Summary of Contents for Fisher & Paykel DCS BE1-30
Page 1
OUTDOOR GRILL BE1-30 Models USER GUIDE US CA...
Page 2
DANGER IF YOU SMELL GAS • Shut off gas to the appliance. • Extinguish any open flame. • Open lid. • If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department. WARNING •...
CONTENTS Introduction Safety and warnings Before you begin Lighting instructions Using the grill Leak testing Burner adjustment Care and cleaning Troubleshooting Warranty and service...
INTRODUCTION Giving you the searing heat and precise control of DCS appliances, the Series 9 All Grill gives you 525 square inches of flat top grilling space with up 50,000 BTU. Designed with flexibility in mind, the All Grill can be built-in to match the full suite of professional styled DCS Series 9 products, or mounted on a freestanding cart to create the complete outdoor kitchen for your backyard.
SAFETY AND WARNINGS WARNING! Electric Shock Hazard Failure to follow this advice may result in electric shock or death. • This appliance is equipped with a three-prong or four-prong grounding plug for your protection against shock hazard and should be plugged directly into a properly grounded power outlet.
Page 7
SAFETY AND WARNINGS WARNING! Hot Surface Hazard Failure to follow this advice may result in fire, burns, scalds or personal injury. • Accessible parts may become hot during use. • When in use, do not touch the burner, grate, or immediate surrounding area as these areas become extremely hot.
Page 8
SAFETY AND WARNINGS WARNING! Explosion Hazard Failure to follow this advice may result in injury or death • If you smell gas, do not use the appliance. • Do not use water on grease fires, a violent steam explosion may result. Turn all burners off, then smother fire or flame or use dry chemical or foam-type extinguisher.
Page 9
SAFETY AND WARNINGS Do not store a full LP tank in direct sunlight. After a period of storage or non-use, the appliance should be checked for gas leaks, deterioration, proper assembly, and burner obstructions before use. General Use This appliance is not intended to be installed in or on recreational vehicles, trailers or boats.
Page 10
SAFETY AND WARNINGS Gas requirements This appliance can be used with any brand of 20lb LP gas tank provided it is compatible with a proper retention device (not supplied). The LP gas cylinder must be: Designed for use with a Type 1 system only. Constructed and marked in accordance with the Specifications for LP gas Cylinders of the U.S.
BEFORE YOU BEGIN Ensure the installer has completed the final checklist in the installation guide. Read this guide, taking special note of the safety and warnings section. Remove all packaging and dispose of it responsibly. Recycle items that you can. Grill Features 1 Control dials 2 Dual-sided grates...
LIGHTING INSTRUCTIONS If you are using propane gas, a slight pop or flash may occur at the burner ports a few seconds after the burner has been turned . This is normal for propane gas. Remove the cover and any cooking utensils. Ensure the drip pan is in place.
Page 13
LIGHTING INSTRUCTIONS Manual lighting If the burner will not light after several attempts, the burner can be manually lit. If you have attempted to light the burner with the ignition, allow 5 minutes for any accumulated gas to dissipate. Remove the cover and any cooking utensils. Ensure the drip pan is in place.
USING THE GRILL Using the grill Remove the cover and any cooking utensils. Ensure the drip pan is in place. Light the grill burners following the lighting instructions and preheat. Place food on the grill and cook to the desired level. You can adjust the heat setting during cooking if needed.
Page 15
USING THE GRILL Dual-sided grates The dual-sided grate provides cooking options for food of varying textures. One side has a W-shaped surface that creates nice sear lines for steaks, chicken, chops and routes oil and grease away from food. The other side has a radius surface area providing more support for handling of delicate food items.
LEAK TESTING A complete gas tightness check must be performed at the installation site. Periodically check the whole system for leaks, or immediately if the smell of gas is present. When using a LP gas cylinder ensure it is installed in a vertical position to provide the required vapor withdrawal.
BURNER ADJUSTMENT Flame height adjustment Flames should be blue and stable with no yellow tips, excessive noise or lifting (Note: LP units may have some yellow tipping). If any of these conditions exist, check the air shutter and burner ports are clear. If cleaning these does not improve performance, the air shutter can be adjusted as per the instructions below.
Page 18
BURNER ADJUSTMENT Low flame adjustment The valves on the grill feature an adjustable low setting. Due to fluctuations in gas pressure, or heating value you may want to increase or decrease gas flow in the low position. If the gas type has been converted from natural to LP or vice-versa, the low flame setting must be reviewed and adjusted.
CARE AND CLEANING Regulator and hose replacement The pressure regulator and hose assembly supplied with the unit must be used. If replacements are needed, contact customer care at dcsappliances.com. Resetting the flow control Failure to follow the steps in the order shown may cause the Flow Limiting Device to activate resulting in extremely low gas flow and irregular operation.
Page 20
CARE AND CLEANING Removing the burners for cleaning Ensure the grill is and cool. Remove the grill grates, then lift out the radiant tray. remove screw Use a screw driver to open the bracket slot at the rear of the unit Press the bracket down while pulling the burner back and up.
Page 21
CARE AND CLEANING Burner alignment ⁄ ” REMOVE DRIP PAN TO VIEW CONNECTION Ensure the air shutters are not misaligned from their original position. Lower the rear of the burner into the cutouts on the support channel at the rear of the burner box. Ensure it is level and does not rock.
TROUBLESHOOTING If there is a problem with your grill, please check the following before contacting your local Fisher & Paykel trained and supported service technician or DCS Customer Care Centre. PROBLEM POSSIBLE CAUSES WHAT TO DO The grill won't light when There is no gas flowing to the unit.
WARRANTY AND SERVICE Before you call for service or assistance Refer to the installation instructions and your user guide and check that: Your product is correctly installed. You are familiar with its normal operation. Model number (can be found on the inside, right side panel behind the drip pan handle. Serial number (can be found on the inside, right side panel behind the drip pan handle.