126 Installation Of An Additional Battery - Opel Movano X62 2010 Conversion Manualline

OPEL MOVANO (X62)
126 – INSTALLATION OF AN ADDITIONAL BATTERY
A space is set aside under the right-hand cab side sill.
A special battery tray should be used according to the size of the battery. It is to be attached under the
body. It is recommended that a model be taken on the mountings of the main battery tray on the left-hand
side. The battery will therefore be fitted from underneath the body.
The side sill panel may be cut out to allow access to the positive and negative terminals. The maximum
authorized cut-out must follow the stamped part. The side sill cut-out must be sealed (water, air, noise).
The right-hand plastic side sill is not intended for this use.
LOCATION
1 2
1: Main battery access area in the left-hand cab side sill
2: Zone to be cut out for access to the additional battery terminals in the right-hand cab side sill
After cutting out the side sill, the filings or shavings must be vacuumed and a corrosion inhibitor used,
referring to the "Specific Corrosion Guidelines".
To install the additional battery and its mountings, please refer to the "Battery" sheet.
For battery coupling, please refer to the "Battery coupling" sheet.
N.B.:
The additional battery must be disconnected during installation.
Warning:
The batteries may not be directly coupled in parallel.
Note: Subject to errors and technical amendments. The electronic version of the body guidelines is the decisive source of
1
up-to-date data on body guidelines (online body guidelines). Data status June 2009