Element4 Club 240H F Installation, Operation And Owner's Manual

Direct vent gas fireplaces

Advertisement

Quick Links

HOT GLASS WILL
CAUSE BURNS.
DO NOT TOUCH GLASS
UNTIL COOLED.
NEVER ALLOW CHILDREN
TO TOUCH GLASS.
A barrier designed to reduce the risk of burns from the hot viewing glass is provided with this appliance and shall be installed
for the protection of children and other at-risk individuals.
Une barrière conçu pour réduire le risque de brûlure par le verre de visualisation chaude est fournie avec cet appareil et doit
être installé pour la protection des enfants et autres personnes à risque.
WARNING:
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly could
result in serious injury, death, or property damage.
- Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
- WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not
use any phone in your building.
• Leave the building immediately.
• Immediately call your gas supplier from a
neighbor's phone. Follow the gas supplier's
instructions.
• If you cannot reach your gas supplier, call
the fire department.
- Installation and service must be performed
by a qualified installer, service agency or the
gas supplier.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
Element4 Gas Fireplaces Rev #01272020
Installation, Operation and Owner's Manual
Club 240H F
Club 240H C
Club 240H T
Club 240H R
Direct Vent Gas Fireplaces
AVERTISSEMENT:
INCENDIE OU D'EXPLOSION
Le non-respect des avertissements de sécurité à la
lettre pourrait entraîner de graves blessures , la mort
ou des dommages matériels.
- Ne pas entreposer ni utilizer d'essence ni d'autres vapeurs
ou liquides inflammables dans le voisinage de cet appareil
ou de tout autre appareil.
- QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ
• Ne pas tenter d'allumer d'appareil.
• Ne touchez á aucan interrupteur. Ne pas vous servir des
téléphones se trouvant dans le bátiment ou vous trouvez.
• Quitter immédiatement le bâtiment.
• Appelez immédiatment votre fournisseur de gaz depuis
un voisin. Suivez les instructions du fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz
appelez le service des incindies.
- Installation et l'entretien doivent être effectués par un
installateur qualifié, une agence de service ou le fournisseur
de gaz.
INSTALLATEUR: Laissez cette notice avec l'appareil.
CONSOMMATEUR: Conservez cette notice pour
consultation ultérieure.
1
4006611
Une surface vitrée chaude
peut causer des brûlures.
Laisser refroidir la surface
vitrée avant d'y toucher.
Ne permettez jamais á un enfant
de toucher la surface vitrée.
www.EuropeanHome.com
January 2020

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Club 240H F and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Element4 Club 240H F

  • Page 1 INSTALLER: Leave this manual with the appliance. INSTALLATEUR: Laissez cette notice avec l’appareil. CONSUMER: Retain this manual for future reference. CONSOMMATEUR: Conservez cette notice pour consultation ultérieure. January 2020 Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com 4006611...
  • Page 3: Table Of Contents

    TABLE OF CONTENTS Important Safety Information ..................... 4 Key Installation Points ......................7 Planning Your Gas Fireplace....................8 User Information ........................10 Specifications and Dimensions..................11 Clearances ..........................18 Locating the Fireplace Placing the Fireplace Clearances to Combustibles Clearances to Non-Combustibles Mantel Clearances Convection Clearances Gas and Electric ........................22...
  • Page 4: Important Safety Information

    Do not place furniture or other objects within 36” of the fireplace glass. SAVE THESE INSTRUCTIONS Make yourself fully aware of all the following instructions and the many features of the Element4 direct vent gas fireplace appliance. INSTALLER: Leave this manual with the appliance.
  • Page 5 : Glass Handling jurisdiction for gas product installations to determine their specific requirements for high altitude installations. The glass must only be removed by a qualified person. Gloves should be worn when removing the glass. Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 6 1/16” when converted. If greater accuracy is DO NOT USE abrasive cleaners on the panels. DO NOT required, use the metric dimensions. ATTEMPT to clean the glass panels when they are hot. Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 7: Key Installation Points

    Gas pressures MUST be read with a manometer and confirmed with what is required in the installation manual. FINISHING 1/8” gap between the flange and the enclosing wallboard MUST be maintained to prevent cracking from heat expansion and contraction. Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 8: Planning Your Gas Fireplace

    PLANNING YOUR GAS FIREPLACE Before You Begin Since the Element4 fireplaces are vented gas appliances they must be installed by a qualified installer. • Your sales representative can help you choose the appropriate professional. Overall Design • One of the many features of the Element4 fireplace is its use of convective air flow.
  • Page 9 If the venting falls outside of the vent graphs, a power vent is available. • The next question to ask is, “Can I get my gas pipe to the fireplace?” The Element4 fireplaces burn either Important Points natural gas (NG) or propane gas (LP.) Your sales representative will ask you for your requirement at the •...
  • Page 10: User Information

    WARMTH AND BEAUTY - HOW IT WORKS The Element4 fireplaces are direct vent fireplaces and, as such, the intake and exhaust are both handled through the vent pipe. The fireplace also provides convection air to your room. The illustration shows one of the unique features of the Element4 fireplaces - its use of warm, convection air flow.
  • Page 11: Specifications And Dimensions

    A sample listing label image is shown Output Cord Length 6 Feet above. A metal listing label is attached Agency Approvals UL, CSA to every Element4 fireplace and contains Figure 4 important certification information. The listing label must not be removed from 24V POWER SUPPLY SPECIFICATIONS...
  • Page 12 This information is for reference only. Please consult the Installation Manual for all details prior to making any design decisions. Conversions from millimeters are rounded to the nearest fraction. A DWG file is available at www.europeanhome.com CLUB 240H F www.EuropeanHome.com (Vent can be ordered on either side) Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 13 Millimeters 1013 E4-23 CLUB 240H RC (Club 240 LC is a mirror image) Figure 9 (Vent is opposit side of side glass) A downloadable DWG file is available at www.europeanhome.com for dimensions not shown. Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 14 This information is for reference only. Please consult the Installation Manual for all details prior to making any design decisions. Conversions from millimeters are rounded to the nearest fraction. A DWG file is available at www.europeanhome.com Figure 10 www.EuropeanHome.com CLUB 240H R Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 15 Pounds Kilograms APPV'D Millimeters 1013 E4-23 MATERIAL: DWG NO. SEE BOM WEIGHT: 157587.41 SCALE:1:50 SHEET 1 OF 1 Figure 11 CLUB 240H T A downloadable DWG file is available at www.europeanhome.com for dimensions not shown. Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 16 SPECIFICATIONS and DIMENSIONS PARTS OF THE FIREPLACE The various parts of the Club 240 RD fireplace are shown below. These parts are typical of any Element4 Club 240 fireplace. 14 14 Figure 12 Table of Fireplace Parts Outer Frame Face - surrounds the glass panels and limits the non-combustible wall board...
  • Page 17 Vent Collar - accepts the 5” x 8” venting adapter (included) Relief Door - part of the safety system. Do NOT block the operation. Pilot Assembly Upright Trim - quantity varies by model Figure 15 Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 18: Clearances

    YOUR RESPONSIBILITY TO ENSURE THE SAFETY OF THESE CRITICAL COMPONENTS THROUGHOUT THE INSTALLATION CRITICAL COMPONENTS THROUGHOUT THE INSTALLATION PROCESS. REMOVE AND DISPOSE OF ALL WRAPS AND TIES. PROCESS. REMOVE AND DISPOSE OF ALL WRAPS AND TIES. Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 19: Clearances To Combustibles

    We recommend that the fireplace be set into its final location before building the enclosure. Please refer to the “Reduced Clearance to Existing Combustible Wall” section for use of combustibles inside of the above clearances. Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 20: Mantel Clearances

    (TYPICAL) Mantel Depth NON COMBUSTIBLE 12”/300 mm MATERIAL CONSTRUCTION BEAMS NON- COMBUSTIBLE (TYPICAL) DETAIL C ETAIL C 1”/25 mm ALE 1 : 10 TOP OF FIREPLACE OPENING Figure 19 Figure 20 GLASS CONVECTION GAP Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 21: Convection Clearances

    Figure 21 Air Outlet Area by Model Minimum Distances Room ceiling to 72” Square Square Model Inches Centimeters appliance bottom 1830 Room ceiling to top of 1” Convection Air Outlet Figure 23 Figure 22 Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 22: Gas And Electric

    The installer must provide an approved 120V AC receptacle to be placed within the three foot cord limit of the 24V power supply. Electrical work must be performed by a qualified, licensed electrician. WARNING All wiring shall be in compliance with all local, city, and state codes. Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 23: Venting

    Pro-Form (BDM - Bernard Dalsin Manufacturing) Direct-Temp (Selkirk Corporation) AmeriVent Direct Vent (Hart & Cooley Inc.) Ventis Direct Vent (Olympia Chimney Supply, Inc.) Figure 25 Please visit www.europeanhome.com/technical-support/ for the power venting installation manuals Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 24 Calculate the Total Vertical Section by adding up all vertical (upward) sections in your vent design. CALCULATING THE TOTAL HORIZONTAL SECTION (THS) Calculate the Total Horizontal Section by adding up all horizontal sections in your vent design. Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 25 Loosen the screws on either side and slide the restrictor as desired. Do not modify the restrictor(s). Please use the graph above to determine if you will need to use a restrictor. Loosen these two Phillips head screws to slide the restrictor on/off. Figure 30 Figure 31 Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 26: Venting Charts

    0 - 1'7" 1'8" (0.5 m) 3'4" (1 m) 5' (1.5 m) 6'7" (2 m) 8'3" (2.5 m) . (meters) configuration NOT allowed configuration allowed, no restrictor required configuration allowed, 50 mm restrictor required configuration NOT allowed Figure 34 Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 27: Venting Clearances

    VENTING CLEARANCES HORIZONTAL VENT TERMINATION CLEARANCES AND REQUIREMENTS Figure 35 Figure 36 Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 28 National Fuel Gas Code (ANSI Z223.1 in the USA) or the current standard of CAN/CSA-B149.1 in Canada. Figure 37 Figure 38: Termination Heights A second termination may be no closer than 12”/305 Figure 39: Multiple Termination Clearance Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 29: Enclosing The Fireplace

    Figure 40: * The listed brand names are trademarks of their respective companies. Skamol Americas, Inc. Promat Inc. James Hardie Building Products (844) 475-2665 (865) 681-0155 (888) 542-7343 E-mail: skamotec225@skamol.com E-mail: sales@promat.us www.jameshardie.com www.skamotec225.com www.promat.us/en Fireplace Trim Figure 42 Minimum Wall Thickness = 1/2”/12 Figure 41 Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 30 ENCLOSING the FIREPLACE BUILDING THE ENCLOSURE/FRAMING A safe installation of your Element4 fireplace requires that three things be clearly understood. 1. Most important, these fireplaces are NOT zero-clearance fireplaces. Unlike zero-clearance fireplaces, there is not an outer metal box around the Element4 fireplaces which increases the framing dimensions.
  • Page 31 Gap MUST BE Gap MUST BE MAINTAINED MAINTAINED 1” (25) 1” (25) Minimum Air Gap MUST BE MAINTAINED Minimum Air Gap MUST BE MAINTAINED Figure 43 OMBUstiBle HielD inisHeD HielD inisHeD OMBUstiBle Figure 45 Figure 46 Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 32: Rough Opening Dimensions

    When enclosing the Club 240H F fireplace there is a minimum clear area which must be maintained. Nothing except the Club 240H F may be within this area. When enclosed, the Club 240H F is centered between the left and right enclosing walls. This minimum area MUST BE DEFINED BY NON-COMBUSTIBLE MATERIAL.
  • Page 33 Your installation will use more than this minimum cabinet space in order to accommodate controls, venting, air openings, etc. We recommend that the fireplace be set into its final location before building the enclosure. Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 34 Your installation will use more than this minimum cabinet space in order to accommodate controls, venting, air openings, etc. We recommend that the fireplace be set into its final location before building the enclosure. Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 35 Your installation will use more than this minimum cabinet space in order to accommodate controls, venting, air openings, etc. We recommend that the fireplace be set into its final location before building the enclosure. Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 36: Convection Air Opening

    ENCLOSING the FIREPLACE Figure 51: Figure 52: Club 240H F with Air Club 240H F with Air Outlets in Wall Outlet in Reveal Figure 53: Figure 54: Club 240H C with Club 240H C with Air Outlets in Wall Air Outlet in Reveal...
  • Page 37 Figure 56 Use the adjustable feet to ensure that the fireplace is level prior to enclosing it. Do NOT lift the fireplace by the face frame but by the bottom of the cabinet. Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 38: Cold Climate Installation

    The drawing is not to scale. * Controls will not reach to this edge of the fireplace 40” N/A* 1016 All controls are located on the vent side of the fireplace. Figure 58 50” 43” Diameter 1092 Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 39 Once the system stays lit for at least one full minute, turn the fireplace off, fix the glass panels in place and operate the fireplace for at least 45 minutes to ensure the system works properly when heated. Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 40: Installing The Fire Media

    B shows the pilot ssembly. C shows the 2 thermocouple. Pilot Assembly Pilot Assembly Thermocouple Thermocouple Figure 62 To see how to arrange media in an Element4 fireplace please visit the link below. WWW.EUROPEANHOME.COM/RESOURCES/VIDEOS/ Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 41: Screen Installation

    Place the two Lower Tabs on the trim, with the short side against the glass, about 2-3” from each corner of the glass. Place a magnet on the front of each tab. Figure 71 Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 42 Figure 74 The small end screen will only have one metal tab placed at the top center (where applicable). Figure 75 Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 43: Operating The Fireplace

    OPERATING the FIREPLACE OVERVIEW The Club 140 Series fireplaces may be controlled with one of two devices; the included remote control or the Element4 ProContol app on your iOS/Android mobile device. The ProControl app is required for control of both the fireplace flames and the LED lights and is available at either the Apple App Store or Google Play.
  • Page 44 OPERATING the FIREPLACE OPERATING the FIREPLACE Multi-Burner Status Figure 78 Figure 80 Figure 79 Figure 81 Element4 Gas Fireplaces EuropeanHome.com Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 45 OPERATING the FIREPLACE Figure 82 Figure 83 Figure 84 Figure 85 Figure 86 NOTE: There is a 2 min delay before the next ignition is possible. Figure 88 Figure 87 Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com Element4 Gas Fireplaces EuropeanHome.com...
  • Page 46 OPERATING the FIREPLACE OPERATING the FIREPLACE Figure 89 Figure 90 Figure 92 Figure 91 Figure 93 Figure 94 Figure 95 Figure 97 Figure 96 Element4 Gas Fireplaces Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com EuropeanHome.com...
  • Page 47 OPERATING the FIREPLACE OPERATING the FIREPLACE Figure 98 Figure 99 Figure 100 Element4 Gas Fireplaces Rev #01272020 Element4 Gas Fireplaces www.EuropeanHome.com EuropeanHome.com...
  • Page 48 ProControl APP The Element4 ProControl app has a user friendly, interactive layout and may be used with up to eight Element4 fireplaces in one location. The number of users is unlimited so every family member can make use of it after easily making a personal account.
  • Page 49 The upper right button is used to turn on the color carousel. In this mode the colors are looped and will gradually change. Glowing Ember: Red / Yellow / Orange LEDs Manual : Your color choice. Party: Popping different colors to beats. Zen: Calm sequence of colors. Romantic: Red and Pink colors. Twinkle: Shimmery colors. Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 50 OPERATING the FIREPLACE Figure 101 Figure 102 Figure 103 Figure 104 Figure 105 Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 51: Glass

    Since it is a metal fireplace, the heat-up and cool-down cycles may produce some noises caused by the expansion and contraction of these metals. The premium materials and build quality of your fireplace will keep these sounds to a minimum. Figure 106 To see an Element4 fireplace starting and running normally please visit the link below. WWW.EUROPEANHOME.COM/RESOURCES/VIDEOS/ Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 52: Maintenance

    Remove all of the retaining bolts and clamps holding in the first piece of glass. To see how to remove the glass from an Element4 fireplace please visit the link below. WWW.EUROPEANHOME.COM/TECHNICAL/HOW-TO-VIDEOS/ Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 53 While ensuring that the glass panels are tight and square to each another, tighten the retaining bolt(s) on each clamp NO MORE THAN 1/2 TURN past finger tight. PROPERLY PLACE, CLAMP AND SEAL THE GLASS PANELS BEFORE LIGHTING THE FIRE! Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 54: Burner

    The pilot has two distinct flames, one engulfing the thermocouple on its left, the other reaching across to the burner. The area around the pilot should be inspected for cleanliness. Lint or foreign material must be removed with a brush or vacuum. Figure 111 Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 55: Thermocouple

    MAINTENANCE THERMOCOUPLE MAINTENANCE The Element4 fireplaces have two thermocouples; one next to the pilot and one opposite the pilot side of the burner. The completeness and operation of both must be checked. A qualified installer must confirm that both thermocouples are in place and not damaged.
  • Page 56: Replacement Parts

    DescRiptiOn QUAntitY pARt nUMBeR glass e4-glAss-240H ROnt Safety Screen e4-ss-9421-stD All Tabs with Magnets (Kit) e4-sA-ss-HWK-5/15 Lower and Side Trim Repl-e4-cp-tRiM-MOD-240H Foot with Nut Repl-e4-cp-Ft Hearth Panel Repl-e4-cp-HeARtH-240H-clUB Hearth Panel Screws Repl-34-cp-Hps-01 Figure 114 Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 57 Front Glass e4-glAss-240H Side Glass e4-glAss-s-240H Safety Screen e4-ss-BiD2005-H All Tabs with Magnets (Kit) e4-sA-ss-HWK-5/15 - 3/9 Lower and Side Trim Repl-e4-cp-tRiM-BiD-240H Foot with Nut Repl-e4-cp-Ft Hearth Panel Repl-e4-cp-HeARtH-240H-clUB Hearth Panel Screws Repl-34-cp-Hps-01 Figure 116 Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 58 DescRiptiOn QUAntitY pARt nUMBeR glass e4-glAss-240H Safety Screen e4-ss-9421-stD All Tabs with Magnets (Kit) e4-sA-ss-HWK-5/24 Lower and Side Trim Repl-e4-cp-tRiM-ten-240H Foot with Nut Repl-e4-cp-Ft Hearth Panel Repl-e4-cp-HeARtH-240H-clUB Hearth Panel Screws Repl-34-cp-Hps-01 Figure 118 Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 59 QUAntitY pARt nUMBeR glass e4-glAss-240H Safety Screen e4-ss-lUc4005-H All Tabs with Magnets (Kit) e4-sA-ss-HWK-5/15 - 3/9 Lower and Side Trim Repl-e4-cp-tRiM-ten-240H Foot with Nut Repl-e4-cp-Ft Hearth Panel Repl-e4-cp-HeARtH-240H-clUB Hearth Panel Screws Repl-34-cp-Hps-01 Figure 120 Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 60 MAINTENANCE REPLACEMENT PARTS Figure 121 Item Description Quantity Part Number Required Pilot Assembly REPL-E4-GS-PABT-01 Ignitor Rod REPL-E4-GS-TIBT-01 1st Thermocouple REPL-E4-GS-1T-01 2nd Thermocouple REPL-E4-GS-2TC-02 Figure 122 Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 61 After 1/2020 Ribbon Burner Poilot Assembly E4PGS-PABT-01 Second Thermocouple E4-GS-2TC-01 6 Volt Adaptor AC Adaptor-03 Wifi-Box E4-GS-Con-Wifi-02 24 Volt Adaptor Adaptor-24V Repl-E4-GS-RC-10B Befor 1/2020 10 Button Remote Repl-E4-GS-RC-10B-02 After 1/2020 Figure 125 Figure 124 Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 62: Warranty

    Club 240H F Club 240H C Club 240H R Club 240H T (check one) Purchased From Date of Purchase Installed By Date of Installation Fireplace Serial Number Fuel Type Total Venting Horizontal Total Venting Vertical Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 63: Massachusetts Certification

    Gas Fitters has issued approval number G1-0515-495 for this appliance. The following must be observed when installing the Element4 fireplaces within the Commonwealth of Massachusetts: (a) For all side wall horizontally vented gas fueled equipment installed in every dwelling, building or structure used in whole...
  • Page 64 Confirm proper connection/operation of latching sound. SW-cable the SW-cable. disconnected. Motor not operating Replace gas valve. properly. Micro switch not Replace gas valve. operating properly. (continued) Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com I:\DEPARTMENTS\Technical Support\Troubleshooting\Guides\20181205_Troubleshooting Flow Chart_E4_8btn Edition.indd...
  • Page 65 Short between interrupter block and TC- Check connection to interrupter block. cable. Sparking stops after pilot is lit. Electronic measuring amplifier defective. Replace the receiver. (continued) Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 66 Manual knob is in the “MAN” position. positive latch is required. Main burner is lit. Confirm correct gas pressure. Increase pilot Pilot flame is too low. flame if necessary. (continued) Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com I:\DEPARTMENTS\Technical Support\Troubleshooting\Guides\20181205_Troubleshooting Flow Chart_E4_8btn Edition.indd...
  • Page 67 Quality 1.5V AA alkaline recommended. Magnet unit drops Ensure magnet unit is operating while motor turns. Test the receiver output to the magnet unit. normally. Receiver makes 3 beeps. (continued) I:\DEPARTMENTS\Technical Support\Troubleshooting\Guides\20181205_Troubleshooting Flow Chart_E4_8btn Edition.indd Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 68 Check venting for complete integrity. Reduce the primary air opening until flames have blue Too much primary air. base and yellow upper two-thirds. Flames are stable but too small and blue. NORMAL OPERATION Element4 Gas Fireplaces Rev #01272020 I:\DEPARTMENTS\Technical Support\Troubleshooting\Guides\20181205_Troubleshooting Flow Chart_E4_8btn Edition.indd www.EuropeanHome.com...
  • Page 69 DESCRIPTION PART NUMBER NUMBER Maxitrol Esave Remote Control E4-GS-RC-10B B6R-HATV4BW 10 Button Remote supports Wi-Fi 10 Button Remote Maxitrol Receiver 918 mHz Receiver E4-GS-CM-Wifi-03 B6R-RAPT2 supports Wi-Fi Gas Valve Repl-E4-GS-GV-01 GV60M1-C5B1KL-0003 Maxitrol Gas Valve Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 70 APPENDIX TWO ProControl Error Codes Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 71 APPENDIX TWO ProControl Error Codes (con’t.) Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 72 Frequent ON and OFF cycles will limit life expectancy of the valve and will increase battery consumption. The fireplace should be powered by the AC adapter for improved reliability and customer satisfaction. Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 73 Step 3. Using the provided suction cups, carefully put the top end of the glass into the top channel first. Push up until the bottom end of the glass clears the bottom channel. Lower the glass into the bottom channel. Figure 130 Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 74 No communication between receiver and Wi-Fi Contact service No control possible by the electronics module Contact service No temperature display in the App • No hand transmitter connected “N.a. ” in the App • Batteries hand transmitter empty Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 75 2x 1.5 V AAA 4 sec. No reaction from the fireplace No or bad connection between the receiver and Interrupted responses hand transmitter No electronic control No voltage on the receiver Low communication range, AC adapter Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 76 Try to keep jammers as far away as possible devices can not connect via the 5GHz band, the ProControl from the router. Neighboring wireless networks also play a module is not suitable for 5GHz band. role in the Wi-Fi area. Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 77 NOTES Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 78 OMBUstiBle Alls Venting FiRe MeDiA HARts nstAlling tHe tOnes FiRst FiRe 51 leARAnces OnFigURing ORizOntAl eRMinAtiOns estRictOR eRticAl eRMinAtiOns nstAlling tHe RessURes WARRentY 62 listing lABel 11 MAintenAnce URneR lAss ilOt HeRMOcOUples MAntels 20 Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...
  • Page 80 Imported and distributed in North America by: EUROPEAN HOME a division of Europa Ja, Inc. 30 Log Bridge Road Building 300 - Suite 303 Middleton, MA 01949 www.europeanhome.com IGE4-23RB-180130 Element4 Gas Fireplaces Rev #01272020 www.EuropeanHome.com...

This manual is also suitable for:

Club 240h cClub 240h tClub 240h r

Table of Contents