KNOW YOUR LAWN MOWER Read this manual carefully, observing the recommended safety instructions before, during and after using your lawn mower. Following these simple instructions will also maintain your lawn mower in good working order. Familiarize yourself with the controls on your mower before attempting to operate it, but above all, be sure you know how to stop your mower in an emergency.
Page 5
Do not operate on inclines greater than 15°. Mow across the face of slopes,never up and down. Electric shock hazard. Wait until all machine components have completely stopped before touching them. CE Marking The product meets demands and regulations set by the European Community. WEEE Marking CAUTION! Unusable power tools do not belong to domestic waste.
collected, recycled or disposed of in an environmentally -friendly way. Only for EC countries: Defective or dead batteries must be recycled according to the directive 2006/66/EC Noise level marking Your tool noise is not more than XXdB. SAFETY ALERT SYMBOL: Indicates caution or warning may be used in conjunction with other symbols or pictures.
Page 7
4) Keep in mind that the operator or user is responsible for accidents or hazards occurring to other people or their property. 5) While mowing, always wear substantial footwear and long trousers. Do not operate the equipment when barefoot or wearing open sandals; Avoid wearing clothing that is loose-fitting or that has hanging cords or ties. 6) Thoroughly inspect the area where the equipment is to be used and remove all objects which can be whirled up by the machine.
Page 8
- before checking, cleaning or working on the lawnmower; - after striking a foreign abject. Inspect the lawnmower for damage and make repairs before restarting and operating the lawnmower. If lawnmower starts to vibrate abnormally (check immediately): - inspect for damage; - replace or repair any damage parts;...
Page 9
another. Shorting the battery terminals together may cause burns or a fire. 39)Under abusive conditions, liquid may be ejected from the battery: -If contact accidentally occurs, flush with water. -If liquid contacts eyes additionally seek medical help. Liquid ejected from the battery may cause irritation or burns.
You should return it to a local battery collection point in accordance with battery regulations or return them to us suitably marked “used battery”. 3. GENERAL IDENTIFICATION Fig.1A EM 4662 P-Li (DYM192107) Fig.1B EM 4662 S-Li& EM 5162 S-Li (DYM192207 & DYM192607) 1. Upper handle 2.
9. Cable clamp 10. On-off button 11. Side discharge channel 12.Mulching wedge 13. Rear discharge channel 14 Self-drive control handle 4. TECHNICAL DATA Model: EM 4662 P-Li EM 4662 S-Li EM 5162 S-Li (DYM192107) (DYM192207) (DYM192607) Rated Voltage: 62V DC...
Page 12
Fig.2A Fig. 2B Fig. 2C Fig.2D Fig. 2E Fig. 2F Washer Bolt Locking knob Fig.2G Fig. 2H Fig. 2I Cable clamp Fig.2J 5.2 ADJUSTMENT FOR AN APPROPRIATE ANGLE 1. Unscrew the locking knobs which fixed the lower handle. (Fig.3A) 2. Move the lower handle up and down, adjust it to the proper height. There are 3 adjustable heights to be chosen from on this type of lawn mower;...
Page 13
Fig.3A Fig.3B 5.3 MOUNTING AND DISMOUNTING THE GRASS CATCHER Assemble the handle into the grass catcher (Fig.4A/ Fig.4B/Fig.4C) Insert one end with a projection into the grass catcher, and then fixed another end of the handle onto the grass catcher with the screw. 1.
Page 14
Fig.4G Fig.4H 5.4 ASSEMBLE THE BATTERY AND THE ISOLATOR KEY 1. Open the battery door. (Fig. 5A) 2. Insert the battery pack into battery holder. (Fig. 5B) 3. Make sure the latch on bottom of battery pack snaps in place and that battery pack is fully seated. (Fig. 5C) 4.
Fig.6D 6. ADJUSTMENT OF CUTTING HEIGHT Apply outward pressure to disengage lever from rack. Move lever forward or back to adjust height. The height (the blade to the ground) can be adjusted from 25mm (position 1) to 75mm (position 6), 6 height positions.
Page 16
WARNING: Only with a stopped motor and standstill cutter. 1. Raise the rear cover and remove the grass catcher. (Fig.8A) 2. Push the mulching wedge into the deck. Making sure it is securely in place (Fig. 8B/Fig. 8C) 3. Lower the rear cover again. (Fig.8D) Fig.
Fig. 10A Fig.10B Fig.10C Fig.10D FOUR: Mowing with the grass catcher WARNING: Only with a stopped engine and standstill cutter. For mowing with the grass catcher, remove the mulching wedge, discharge channel for side discharge and rear discharge channel and mount the grass catcher. 1.
1. Assemble the battery and the isolator key as part 5.4 described. 2. Press the On-off button. (Fig.12A/Fig.12D) 3. And meanwhile, grasp the brake control handle, and keep it in grasp, then release on-off button (Fig.12B/Fig.12C/ Fig.12E/Fig.12F). The mower will start. For EM 4662 P-Li (DYM192107) Fig. 12A Fig.12B Fig.12C...
Page 19
Fig. 12D Fig.12E Fig.12F CAUTION! The blade starts turning as soon as the motor is started. WARNING! Cutting elements continue to rotate after the motor is switch off. 9.2 stop Fully release the brake control handle, the blade will stop. 9.3 CONNECTION FOR AUTO MOVE Only for EM 4662 S-Li&...
Page 20
Please refer to the following table for the meaning of LED display. Lawn mower status Battery pack capacity Abnormal situation indicator indicator status (press status “POWER” button (1) Green light (2) Red light (3) The battery pack capacity is between Four LEDs ON 75%~100%.
When reassembling, make sure that the cutting edges face in the direction of the motor rotation. The blade screw (2) must be torque to 20N.m. WARNING: For service, replace the blade with DAYE blade: EM 4662 P-Li(DYM192107): DAYE 2105300083 EM 4662 S-Li(DYM192207): DAYE 2105300083 EM 5162 S-Li(DYM192607): DAYE 2105300084 Fig.15...
12. STORING THE MOWER The following steps should be taken in order to prepare the lawn mower for storage. 1. Remove the battery pack from the mower and store it at room temperature in a dry location. 2. Clean the mower as described earlier in the maintenance section. 3.
Directive based on its design and type, as brought into circulation by us. In case of alteration of the machine, not agreed upon by us, this declaration will lose its validity Product Cordless Lawn Mower Machine Type: EM 4662 P-Li (DYM192107) EM 4662 S-Li(DYM192207) 5162 S-Li(DYM192607) Rated voltage/power 62 V DC Measured sound power level: 93.64 dB(A)
Page 24
2006/42/EC 2000/14/EC 2011/65/EU Applicable Harmonized Standards: EN 60335-1 EN 60335-2-77 EN 62233 EN 55014-1 EN 55014-2 Authorized Signature/Date/ Place: Ningbo Daye Garden Machinery Co., Ltd. No. 58 Jinfeng Road, Yuyao, Zhejiang 315403, P. R. China 2018-01-04 Title of Signatory: General Manager Name and address of the person authorised to compile the technical file...