Table of Contents
Advertisement
Quick Links
Submersible Pump
99916061 REV 9
INSTRUCTION MANUAL
H4665A
Serial Code FTY
Read and understand all of the instructions and
safety information in this manual before operating
or servicing this tool.
Register this product at www.greenlee.com
© 2011 Greenlee Textron Inc.
Español ............... 11
Français .............. 21
Deutsch .............. 31
Italiano ................ 41
2/11
Advertisement
Table of Contents
Related Manuals for Textron Greenline H4665A
Summary of Contents for Textron Greenline H4665A
- Page 1 Italiano ....41 H4665A Submersible Pump Serial Code FTY Read and understand all of the instructions and safety information in this manual before operating or servicing this tool. Register this product at www.greenlee.com 99916061 REV 9 © 2011 Greenlee Textron Inc. 2/11...
-
Page 2: Table Of Contents
SAE Standard J1273 (Hose and Hose Assemblies): Publication 99930323 All specifications are nominal and may change as design improvements occur. Greenlee Textron Inc. shall not be liable for damages resulting from misapplication or misuse of its products. Loctite is a registered trademark of Henkel Corp. -
Page 3: Important Safety Information
Failure to observe this warning could result in severe or servicing this tool. injury or death. Failure to wear eye protection could result in serious eye injury from flying debris or hydraulic oil. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... - Page 4 • In case of accidental skin contact with hydraulic oil, wash the affected area immediately to remove the oil. Failure to observe these precautions may result in injury. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
-
Page 5: Identification
2. Hydraulic Motor 7. Housing 3. Hydraulic Tank Port “T” (return) 8. Inlet Screen 4. Hydraulic Pressure Port “P” (supply) 9. Base Plate 5. Handle Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... -
Page 6: Specifications
• Pressure relief: 138 bar (2000 psi) • Back pressure: 13.8 bar (200 psi) Failure to observe this warning could result in severe injury or death. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... -
Page 7: Hoses And Fittings
4. Disconnect the tank hose from the tool, and then from the hydraulic power source. Typical Setup 5. Install dust caps over the ports to prevent contamination. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... -
Page 8: Operation
Perform a thorough inspection of the hydraulic hoses attention immediately. and fittings as described in publication 99930323, SAE J1273 (Hose and Hose Assemblies). Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... -
Page 9: Troubleshooting
Tool operates, but discharge Inlet screen plugged with debris. Remove debris from inlet screen. is low. Discharge hose plugged. Remove and clean hose. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... -
Page 10: Service Disassembly
3. Remove two quad rings (D) and two O-rings (C, E) from seal carrier (F). 4. Remove two O-rings (A) and one O-ring (19) from retainer (B). Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... -
Page 11: Español
3. Install retainer (18) in motor body (1). Secure using six socket head cap screws (22). 4. Turn drive shaft (3). Drive shaft must turn without binding. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... - Page 12 ® nut (30). Follow the manu facturer’s instructions for curing. Secure impeller and shims to shaft with left- handed acorn nut (30) by tightening counterclockwise. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
- Page 13 H4665A Submersible Pump Illustration Serial number 97720 and after 14,43 12,13 26,27 Apply locking compound 35,36,37 to threads. SECTION A-A Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
- Page 14 F024472 Coupling, 2 M NPT ..............1 Washer, 6 mm hard ..............8 Repair Parts 41122 50411224 Packing kit (includes items marked with an asterisk) Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
- Page 15 O-ring, .500 x .687 x .094–80 ....1 41872 50418720 Ball, .156 diameter (not illustrated) ..2 Repair Kits 41122 50411224 Packing kit (includes items marked with an asterisk) Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
- Page 16 Hose assembly, heavy-duty discharge Coupling, cam lock ..............1 Clamp, hose ................4 Hose, discharge, 2" x 25'............1 Coupling, male cam lock ............1 Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
- Page 17 800-435-0786 Fax: 800-451-2632 815-397-7070 Fax: 815-397-1865 Canada 800-435-0786 Fax: 800-524-2853 International +1-815-397-7070 Fax: +1-815-397-9247 4455 Boeing Drive • Rockford, IL 61109-2988 • USA • 815-397-7070 • An ISO 9001 Company Greenlee Textron Inc. is a subsidiary of Textron Inc. www.greenlee.com...
Need help?
Do you have a question about the Greenline H4665A and is the answer not in the manual?
Questions and answers