Operating Safety - Wallenstein GE605 Operator's Manual

2.7

OPERATING SAFETY

1. Please remember it is important that you read
and heed the safety signs on the Backhoe.
Clean or replace all safety signs if they cannot
be clearly read and understood. They are there
for your safety, as well as the safety of others.
The safe use of this machine is strictly up to
you, the operator.
2. All things with moving parts are potentially
hazardous. There is no substitute for a cautious,
safe-minded operator who recognizes potential
hazards and follows reasonable safety practices.
The manufacturer has designed this Backhoe to
be used with all its safety equipment properly
attached, to minimize the chance of accidents.
Study this manual to make sure you have all
safety equipment attached.
3. If a safety shield or guard is removed for any
reason, it must be replaced before the machine
is again operated.
4. Attach the tractor side plate to reinforce the
frame if required. Do not overload the tractor
frame.
5. Ensure subframe is firmly attached and all
hardware is torqued to specifications to prevent
backhoe from moving when digging.
6. Have an underground utility locating/marking
service survey the area before digging.
Underground Utility Hazard!
Contacting underground utilities
can cause electrocution. Have
an underground utility locating/
marking service survey the area
before digging.
7. Keep boom and bucket away from overhead
and underground power lines and utilities.
Electrocution can occur without direct contact
with an overhead power line.
8. Remove all sticks, stones, roots, wires or debris
from working area before starting.
9. Never operate controls from the ground.
Operate only from the operator's seat to prevent
unexpected boom movement that can lead to
crushing between frame members.
10. Do not dig under machine or stabilizers. A cave-in
could result and the machine could fall into the
excavation.
11. Do not exceed machine lift capacity. Overloading
can cause structural damage and lead to unsafe
12
WARNING!
operating conditions.
12. Position Backhoe so that loads extend directly
behind machine when lifting or placing heavy
objects.
13. When digging or lifting, Be aware of overhead
obstructions such as:
• Power lines
• Telephone lines
• Tree branches
• Roof overhang
• Washlines, ropes or cables.
14. Do not allow riders on this machine at any time.
There is no safe place for any riders.
15. Never carry, lift or move people on boom or
bucket.
16. Always use two people to handle heavy, unwieldy
components or accessories during assembly,
installation, removal or moving.
17. Never place any part of your body where it would
be in danger if movement should occur during
assembly, installation, operation, maintaining,
repairing, removal or moving.
18. Do not walk or work under a raised machine or
attachment unless it is securely blocked or held in
position. Do not depend on the tractor hydraulic
system to hold the machine or attachment in
place.
19. Never use alcoholic beverages or drugs which
can hinder alertness or coordination while
operating this equipment. Consult your doctor
about operating this machine while taking
prescription medications.
20. Before you operate the machine, check over
all hydraulic lines, hoses, connections and
components. Replace any worn or damaged
parts immediately. Tighten all leaking fittings.
21. Keep hands, feet, hair, jewellery, and clothing
away from all moving and/or rotating parts.
22. Review safety and operating instructions
annually.
23. A front is loader is required to counter-balance
backhoe and provide stability. Unbalanced
machines can tip during operation.
24. Carefully lower stabilizers and front bucket
to the ground to stabilize the machine before
starting to dig.
25. For maximum stability the tractor wheels must
be resting on the ground during operation, using
the backhoe with wheels raised up could result in
serious injury or death and may cause damage
to the machine.