Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Textron GREENLEE 1725
Summary of Contents for Textron GREENLEE 1725
- Page 1 INSTRUCTION MANUAL 1725 Hydraulic Foot Pump Read and understand all of the instructions and safety information in this manual before operating or servicing this tool. 999 8293.5 © 2005 Greenlee Textron Inc. IM 994 REV 10 5/05...
-
Page 2: Table Of Contents
Replacement manuals are available upon request at no charge. All specifications are nominal and may change as design improve- ments occur. Greenlee Textron Inc. shall not be liable for damages resulting from misapplication or misuse of its products. KEEP THIS MANUAL Greenlee / A Textron Company 4455 Boeing Dr. -
Page 3: Important Safety Information
Failure to observe this warning could result in severe injury or death. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... - Page 4 Any other use may result in injury or property damage. Failure to wear eye protection could result in serious eye injury from flying debris or hydraulic oil. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
-
Page 5: Preparation
3. Fill the reservoir up to 2-3/4" from the end of the reservoir. Note: Do not overfill the reservoir. Overfilling will prevent the pump from operating properly. 4. Replace the end cap. Figure 1 Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... -
Page 6: Purging Air From The System
4. Set the pump on a horizontal surface and operate the pump as usual. If the lever still feels spongy or operation is erratic, repeat steps 1–3. Figure 3–Pump Figure 4–Release Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... -
Page 7: Troubleshooting
500 psi, but should then hold. If the pressure does not hold at this point, go to the Probable Causes). Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... -
Page 8: Replacing The Valve Pin
7. Repeat steps 4–7 until the relief setting is at the correct pressure. 8. Tighten the jam nut (31). 9. Replace the end cap (35). Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... -
Page 9: Refinishing A Ball Seat
Leak Back or Pressure Drop Pressure Adj. 3/16 Ball Seat 29/64 Drill 15/64 Drill Intake Leak 3/16 Ball Seat Cone Seat Discharge Leak Built-in Relief Valve Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070... - Page 10 1725 Hydraulic Foot Pump 1725 Hydraulic Foot Pump—Exploded View Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
- Page 11 O-ring, .625 x .812 x .093 (not shown) ..........1 503 3336.4 Repair kit (includes items marked with an asterisk) **Fluorocarbon O-rings are used at the factory as a part of production process. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
- Page 12 815-397-7070 Fax: 815-397-1865 Canada 800-435-0786 Fax: 800-524-2853 International +1-815-397-7070 Fax: +1-815-397-9247 4455 Boeing Drive • Rockford, IL 61109-2988 • USA • 815-397-7070 An ISO 9001 Company Greenlee Textron Inc. is a subsidiary of Textron Inc. • www.greenlee.com Printed in USA...
Need help?
Do you have a question about the GREENLEE 1725 and is the answer not in the manual?
Questions and answers