Maintenance; Recommended Maintenance Schedule(S); Periodic Maintenance; Check Engine Oil Level - Exmark BRS270CKC36000 Operator's Manual

Maintenance

Note: Determine the left and right sides of the
machine from the normal operating position.
WARNING
If you leave the wire on the spark plug, someone
could accidentally start the engine. Accidental
starting of the engine could seriously injure you
or other bystanders.
Disconnect the wire from the spark plug before
you do any maintenance. Set the wire aside so
that it does not accidentally contact the spark
plug.

Recommended Maintenance Schedule(s)

Maintenance Service
Interval
After the first 2 hours
After the first 5 hours
Before each use or daily
Every 50 hours
Every 100 hours
Every 160 hours
Yearly

Periodic Maintenance

Check Engine Oil Level

Service Interval: Before each use or daily
1. Stop engine and wait for all moving parts to stop.
Make sure unit is on a level surface.
2. Check with engine cold.
3. Clean area around dipstick. Remove dipstick
and wipe oil off. Reinsert the dipstick according
Maintenance Procedure
• Check the traction cable.
• Check the broom cable.
• Change the engine oil.
• Check the engine oil level.
• Check for loose hardware.
• Check fuel tank filter
• Check the broom shaft shear pin.
• Check the tire pressures.
• Check the condition of the belts.
• Change the engine oil. (May need more often under severe conditions.)
• Grease the broom angle lock pin.
• Check the spark plug.
• Check the traction cable.
• Lubricate hex shaft.
• Check the broom cable.
WARNING
The engine can become very hot. Touching a hot
engine can cause severe burns.
Allow the engine to cool completely before
service or making repairs around the engine area.
to the engine manufacturer's recommendations.
Remove the dipstick and read the oil level.
4. If the oil level is low, wipe off the area around the
oil fill cap, remove cap and fill to the "FULL"
mark on the dipstick. Exmark 4-Cycle Premium
Engine Oil is recommended; refer to the Engine
Owner's manual for an acceptable alternative. Do
Not overfill.
Important: Do Not operate the engine with the
oil level below the "LOW" (or "ADD") mark on
the dipstick, or over the "FULL" mark.
21
Maintenance