Maintenance; Cleaning And Sanitizing Procedures; General - Delfield Shelleyglas Series Installation, Operation And Maintanance Manual

It is the responsibility of the equipment owner to
perform a personal protective equipment hazard
assessment to ensure adequate protection during
maintenance procedures.
Failure to disconnect the power at the main power
supply disconnect could result in serious injury or death.
The power switch DOES NOT disconnect all incoming
power.
Disconnect electric power at the main power disconnect
for all equipment being serviced. Observe correct
polarity of incoming line voltage. Incorrect polarity can
lead to erratic operation.
n
Never use sharp objects or tools to remove ice or frost.
Do not use mechanical devices or other means to
accelerate the defrosting process.
n
Use a jack to lift the refrigeration unit off the ground
just far enough to remove the leg. Place blocking
underneath the unit. Do not work underneath a raised
unit without proper blocking. Do not lift the unit more
than necessary to remove the leg. Lifting the unit too far
can make the unit unstable.

Maintenance

Interior
Gasket
Exterior
Drain
Condenser Coil
Part Number: 9291493 REV00 11/19
Maintenance
DANGER
DANGER
DANGER
Warning
Warning
Daily Weekly
X
X
X
X
Section 4
Never use a high-pressure water jet for cleaning or hose
down or flood interior or exterior of units with water.
This will void the warranty. Do not use power cleaning
equipment, steel wool, scrapers or wire brushes on
stainless steel or painted surfaces.

Cleaning and Sanitizing Procedures

Maintenance and servicing work other than cleaning as
described in this manual must be done by an authorized
service personnel.

GENERAL

When using cleaning fluids or chemicals, rubber gloves
and eye protection (and/or face shield) must be worn.
You are responsible for maintaining the equipment
in accordance with the instructions in this manual.
Maintenance procedures are not covered by the warranty.
Monthly
X
Warning
n
Caution
,
Warning
n
After Prolonged
Shutdown
X
X
X
X
X
At Start-Up
X
X
X
X
X
25