If you have dual infrared burners, repeat the previous steps for the second burner. g. Replace the back cover. P4, P5, and P6 Barbecue Grills LTR50001137, Rev. Q www.cal amebbq.com...
-
Page 36: Installing Sear Zone Burners
11. Reconnect or turn on the gas line. other burners. If you want to change Sear Zone burners to regular burners, just follow the above procedure above in a similar way. P4, P5, and P6 Barbecue Grills LTR50001137, Rev. Q www.cal amebbq.com... -
Page 37: Wiring Diagram
TRANSFORMER PLUG WHITE GREEN QUICK CONNECTOR QUICK WHITE CONNECTOR HALOGEN LIGHT HALOGEN LIGHT NOTE: USE TERMINAL CONNECTORS TO ALL WIRE ENDS THAT CONNECT TO ALL ELECTRICAL COMPONENTS. NO SOLDERING. P4, P5, and P6 Barbecue Grills LTR50001137, Rev. Q www.cal amebbq.com... -
Page 38: P6 Dimensions
P6 Dimensions P4, P5, and P6 Barbecue Grills LTR50001137, Rev. Q www.cal amebbq.com... -
Page 39: Replacement Parts
Replacement Parts See following page for part numbers. To order replacement parts: • contact authorized selling dealer. • Call LMS Customer Service at (800) 225-7727. • Visit us at www.quickbbqparts.com. P4, P5, and P6 Barbecue Grills LTR50001137, Rev. Q www.cal amebbq.com... - Page 40 BBQ18856P6 Flame tamer BBQ04103010-CC 2” knob BBQ04101028 4 burner BBQ08100657-CC Warming rack 5 burner BBQ08100658 6 burner BBQ18P06-WRACK Cal Flame logo BBQ04100972 Back burner electrode BBQ04101809 Hood hinge BBQ04101257 P4, P5, and P6 Barbecue Grills LTR50001137, Rev. Q www.cal amebbq.com...
- Page 41 BBQ13867 4 burner BBQCP4-B Grill cover (not shown) 5 burner BBQCP4-B 6 burner BBQCP6 4 burner BBQ07101045 Gas conversion kit (LP to NG) 5 burner BBQ07101045 6 burner BBQ07101045-P6 P4, P5, and P6 Barbecue Grills LTR50001137, Rev. Q www.cal amebbq.com...
-
Page 42: Limited Warranty
Limited Warranty This Limited Warranty is extended to the original purchaser of a Cal Flame P4, P5, or P6 grill manufactured after January 1, 2020 and installed for residential use in the United States and Canada. 10 Year Structure Cal Flame grill structure or frame housing is warranted against rust-through, due to defects in material or workmanship in normal household use for ten years from the original date of purchase. - Page 43 Warranty Limitations any defect covered by this limited warranty, including This Limited Warranty is void if Cal Flame or its without limitation, loss of use of the grill and cost for designated representative determines that the grill...
- Page 44 Locating the product serial number The serial number of your Cal Flame grill is located on the back and is visible when the hood is down. You will need this number to properly register your grill and activate coverage. Write this information in the space provided below.