Cessna 188 Series Service Manual page 51

MODEL 188 & T188 SERIES SERVICE MANUAL
SPECIAL INSPECTION ITEMS (Continued from page 2-28)
24. Fuel quantity indicating system operational test is required every 12 months. Refer to Section 15 for
detailed accomplishment instructions.
25. At the first 100-hour inspection on new, rebuilt or overhauled engines, remove and clean the fuel injection |
nozzles. Thereafter, the fuel injection nozzles must be cleaned at 300-hour intervals or more frequently if
fuel stains are found.
2-54. COMPONENT TIME LIMITS
1. General
A. Most components listed throughout Section 2 should be inspected as detailed elsewhere in this section
and repaired, overhauled or replaced as required. Some components, however, have a time or life
limit, and must be overhauled or replaced on or before the specified time limit.
NOTE: The terms overhaul and replacement as used within this section are defined as follows:
Overhaul - Item may be overhauled as defined in FAR 43.2 or it can be replaced.
Replacement - Item must be replaced with a new item or a serviceable item that is within its service life
and time limits or has been rebuilt as defined in FAR 43.2.
B. This section provides a list of items which must be overhauled or replaced at specific time limits. Table
1 lists those items which Cessna has mandated must be overhauled or replaced at specific time limits.
Table 2 lists component time limits which have been established by a supplier to Cessna for the
supplier's product.
C. In addition to these time limits, the components listed herein are also inspected at regular time intervals
set forth in the Inspection Charts, and may require overhaul/replacement before the time limit is
reached based on service usage and inspection results.
2. Cessna-Established Replacement Time Limits
A. The following component time limits have been established by Cessna Aircraft Company.
Table 1: Cessna-Established Replacement Time Limits
COMPONENT REPLACEMENT
TIME
OVERHAUL
Restraint Assembly Pilot Seat
Trim Tab Actuator
Pitot and Static System Hoses
Engine Compartment Flexible Fluid-
Carrying Teflon Hoses (Cessna-
Installed) Except Drain Hoses
(Drain hoses are replaced
on condition)
Engine Compartment Flexible Fluid-
Carrying Rubber Hoses (Cessna-
Installed) Except Drain Hoses
(Drain hoses are replaced
on condition)
1,000 hours or 3 years,
whichever occurs first
10 years
10 years or engine overhaul,
whichever occurs first
(Note 1)
5 years or engine overhaul,
whichever occurs first
(Note 1)
D2054-1-13 Temporary Revision Number 5 - Apr 5/2004
© Cessna Aircraft Company
5 years NO
YES
NO
NO
NO
2-28A