Nilfisk-Advance SW900 User Manual
Hide thumbs
Also See for SW900:
- Service manual (137 pages) ,
- Instructions for use manual (92 pages) ,
- User manual (84 pages)
Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Nilfisk-Advance SW900
Summary of Contents for Nilfisk-Advance SW900
- Page 1 New & Reconditioned Equipment & Parts- www.southeasternequipment.net 08/2013 ENGLISH 1465366000 Model: 9084110010 SW900 USER MANUAL TRANSLATION OF ORIGINAL USER MANUAL INSTRUCTION New & Reconditioned Equipment - www.southeasternequipment.net...
- Page 2 Тип / Typ / Typ / Type / Tipo / Tüüp / Type / Tyyppi / Type / Τύπος / SW900 Típus / Tipo / Tipas / Tips / Type / Type / Tipo / Typ / Tip / Тип / Typ / Typ / Tip / Tip : Сериен...
-
Page 3: Table Of Contents
DUST FILTER CLEANING AND INTEGRITY CHECK ........................19 HOPPER POSITION MICROSWITCH OPERATION CHECK ....................... 20 FUSE CHECK/REPLACEMENT/RESET ............................20 BATTERY ELECTROLYTE LEVEL CHECK (FOR WET BATTERIES ONLY) ................20 TROUBLESHOOTING ..............................21 SCRAPPING .................................. 22 1465366000 - SW900 New & Reconditioned Equipment - www.southeasternequipment.net... -
Page 4: Introduction
Nilfisk constantly improves its products and reserves the right to make changes and improvements at its discretion without being obliged to apply such benefits to the machines that were previously sold. Any change and/or addition of accessory must be approved and performed by Nilfisk. SW900 - 1465366000 New & Reconditioned Equipment - www.southeasternequipment.net... -
Page 5: Operation Capabilities
Do not wash the machine with direct or before performing any operation on the pressurised water jets. machine. WARNING! WARNING! Do not use the machine on slopes with a Moving parts. gradient exceeding the specifications. 1465366000 - SW900 New & Reconditioned Equipment - www.southeasternequipment.net... -
Page 6: Symbols That Appear On This Manual
Service Center. – Before performing any maintenance procedure, disconnect the battery charger cable from the electrical mains to avoid any risk of fire, electric shock or injuries. SW900 - 1465366000 New & Reconditioned Equipment - www.southeasternequipment.net... - Page 7 The machine must be disposed of properly, because of the presence of toxic-harmful materials (batteries, oils, etc.), which are subject to standards that require disposal in special centres (see the Scrapping chapter). 1465366000 - SW900 New & Reconditioned Equipment - www.southeasternequipment.net...
-
Page 8: Machine Description
23. Left door opening/closing knob Drive control lever 24. Front skirt Drive system control adjuster 25. Rear skirt 10. Handlebar 26. Side skirts 11. Handlebar tilting adjusting lever 12. Right side broom lifting/lowering lever P100813 SW900 - 1465366000 New & Reconditioned Equipment - www.southeasternequipment.net... - Page 9 35. Batteries 47. Serial number plate/technical data/conformity certification 36. Battery connector 48. Vacuum fan 37. Right door 49. Driving belt 38. Battery charger cable 50. Main broom belt 51. Rear grid P100814 1465366000 - SW900 New & Reconditioned Equipment - www.southeasternequipment.net...
-
Page 10: Accessories/Options
U-turn space 1550 mm Vibration level at the operator’s arms (ISO 5349-1) (**) < 2.5 m/s With batteries and empty hopper. (**) Under normal working conditions, on a level asphalt surface. SW900 - 1465366000 New & Reconditioned Equipment - www.southeasternequipment.net... -
Page 11: Wiring Diagram
New & Reconditioned Equipment & Parts- www.southeasternequipment.net USER MANUAL ENGLISH Machine material composition and recyclability Type Recyclable SW900 B weight percentage percentage Aluminium 100 % 2.4 % Electric motors - various 29 % 11.8 % Ferrous materials 100 % 39.4 %... -
Page 12: Use
While reading this Manual, the operator must pay particular attention to the symbols shown on the plates (see the Visible Symbols On The Machine paragraph). Do not cover these plates for any reason and immediately replace them if they are damaged. SW900 - 1465366000 New & Reconditioned Equipment - www.southeasternequipment.net... -
Page 13: Battery Check/Setting On A New Machine
Place the protection cap on each terminal, then connect the battery connector (36). Close the battery and main motor hood (21) and engage the front latch (22). Charge the batteries (see the procedure in Maintenance chapter). P100816 Figure 1 1465366000 - SW900 New & Reconditioned Equipment - www.southeasternequipment.net... -
Page 14: Before Machine Start-Up
When operating on dry floors, close the “wet by-pass” port (43) to restore proper vacuuming. The hopper (14) should be emptied after each working cycle and whenever it is full. NOTE When the hopper is full, the machine cannot collect dust and debris anymore. SW900 - 1465366000 New & Reconditioned Equipment - www.southeasternequipment.net... -
Page 15: Hopper Dumping
To perform maintenance procedures, the machine must be off, the ignition key removed, and, if necessary, the batteries must be disconnected. Read carefully the instructions in the Safety chapter before performing any maintenance procedure. 1465366000 - SW900 New & Reconditioned Equipment - www.southeasternequipment.net... -
Page 16: Scheduled Maintenance Table
Connect the cable (38) of the electronic battery charger (40) to the electrical mains. WARNING! The mains voltage and frequency must match the electronic battery charger values shown on the machine serial number plate (47). SW900 - 1465366000 New & Reconditioned Equipment - www.southeasternequipment.net... -
Page 17: Main Broom Height Check And Adjustment
Pay careful attention when performing the above- mentioned checks, and always use the machine P100818 according to the indicated conditions. Figure 3 1465366000 - SW900 New & Reconditioned Equipment - www.southeasternequipment.net... -
Page 18: Main Broom Replacement
11. Install the main broom cover (C) and tighten the knobs (B). 12. Close the left door (A). 13. Adjust the main broom height as shown in the previous paragraph. P100819 Figure 4 SW900 - 1465366000 New & Reconditioned Equipment - www.southeasternequipment.net... -
Page 19: Side Broom Height Check And Adjustment
Install the new broom on the machine engaging it on the pins (C), then tighten the knob (A). Adjust the height of the new broom according to the procedure shown in the previous paragraph. P100822 Figure 7 1465366000 - SW900 New & Reconditioned Equipment - www.southeasternequipment.net... -
Page 20: Skirt Check And Adjustment
18. When the adjustment is completed, tighten the screws (L). P100825 Figure 9 19. Assemble the components in the reverse order of disassembly. NOTE The front skirt (24) on the hopper does not require to be adjusted. P100826 Figure 10 SW900 - 1465366000 New & Reconditioned Equipment - www.southeasternequipment.net... -
Page 21: Dust Filter Cleaning And Integrity Check
11. Perform steps 1 to 3. 12. Remove the pre-filter (K, Fig. 13) and clean it with compressed air at maximum 6 Bar. 13. Assemble the components in the reverse order of disassembly. P100829 Figure 13 1465366000 - SW900 New & Reconditioned Equipment - www.southeasternequipment.net... -
Page 22: Hopper Position Microswitch Operation Check
Close all the battery caps (35). Close the battery and main motor hood (21) and engage the front latch (22). If necessary, charge the batteries as shown in the relevant paragraph. SW900 - 1465366000 New & Reconditioned Equipment - www.southeasternequipment.net... -
Page 23: Troubleshooting
The machine cannot operate without the battery charger. In case of battery charger failure, contact an authorised Service Center. For further information contact a Nilfisk Service Center, where it is possible to consult the Service Manual. 1465366000 - SW900 New & Reconditioned Equipment - www.southeasternequipment.net... -
Page 24: Scrapping
Polyester dust filter – Main and side brooms – Plastic hoses and components – Electrical and electronic components (*) Refer to the nearest Nilfisk Center especially when scrapping electrical and electronic components. SW900 - 1465366000 New & Reconditioned Equipment - www.southeasternequipment.net... - Page 25 New & Reconditioned Equipment & Parts- www.southeasternequipment.net New & Reconditioned Equipment - www.southeasternequipment.net...