Table Of Contents - Quadra-Fire CLASSIC BAY 1200 Installation Manual

CB1200 Free Standing
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Indicates practices which may cause damage to the appliance or to property.
Important Safety Information ............. 3
1
A. Appliance Certification. . . . . . . . . . . . . . . . . . . . . . . .3
B. BTU & Efficiency Specifications . . . . . . . . . . . . . . . .3
C. Glass Specifications . . . . . . . . . . . . . . . . . . . . . . . . .4
D. Electrical Rating . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
E. Mobile Home Approved . . . . . . . . . . . . . . . . . . . . . . .4
F. Non-Combustible Materials . . . . . . . . . . . . . . . . . . . .4
G. Combustible Materials . . . . . . . . . . . . . . . . . . . . . . .4
H. Sleeping Room . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
I. California - Prop65 . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Getting Started .................................... 5
2
A. Design, Installation & Location Considerations . . . . .5
B. Thermostat Wall Control Location . . . . . . . . . . . . . . .6
C. Tools And Supplies Needed . . . . . . . . . . . . . . . . . . .6
D. Inspect Appliance and Components . . . . . . . . . . . . .6
E. Install Checklist . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
Dimensions and Clearances .............. 8
3
A. Appliance Dimensions . . . . . . . . . . . . . . . . . . . . . . . .8
B. Clearances to Combustibles (UL and ULC) . . . . . .10
C. Hearth Pad Requirements (UL and ULC) . . . . . . . . 11
D. Alcove . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12
Vent Information ................................ 13
4
A. Venting Termination Minimum Requirements . . . . .13
B. Avoiding Smoke and Odors . . . . . . . . . . . . . . . . . . .14
C. Draft . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14
D. Negative Pressure. . . . . . . . . . . . . . . . . . . . . . . . . .15
E. Chimney and Exhaust Connection . . . . . . . . . . . . .15
F. Equivalent Feet of Pipe . . . . . . . . . . . . . . . . . . . . . .16
G. Pipe Selection Chart . . . . . . . . . . . . . . . . . . . . . . . .16
2

TABLE OF CONTENTS

Quadra-Fire is a registered trademark of Hearth & Home Technologies.
Safety Alert Key:
Venting Systems ............................... 17
5
A. Through The Wall . . . . . . . . . . . . . . . . . . . . . . . . . .17
B. Vertical into Existing Class A Chimney . . . . . . . . . .18
C. Through The Wall & Vertical - Exterior . . . . . . . . . .18
D. Vertical - Interior - Typical Installation . . . . . . . . . . .18
E. Masonry. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19
F. Alternate Masonry . . . . . . . . . . . . . . . . . . . . . . . . . .19
Appliance Set-Up .............................. 20
6
A. Outside Air Kit Instructions . . . . . . . . . . . . . . . . . . .20
B. Top Vent Adapter Installation . . . . . . . . . . . . . . . . . .21
C. Rear Vent & Rear Vent to Top Vent Adapter . . . . . .21
D. Thermostat Installation and Operation . . . . . . . . . .21
E. Optional Log Set Placement Instructions . . . . . . . .23
F. Installing Logo . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23
Mobile Home Installation .................. 24
7
Accessory List .................................. 25
8
A. Service & Maintenance Log . . . . . . . . . . . . . . . . . .25
B. Accessory List . . . . . . . . . . . . . . . . . . . . . . . . . . . . .26
7027-801C June 4, 2019