5Th Paid Service Activities - Royal Enfield Classic 350 BS IV Owner's Manual

5TH PAID SERVICE ACTIVITIES

1 Water wash the motorcycle and dry it with a clean cloth
2 Batery Electrolyte
3 Battery terminals
4 Rear Drive chain free play
5 Rear brake pedal pivot
6 Rear brake cam
7 Rear wheel cush drive rubbers
8 Rear brake
9 Front brake
10 Tyres front & rear
11 Air filter element
12 Spark plugs (2 Nos.)
13 H.T. Leads
14 Carburetor
15 Fuel filter in Fuel tap
16 Fuel pipe
17 Rubber Hose-Air filter to carburetor
18 Rubber Hose- Inlet manifold
19 Rubber hose, Evaporative Emission Equipment
20 Accelerator, Carburetor/ TPS cable
21 Clutch cable/ Lever free play
22 Engine oil sump strainer, magnetic drain plug
23 Engine oil
24 Engine oil filter element
25 Hand levers & kick starter pivot
26 Front Fork
27 Swing arm spacer & pivot bush
28 Steering Ball Races & Balls system
29 Inlet / Exhaust valve seating
30 Earth wire eyelet Contact
31 Pivot-Side stand, Center stand, Pillion Foot Rest
32 Wheel rims front & rear
Check level & top-up, if necessary
Clean and apply petroleum jelly
Check, clean, lubricate & adjust
Lubricate
Cam clean, lubricate & Adjust play
Inspect & replace
Adjust play
Check & top up brake fluid level
Check wear pattern
Replace
Check, clean & adjust gap
Inspect for cracks
Clean, Inspect & tune
Clean
Inspect for crack
Check and Replace
Check and Replace
Replace
Check & Adjust play
Check & Adjust play
Clean
Replace
Replace
Lubricate
Inspect for oil leakage
Lubricate
Check, Lub.Steering races, balls & Adj. Play
Check by compression test
Inspect
Lubricate
Check spokes tightness / run out
62
CUSTOMER COPY
Job Card No:
Date :
Odo Reading :
Name of Dealer /
ASC with Code:
..........................
..........................
ASC / Dealer's
Stamp & Signature