Related Manuals for Ford FPWG2700H-J-EU
Summary of Contents for Ford FPWG2700H-J-EU
- Page 1 FPWG2700H-J-EU / FPWG3100H-J-EU Fig.A1 Copyright © 2016 P a g e www.fordpowerequipment.co.uk...
- Page 2 FPWG2700H-J-EU / FPWG3100H-J-EU Fig. A2 Copyright © 2016 P a g e www.fordpowerequipment.co.uk...
-
Page 3: Table Of Contents
FPWG2700H-J-EU / FPWG3100H-J-EU APPLICATION ..............5 DESCRIPTION (FIG. A1 & A2) ..........5 PACKAGE CONTENT LIST ............ 6 Unpacking ................... 6 SAFETY SYMBOLS ............... 7 SAFETY INSTRUCTIONS ............7 ATTACHING WHEEL ASSEMBLY (SEE FIG. 1) ..... 10 ATTACHING FOOT ASSEMBLY (SEE FIG. 1) ....... 10 RAISING HANDLE (SEE FIG. - Page 4 FPWG2700H-J-EU / FPWG3100H-J-EU MOVING THE PRESSURE WASHER ........16 MAINTENANCE ..............17 PRE-OPERATION STEPS ............ 17 REMOVE DEBRIS ............... 17 AFTER EACH USE ............... 17 MAINTENANCE SCHEDULE ..........17 CHANGING ENGINE OIL ............ 18 CHECKING DETERGENT SIPHONING TUBE ......18 HIGH PRESSURE HOSE ............
-
Page 5: Application
8.7 l/min. (FPWG2700H-J-EU) / 9.5 l/min. (FPWG3100H-J-EU). This high end residential use system features a 180 CC (FPWG2700H-J-EU) / 208 CC (FPWG3100H- J-EU)engine, no-flat, foam filled tires, 7.5 m high pressure hose and 4 (FPWG2700H-J-EU) / 6 (FPWG3100H-J-EU) quick-connect nozzles. -
Page 6: Package Content List
Extension wand with quick-connect fitting High pressure hose FPWG2700H-J-EU : 4pcs Spray nozzles : 0°, 25°, 40° and soap nozzle. FPWG3100H-J-EU : 6pcs Spray nozzles : 0°, 15°, 25°, 40° ,soap nozzle, rotating (turbo) nozzle Wheels (2pcs) ... -
Page 7: Safety Symbols
FPWG2700H-J-EU / FPWG3100H-J-EU 4 SAFETY SYMBOLS The following symbols are used in this manual and/or on the machine: Indicates potentially hazardous situation which could result serious injury death WARNING ! Never point the jet at avoided. people, animals, the device itself or live... - Page 8 FPWG2700H-J-EU / FPWG3100H-J-EU Do not use the machine within range of persons unless they wear protective clothing. Spray from this unit has extreme pressure and can ricochet back splashing water or propelling objects towards eyes. Never substitute eye protection with dry condition goggles.
- Page 9 FPWG2700H-J-EU / FPWG3100H-J-EU WARNING! For gas or oil-heated machines it is important to provide adequate ventilation and make sure that the flue gases are properly discharged. WARNING! Incorrect fuels shall not be used as they may prove hazardous WARNING! Never spray near a power source such as an electrical outlet.
-
Page 10: Attaching Wheel Assembly (See Fig. 1)
FPWG2700H-J-EU / FPWG3100H-J-EU When adding or draining fuel, unit should be turned off for at least 2 minutes to cool before removing fuel cap. If unit has been running then the fuel cap is under pressure, remove slowly. To keep fuel from spilling, secure unit so it cannot tip while operating or transporting. -
Page 11: Attaching High Pressure Hose Hook (See Fig. 4)
FPWG2700H-J-EU / FPWG3100H-J-EU 10 ATTACHING HIGH PRESSURE HOSE HOOK (SEE FIG. 4) Align the hole of the high pressure hose hook to hole on the handle bar. Install four self-tapping screws, until the screws are snug. 11 ATTACHING ACCESSORY HOOK (SEE FIG. 4) Align the accessory hook with the holes. -
Page 12: Adding / Checking Engine Oil (See Fig. 7)
FPWG2700H-J-EU / FPWG3100H-J-EU 13 ADDING / CHECKING ENGINE OIL (SEE FIG. 7) Place pressure washer on a level surface. Remove one or both of the crankcase dipsticks to ensure you do not overfill the engine. Carefully add 520 ml (17.6 oz) of 4-Cycle engine oil (SAE10W30) to empty reservoir until oil ... -
Page 13: Connecting Garden Hose To Pressure Washer (See Fig 9)
FPWG2700H-J-EU / FPWG3100H-J-EU 15 CONNECTING GARDEN HOSE TO PRESSURE WASHER (SEE FIG 9) Run water through the hose for a few seconds to flush any debris from the hose. Inspect inlet screen and remove any debris. Connect hose to water inlet and tighten by hand. There must be a minimum of 10 feet of ... -
Page 14: Pre-Operation Check List
FPWG2700H-J-EU / FPWG3100H-J-EU 17 PRE-OPERATION CHECK LIST Read and understand this operator manual in its entirety before operating pressure washer. Check oil level and add oil to the proper level if low. Check fuel level and add fuel if needed. -
Page 15: Stopping Pressure Washer (See Fig. 13)
FPWG2700H-J-EU / FPWG3100H-J-EU WARNING! Risk of Injection or Injury – Do Not Direct Discharge Stream At Persons. This pressure washer is equipped with a thermal relief valve (TRV). The TRV is a temperature actuated valve that will open and allow cool water to pass from the garden hose through the pump head to cool the head if the pump reaches 60 °C (140 °F). -
Page 16: Using Spray Nozzle (See Fig. 16)
FPWG2700H-J-EU / FPWG3100H-J-EU 21 USING SPRAY NOZZLE (SEE FIG. 16) To connect or disconnect spray tip, pull back on the quick- connect collar. Insert or remove spray tip then release collar. Spray wand When spray tip is connected, pull on the spray tip to make sure ... -
Page 17: Maintenance
FPWG2700H-J-EU / FPWG3100H-J-EU 25 MAINTENANCE Regular maintenance will extend the life of this pressure washer and improve its performance. The warranty does not cover items that result from operator negligence, misuse, or abuse. To receive full value from the warranty, operator must maintain the pressure washer as instructed in this manual, including proper storage. -
Page 18: Changing Engine Oil
FPWG2700H-J-EU / FPWG3100H-J-EU 30 CHANGING ENGINE OIL Engine oil will drain better if the engine is still warm, but not hot. Shut off engine. Clean the area around the oil fill cap/dipstick to keep out debris then remove oil fill ... -
Page 19: Spray Nozzle
FPWG2700H-J-EU / FPWG3100H-J-EU 34 SPRAY NOZZLE If a pulsing sensation is felt while squeezing the trigger, the spray nozzle may be dirty or clogged and should be cleaned immediately. To clean the nozzle, shut off the engine and turn off the water. -
Page 20: Storing Pressure Washer
FPWG2700H-J-EU / FPWG3100H-J-EU 38 STORING PRESSURE WASHER If storing pressure washer for 30 days or more follow the procedures below: Add fuel stabilizer to gasoline to keep gasoline from going stale and to prevent gum deposits from forming on the carburettor. Run engine for a couple of minutes to circulate the fuel stabilizer. -
Page 21: Technical Data
FPWG2700H-J-EU / FPWG3100H-J-EU 40 TECHNICAL DATA Model FPWG2700H-J-EU FPWG3100H-J-EU Engine 180 CC OHV, 4 Stroke, Air Cooled 208CC OHV, 4 Stroke, Air Cooled Rated speed 3000 min 3000 min Engine Oil type / 10W30 – 0.6 L 10W30 – 0.6 L... -
Page 22: Service
FPWG2700H-J-EU / FPWG3100H-J-EU 43 SERVICE How to contact us: (To order parts, receive warranty assistance, or other services inquiries) Please see contact data on the back of this manual. Record the following information bellow for service or warranty assistance Date of Purchase:...