Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for Delfield KCM-50
Summary of Contents for Delfield KCM-50
- Page 1 ® Shelleyglas /Shelleysteel™ Service and Installation Manual Please read this manual completely before attempting to install or operate this equipment! Notify carrier of damage! Inspect all components immediately. See page 2. Refrigerated, Heated and Non-Electrical Units Effective March 2003...
-
Page 2: Table Of Contents
8. Retain all crating material until an inspection has been made or waived. For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com SERIAL NUMBER INFORMATION If your unit is heated, the serial tag is located above the louvered panel near the on/off switch. -
Page 3: Specifications
Milk and Ice Cream Counters 404A 1199/2040 SCFM-50 SCFM-74 Carving Counter Trimline L-shaped Heated Serving Counter SLT4 (-L OR -R) 208-230/60/1 For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com VOLTAGE/ NEMA HERTZ/PHASE PLUG 120/208-230/60/1 14-20P 120/208-230/60/1... -
Page 4: Installation
Fill the food well with about two inches of water and cover with lid or empty pan. To preheat water, set temperature For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com Electrical Connections Connections must be made in accordance with all applicable local codes and/or the National Electrical Code. -
Page 5: Operation
1 to 7; 7 being the coldest. To turn the cold pan off, turn the knob to the off position. The cold pan is not intended to be used with ice. For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com... -
Page 6: Pressure Control Settings
Over shelves and other items mounted to the top of the counters should never be installed in the field due to the potential damage to the refrigeration system. For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com Pressure control settings: KCSC/SCSC, KHCR/SHCR & KCFT/SCFT... -
Page 7: Cleaning Liquitec
FOOD WELL ASSEMBLY Shelleyglas ® /Shelleysteel™ Service and Installation Manual — KH/SH/-NU SERIES WITH INFINITE CONTROLS 208/230V For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com Part Description KNOB, INFINITE CONTROL INSULATION, BLANKET THERMOSTAT, NON-ADJ, 550°F ELEMENT, HEATING, 208/230V,1000/1222W... -
Page 8: Wiring Diagram
— UNITS WITH INFINITE CONTROLS NEUTRAL WIRE FOR 120 VOLT OPTIONS NEUTRAL 120/208-240V-37A-1PH NEMA #14-50P CORD/PLUG SUPPLIED For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com (DPST SWITCH) MASTER ON/OFF SWITCH 1 INFINITE CONTROL FOOD WELL INFINITE CONTROL... -
Page 9: Wiring Diagram
MASTER ON/OFF SWITCH 2 FOOD WELL INFINITE CONTROL FOOD WELL INFINITE CONTROL FOOD WELL INFINITE CONTROL For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com PILOT LIGHT LIMIT SWITCH HEATER PILOT LIGHT LIMIT SWITCH HEATER PILOT LIGHT... - Page 10 — KCSC, SCSC, KCFT AND SCFT COLD PANS �� ������ ������ ����������������������� ������������������������ For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com PLEASE REFER TO PAGES 8 AND 9 FOR INFORMATION ON THE HOT PAN SECTION OF COMBINATION MODELS. � ��������������� �������������...
-
Page 11: Replacement Parts List
WIRING DIAGRAM — KCFM, SCFM ������ ������ ��� ���������� ���������� � ������� � � ������������� ������ ������ ���������� � ������� � � ������������� UNITS SUPPLIED WITH EVAPORATOR PRESSURE REGULATOR For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com... -
Page 12: Standard Labor Guidelines
/Shelleysteel™ Service and Installation Manual STANDARD LABOR GUIDELINES TO REPAIR OR REPLACE PARTS ON DELFIELD EQUIPMENT Advice and recommendations given by Delfield Service Technicians do not constitute or guarantee any special coverage. • A maximum of 1-hour is allowed to diagnose a defective component. -
Page 13: Parts List
3234242 Plastic Drain 6320007 Bearing 6150201 Extension Spring 3234188 Large Lid 2193927 Pressure Control 2190154 Rocker Switch For customer service, call (800) 733-8829, (800) 773-8821, Fax (989) 773-3210, www.delfield.com SCFT-36, SCFT-50, SCFT-74, SCFT-36 3526716 Cond. Unit 3516101 Filter Dryer 3516225 Expansion Valve... -
Page 14: Standard One Year Warranty
Unit or any exhaust system. Delfield shall not be liable in any manner for any default or delay in performance hereunder caused by or resulting from any contingency beyond Delfield’s control, including, but not limited to, war,... -
Page 15: Additional Four Year Protection Plan
Unit manufacturer, repaired or altered by anyone other than Delfield in any way so as, in Delfield’s sole judgment, to affect its quality or efficiency or if the serial number has been altered, defaced or removed. -
Page 16: Authorized Parts Depots
980 S. Isabella Rd., Mt. Pleasant, MI 48804-0470, U.S.A. • (989) 773-7981 or (800) 733-8821 • Fax (800) 669-0619 • www.delfield.com Delfield reserves the right to make changes in design or specifications without prior notice. 2003 The Delfield Company. All rights reserved. Printed in the U.S.A.
Need help?
Do you have a question about the KCM-50 and is the answer not in the manual?
Questions and answers