Bakers Pride GG Series Installation And Operating Instructions Manual

Advertisement

Quick Links

INSTALLATION AND OPERATING INSTRUCTIONS
Gas Char Broilers
INTENDED FOR OTHER THAN HOUSEHOLD USE
RETAIN THIS MANUAL FOR FUTURE REFERENCE
Do not store or use gasoline or other flammable vapors
or liquids in the vicinity of this or any other appliance.
Improper installation, adjustment, alteration, service or Maintenance can cause property
damage, injury or death. Read the Installation, Operating and Maintenance Instructions
thoroughly before installing or servicing this equipment.
This equipment has been engineered to provide you with year round dependable service
when used according to the instructions in this manual and standard commercial kitchen
practices.
Instructions must be posted in a prominent location. All safety precautions must be
taken in the event the user smells gas. Safety information can be obtained from your
local gas supplier.
R
(914) 576-0200 Phone
(914) 576-0605 Fax
All manuals and user guides at all-guides.com
SGBR and GG
Model:
FOR YOUR SAFETY
WARNING
CERTIFIED
BAKERS PRIDE OVEN CO., INC
30 Pine Street
New Rochelle, NY 10801
R
(800) 431-2745 US & Canada
www.bakerspride.com WebAddress
®
P/N U4010A
5/97

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the GG Series and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Bakers Pride GG Series

  • Page 1 Safety information can be obtained from your local gas supplier. ® CERTIFIED P/N U4010A 5/97 BAKERS PRIDE OVEN CO., INC 30 Pine Street New Rochelle, NY 10801 (914) 576-0200 Phone (800) 431-2745 US & Canada (914) 576-0605 Fax...
  • Page 2 All manuals and user guides at all-guides.com TABLE OF CONTENTS 1. INSTALLATION INSTRUCTIONS SECTION PAGE " 2. OPERATING INSTRUCTIONS...
  • Page 3: Installation Instructions

    All manuals and user guides at all-guides.com 1. INSTALLATION INSTRUCTIONS 1. INSTALLATION: USA, In Canada, 2. ACCEPTABLE CLEARANCES: MINIMUM CLEARANCE FROM NON-COMBUSTIBLE"CONSTRUCTION: 3. GAS CONNECTION:...
  • Page 4 All manuals and user guides at all-guides.com For units using Propane Gas, supply lines with less than 1/2D (12.7 mm) inside diameter should not be used, even for a small unit. NOTE: Be sure plug is installed in the connection not being used. Be sure to cap whichever side is not connected.
  • Page 5: Assembly Procedures

    All manuals and user guides at all-guides.com NOTE: 5. ASSEMBLY PROCEDURES: a. Bottom Grates: b. Glo-Stones: c. Top Grates: d. Griddle Plates...
  • Page 6: Lighting Procedure

    All manuals and user guides at all-guides.com 6. LIGHTING PROCEDURE: a. GG Series If any burner fails to light, turn the burner valves to "OFF", wait five minutes and repeat the above procedure. CAUTION: THE PILOT BURNERS WILL STAY LIT UNTIL THE MAIN GAS SUPPLY TO THE UNIT IS TURNED "OFF".
  • Page 7: Additional Installation Requirements

    All manuals and user guides at all-guides.com NOTE: CAUTION: 7. ADDITIONAL INSTALLATION REQUIREMENTS: 8. INSTALLATION WITH CASTERS:...
  • Page 8: Maintenance

    All manuals and user guides at all-guides.com II. OPERATING INSTRUCTIONS 1. LIGHTING PROCEDURE: 2. BROILING PROCEDURE: BROILER TOP GRATES MUST BE HOT ENOUGH TO MAKE BLACK CHAR-MARKS WHEN STARTING TO BROIL. 3. MAINTENANCE: (a) SERVICE:...
  • Page 9 All manuals and user guides at all-guides.com (b) CARE AND CLEANING OF TOP GRATES: Under no circumstances should the grates be placed in a dishwasher. Soap, water, or any detergent should never be used on the cast iron grates. NOTE: The following procedures should only be done when the unit is cold. “DO NOT” attempt steps c, d, or e when the unit is hot.
  • Page 10 VALVE HANDLE BURNER VALVE BURNER EXTENSION (STRAIGHT) AIR MIXER PILOT FLAME ADJUSTING SCREW MANIFOLD ORIFICE BURNER VALVE MANIFOLD VALVE EXTENSION (CURVED) FIG. 3 GG SERIES FIG. 4 GG SERIES - TYP. SIDE VIEW PILOT BURNER BURNER ORIFICE VALVE HANDLE MANIFOLD VALVE...
  • Page 11 All manuals and user guides at all-guides.com FIG. 5 GG SERIES FIG. 6 SGBR SERIES...
  • Page 12: Bakers Pride Limited Warranty

    BAKERS PRIDE Factory Authorized Service Center. This Warranty is in lieu of all other warranties, expressed or implied, and all other obligations or liabilities on the manufacturers part. BAKERS PRIDE shall in no event be liable for any special, indirect or consequential damages, or in any event for damages in excess of the purchase price of the unit. The repair or replacement of proven defective parts shall constitute a fulfillment of all obligations under the terms of this warranty.

Table of Contents