Page 1
INSTALLATION OPERATING INSTRUCTIONS CONTACT BUN TOASTER INTENDED FOR OTHER THAN HOUSEHOLD USE M2000-JIB Model: RETAIN THIS MANUAL FOR FUTURE REFERENCE APPLIANCE MUST BE KEPT CLEAR OF COMBUSTIBLES AT ALL TIMES FOR YOUR SAFETY: Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
Warranty SAFETY PRECAUTIONS APW Wyott toasters are designed, built, and sold for commercial use and should be operated by trained personnel only. Clearly post all CAUTIONS, WARNINGS and operating instructions near each unit to insure proper operation and to reduce the chance of personal injury and/or equipment damage.
INSTALLATION Examine carton for damage The freight carrier has assumed responsibility for its safe transit and delivery. If equipment is received damaged, either apparent or concealed, a claim must be made with delivering carrier. Apparent damage or loss must be noted on the freight bill at the time of delivery. The carrier representative (Driver) the freight bill.
the correct height. Retighten lock nuts after adjustment is complete. a. To adjust the conveyor up into the drive gear, turn the conveyor adjustment screw clockwise. Use a 7/16-end wrench to tighten the jam nut. b. To adjust the conveyor away from the drive gear, turn the conveyor adjustment screw counterclockwise.
temperature setting to achieve desired brownness and temperature. Should the temperature setting be changed, allow several cycles for the grill plate to adjust. NOTE: Once the desired setting has been achieved, note the temperature and keep it set there. CLEANING WARNING: Make sure the toaster is in the off position and has been off at least 15 ...
ONE-TIME BOIL OUT OF CONVEYOR NOTE: This is for experienced operators only, and in stores that approve this operation. Turn off power and drain the oil from one of the Fryers, and allow it to cool. Turn Toaster main power switch off. Remove power supply plug from the wall outlet. Some surfaces will remain hot after toaster is turned off.
Page 7
If Teflon sheet is installed remove it when Bun Grill Toaster is cool. Set the toaster temperature to 350°F. Scrape loose food particles with scraper into a pan under grill plate. Squeeze 1 to 2 ounces of Scotch-BriteTM Quick Clean Small Appliance Cleaner No. 702 or equivalent into measuring reservoir of bottle.
Is power switch ON and pilot light glowing? Check the rating label. Is the unit connected to the correct power source? If the above checks out, and you still have problems, call an APW Wyott authorized service agent. APW SERVICE HOT LINE 1-800-733-2203...
PARTS LIST w/EXPLODED VIEW EXPLODED VIEW 53 55 10 21 31 32 14 17...
Page 11
PARTS LIST ITEM PART NUMBER DESCRIPTION QUANTITY 86260 PANEL, TOP FRONT 86219P ELEMENT, GRILL 208/240V 86204 PLATE, MOTOR MOUNTING 70202012 PANEL, CONTROL M-2000 86210 PANEL, LEFT SIDE OUTER 86207 PANEL, BACK 86261 PANEL, BOTTOM FRONT 70202009 LABEL, M2K JIB CONTROL 86233 ANGLE, GRILL PLATE 94200095...
WIRING DIAGRAM MOTOR 94200089 SPEED POT. 94000172 WIRE HARNESS 94200093 RTD PROBE 39100 RTD PROBE 39100 BLUE WHITE ORANGE BLACK IN LINE RESISTOR BLUE LIGHTED ROCKER SWITCH 89408 GREEN WHITE WHITE BLACK 6 PIN HARNESS 94100134 WIRE NUT 89149 3 PIN HARNESS 94100061 POWER SUPPLY 94100140 GREEN...
IMPORTANT FOR FUTURE REFERENCE Please complete this information and retain this manual for the life of the equipment. For Warranty Service and/or Parts, this information is required. Model Number Serial Number Date Purchased Notes:...
Page 15
APW Wyott's option or its Authorized Service Agency, it will be serviced on site or replaced. From day two through the conclusion of this warranty period, portable units must be taken to or sent prepaid to the APW Wyott Authorized Service Agency for in-warranty repairs.
Need help?
Do you have a question about the M2000-JIB and is the answer not in the manual?
Questions and answers