Table of Contents
Advertisement
Quick Links
INSTALLER: Leave this manual with party responsible for use and operation.
OWNER: Retain this manual for future reference.
Contact your local dealer with questions on installation, operation or service.
NOTICE: SAVE THESE INSTRUCTIONS
Model(s):
Allure50 Freestanding Pellet Stove
!
Check building codes prior to installation.
• Installation MUST comply with local, regional, state and
national codes and regulations.
• Contact local building or fire officials about restrictions
and installation inspection requirements in your area.
!
Tested and approved for wood pellet fuel only. Burning of
any other type of fuel voids your warranty.
1
Owner's Manual
Care and Operation
CAUTION
CAUTION
Harman® • Allure50 Owner's Manual_R24 • 2016 -___ • 03/21
WARNING
Please read this entire manual before
installation and use of this pellet fuel-
burning room heater.
Failure to follow these instructions could
result in property damage, bodily injury
or even death.
• Do not store or use gasoline or other flammable vapors
and liquids in the vicinity of this or any other appliance.
• Do not overfire - If any external part starts to glow, you
are overfiring. Reduce feed rate. Overfiring will void
your warranty.
• Comply with all minimum clearances to combustibles
as specified. Failure to comply may cause house fire.
WARNING
HOT SURFACES!
Glass and other surfaces are hot
during operation AND cool down.
Hot glass will cause burns.
• Do not touch glass until it is cooled
• NEVER allow children to touch glass
• Keep children away
• CAREFULLY SUPERVISE children in same room as
stove.
• Alert children and adults to hazards of high temperatures.
High temperatures may ignite clothing or other
flammable materials.
• Keep clothing, furniture, draperies and other flammable
materials away.
To obtain a French translation of this manual, please
contact your dealer or visit www.harmanstoves.com.
Pour obtenir une traduction française de ce manuel, s'il
vous plaît contacter votre revendeur ou visitez www.
harmanstoves.com.
NOTE
3-90-888000c
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Harman Allure50
Summary of Contents for Harman Allure50
- Page 1 Pour obtenir une traduction française de ce manuel, s’il Tested and approved for wood pellet fuel only. Burning of vous plaît contacter votre revendeur ou visitez www. any other type of fuel voids your warranty. harmanstoves.com. Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c...
- Page 2 (4) Slotted Hole Size = .156 x .25 (4) Corners = R.062 352 Mountain House Road Halifax, PA 17032 This unit will need the addendum label that refers to the “Wood heater needs periodic inspection” Information Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c...
-
Page 3: Table Of Contents
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury. • CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury. • NOTICE: Used to address practices not related to personal injury. Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c... -
Page 4: Product Specifications And Important Safety Information
Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Harman is a registered trademark of Hearth & Home ® Technologies. For assistance or additional information, consult a qualified installer, service agency or your dealer. Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c... -
Page 5: Appliance Safety
MINIMUM LOW BURN RATE THAT MUST NOT BE ALTERED. IT IS AGAINST FEDERAL REGULATIONS TO ALTER THIS SETTING OR OTHERWISE OPERATE THIS WOOD HEATER IN A MANNER INCONSISTENT WITH OPERATING INSTRUCTIONS IN THIS MANUAL. Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c... -
Page 6: Helpful Hints
• Damp pellet fuel could turn back into sawdust which Exhaust being drawn back inside the dwelling - Outside air does not flow properly through the feed system. connection to the appliance is necessary. Vent leakage Follow venting manufacturer’s recommendations for sealing pipe joints. CAUTION This appliance must be vented to the outside Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c... - Page 7 IN THIS HEATER. KEEP ALL SUCH LIQUIDS WELL AWAY FROM THE HEATER, WHILE IN USE. WARNING Tested and approved for use with wood pellets ONLY. Burning of any other fuel will void your warranty. Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c...
-
Page 8: Quick Start Guide
3. Adjust arrows to set room desired temperature. 4. Touch the On/Off Power Icon. Refer to Touch Manual for all other operations. Please Note: The USB port on the EASY Touch Control is not a charging port for smartphones, tablets etc. Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c... -
Page 9: Frequently Asked Questions
Missed Ignition. Ensure pellets in burnpot Ensure holes in burnpot are clear of obstructions above the igniter. See Burnpot Maintenance. Check to see if the ignitor is getting hot, if not replace ignitor. *See manual ignition instructions for emergency heating needs. Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c... -
Page 10: Cleaning Prompts, Messages And Errors
Touch Control has lost communication to the stove. Call your Harman Dealer. Exhaust Sensing Probe (ESP) as failed. Clean the ESP. If issue persists, call your Harman Dealer. Clean your stove. Call your Harman Dealer if problem persists. Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c... -
Page 11: Maintenance And Service
Not properly cleaning your appliance on a regular basis will void your warranty. Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c... -
Page 12: Quick Reference Maintenance Chart
2. Frequency of cleaning depends largely on fuel type. Lower quality pellets require most frequent cleaning. 3. Flame resistant gloves will help protect your skin from potential contact with heat or flames. 4. Yearly cleaning is also known as a Total Clean. This requires completing all the Daily, Weekly, Monthly and Yearly maintenance mentioned. This should be done before you begin burning the unit each heating season. Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c... -
Page 13: Unit Maintenance
Cleaning the Heat Exchanger- Clean the heat exchanger with scraper as shown in Figure 2.2. Brush or scrape the inside of the stove to remove fly ash. Remove the ash pan and dispose of ashes in an approved manner, according to local codes. Scrape heat exchanger Wing Thumb Screws with scraper tool. Figure 2.4 Figure 2.2 Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c... -
Page 14: Yearly Maintenance
Note: The hot lead/cold lead connection must always be pulled to the rear of the feeder body before operation. Combustion Fan Blade Exhaust Passage Figure 2.8 Clean Ash Accumulation Figure 2.6 Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c... - Page 15 Glass Gasket Replace glass only with high temperature ceramic glass. (2) Glass Clips (4) 1/4-20 X 3/8” Button Head Screw Figure 2.9 Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c...
-
Page 16: Reference Materials
Pellet Stove Ending Manufacturing Date: Active 1-90-888000-1(Black) (Beginning Manufacturing Date: Aug 2016)(Ending Manufacturing Date: Feb 2020) 1-90-888001-1(Black w/Wireless) (Beginning Manufacturing Date: Feb 2020) Part number list on following page. 03/21 Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c... - Page 17 SRV8787-008 Hopper Assembly w/Rear Covers Post HF1572862 SRV1-10-888223 Gasket, Hopper Throat 3-44-677185 Gasket 3/8 x 1/2 1-00-375501 20 Feet Wireless Room Sensor 3-20-777556 Additional service parts on following page. Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c...
- Page 18 Wingscrews 1/4-20 x 5/8 Pkg of 10 3-31-782108-10 Cleanout w/Hardware Set of 2 1-00-06623 3-20-677200 Igniter Pkg of 10 1-00-677200 Burn Pot Weldment 1-10-888194W Additional service parts on following page. Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c...
- Page 19 Ash Door, Roped 4-00-888109S Gasket, 1/2” Round Graphite 20 Feet 1-00-1086415 Latch Kit 1-00-888136 Latch Roller w/Hardware 1-00-888210 Wave Washer Pkg of 10 SRV3-31-453013 Additional service parts on following page. Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c...
- Page 20 Air Intake 1-10-06810A 10.13 Gasket, Air Intake Pkg of 6 3-44-72224-6 #23 Control Board Control Board 1-00-05372 5A Ceramic Fuse 1-00-05237 Pkg of 5 Additional service parts on following page. Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c...
- Page 21 Draft Meter Bolt & Tube 1-00-04004 Leg Leveling Kit 1 Set 1-00-12302 Return Air Sensor 3-20-08780 Gloss Black 1-00-0026 Gloss White 1-00-0028 Touch-up Paint Gloss Red 1-00-0029 Satin Black 1-00-0001 Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c...
-
Page 22: Limited Lifetime Warranty
Firebox and heat exchanger, FlexBurn® System 3 years Lifetime (engine, inner cover, access cover and fireback) None 1 Year All purchased replacement parts Page 1 of 2 4021-645L 10/20 Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c... - Page 23 EXPRESSED WARRANTY SPECIFIED ABOVE FOR THE APPLICABLE PRODUCT. Some States do not allow limitations on how long an implied warranty lasts, so the above limitation may not apply to you. Page 2 of 2 4021-645L 10/20 Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c...
-
Page 24: Loss Of Power
IMPORTANT! : UPS or Battery Backup cannot prevent smoke 5. Light firestarter with a match, and close the door, touch leakage from an improperly maintained unit. Keep the venting the On/Off icon on the home screen. Operation will begin system clean and free from obstructions and maintain all when the fire reaches the proper temperature. gaskets to keep an airtight seal. Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c... -
Page 25: Troubleshooting
• Hopper lid not closed properly. • Feed motor or combustion fan has failed. Smoke is visible coming out of vent • Air-fuel ratio is too rich. - Feed rate too high. - Draft too low caused by a gasket leak. Low heat output • Feed rate too low. • Draft too low because of gasket leak. • Poor quality or damp pellets. • Combination of 1 and 2. Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c... -
Page 26: Glass Installation And Cleaning
Figure 4. Repeat step for other side. Front side Note: Use 1/8” Allen Wrench supplied with stove. Back side Top of door Figure 2 Figure 4 Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c... - Page 27 Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c...
-
Page 28: Contact Information
Printed in U.S.A. Harman® • Allure50 Owner’s Manual_R24 • 2016 -___ • 03/21 3-90-888000c...
Need help?
Do you have a question about the Allure50 and is the answer not in the manual?
Questions and answers