Related Manuals for Bakers Pride DANTE CH Series
Summary of Contents for Bakers Pride DANTE CH Series
- Page 1 OPERATION MANUAL DANTE SERIES GAS CHARBROILERS SERIES: CH B U I LT B Y C R A F T S M E N . T E S T E D B Y T I M E ®...
- Page 2 CH CHARBROILER OPERATION MANUAL CHARBROILER OPERATION MANUAL Models: WARNING Dante CH All gas operated Bakers Pride charbroilers are ® Improper installation, adjustment, intended for use with the type of gas specified on the alteration, service or maintenance can rating plate and for installation will be in accordance cause property damage, injury or death.
-
Page 3: Table Of Contents
CH CHARBROILER OPERATION MANUAL TABLE OF CONTENTS GENERAL DESCRIPTION OPERATIONAL GUIDELINES FOR CHARBROILER NATURAL SMOKE ESSENCE INSTALLATION HELPFUL HINTS CLEARANCES MAINTENANCE GAS CONNECTION SERVICE BURNERS CARE AND CLEANING OF TOP GRATES RADIANTS GREASE COLLECTION TOP GRATES CLEANING TOOLS LIGHTING AVERAGE PRODUCTION GUIDE GRIDDLE PLATES TROUBLESHOOTING GUIDE ADDITIONAL INSTALLATION REQUIREMENTS... -
Page 4: General Description
CH CHARBROILER OPERATION MANUAL INSTALLATION INSTRUCTIONS General: The instructions in this manual apply to all CH series Broilers. For units using propane gas, supply lines less than 1/2” inside diameter should not be used, The CH series may include the following options: even for a small unit. -
Page 5: Radiants
CH CHARBROILER OPERATION MANUAL INSTALLATION INSTRUCTIONS pilot burner that must be lit before the burners can be (c) Drop the rear end of the burner over the burner support pin on the back of the unit. lit. To light the pilot burners: Radiants: (a) Turn all broiler valves to the off position. -
Page 6: Additional Installation Requirements
CH CHARBROILER OPERATION MANUAL INSTALLATION INSTRUCTIONS Additional Installation Instructions (a) Remove the grease pans from their rails completely and set aside. (a) Keep the area around the broiler free and clear of combustible materials. (b) Unscrew to remove the legs from the broiler. Discard. -
Page 7: Operating Instructions
Broiler top grates must be hot enough to make degree of doneness is attained. black char-marks when starting to broil. (e) Cooking Tools: Bakers Pride has designed a Adequate pre-heating time is necessary for the food number of tools to help you operate more to release from the broiler and to cook properly. -
Page 8: Helpful Hints
Bakers Pride. Contact Bakers Pride for more information. (c) Do not use forks or other sharp objects which poke holes in the meat. -
Page 9: Average Production Guide
CH CHARBROILER OPERATION MANUAL OPERATING INSTRUCTIONS Average Production Guide: Estimated Hourly Production MODEL NUMBER BROILING AREA 3 OZ. BURGERS 12 OZ. STEAKS CH-6 31 1/2” x 24” CH-8 42” x 24” 1200 CH-10 52 1/2” x 24” 1500 The table above gives estimated hourly production as a guide only. Actual production may vary depending on required doneness, thickness and weight of product. -
Page 10: One Burner Fails To Light
Attempt to relight using For additional information contact: Bakers Pride Oven Co., Inc. (800) 527-2100. Troubleshooting Chart PROBLEM... -
Page 11: Valve Assembly Views
CH CHARBROILER OPERATION MANUAL VALVE ASSEMBLY VIEWS Valve Assembly Views: (A=Cap Hold-Down Screw) Figure 2: Air Mixer Cap And Pilot Burners Figure 3: Side View - CH Series... -
Page 12: Parts Lists & Exploded Views
CH CHARBROILER OPERATION MANUAL PARTS LISTS AND EXPLODED VIEWS EXPLODED VIEW – CH-6, 8, & 10 Note: When ordering, ALWAYS specify Part #, Model #, Serial #, Voltage/Phase and Gas Type. - Page 13 CH CHARBROILER OPERATION MANUAL PARTS LISTS AND EXPLODED VIEWS Item Part No. Description Item Part No. Description T1006A Top Grate 5 1/4' Wide 2 T3079V S/S Heat Shield w/Handle (CH-6) T1217U Grate, Meat (4 1/2") T3080V S/S Heat Shield w/Handle (CH-8) T1210U Grate, Meat (6") T3081X...
- Page 14 BP SERIES RANGES OPERATION MANUAL NOTES:...
-
Page 15: Parts List & Exploded View
Baker's Pride sole obligation under this warranty is limited to either and proper use and maintenance service as specified by Bakers Pride repair or replacement parts, subject to the additional and upon proper installation and start-up in accordance with the limitations detailed below. - Page 16 265 Hobson St. • Smithville, TN 37166 Phone 800.527.2100 | bakerspride.com Be sure to keep up with new product announcements and events on social media! Social icon Square Only use blue and/or white. For more details check out our 2M-U6023A REV B (11-22) Brand Guidelines.
Need help?
Do you have a question about the DANTE CH Series and is the answer not in the manual?
Questions and answers