Table of Contents
Advertisement
GRILL INSTALLATION
This grill must be installed in accordance with all local codes.
Always keep the grill in a level position at all times
This grill is for outdoor use only. Never use in an enclosed or partially enclosed environment whether
permanent or temporary structure. This grill should only be used in an open air space.
Installing the Grill in a BBQ Island
NOTE: ALWAYS have equipment measured by Contractor before building.
To build in a kamado grill into an outdoor kitchen, one creates a non-combustible built in surface for the unit
to sit on in the outdoor kitchen. EVERY PART OF THE OUTDOOR KITCHEN CONSTRUCTION MUST BE
MADE OF NON-COMBUSTIBLE MATERIALS. (see page 12 for examples of unapproved materials)
The height of the cooking surface, amount of extra space around the unit, finishing around the outdoor
kitchen, etc. are all subject to personal preference once the unit physically has the room to fit and clearances
from combustibles are met. Diagrams showing grill dimensions can be found below on pages 12-13 for
planning purposes. Remember the side shelf kit is an optional accessory and typically not purchased for
those building into an outdoor kitchen. The below items will also need to be reviewed when building in:
•
Typically the cooking surface is positioned at or slightly higher than countertop height.
•
Please adhere to all required distances to combustibles in all directions around the non-combustible
island structure. Always give the minimum required distances from combustible surfaces (page 7).
•
In the event non-combustible materials are used behind the grill, allow enough space for the lid to open
(approximately an additional 8 inches behind the grill). A greater space behind the grill may be desirable
to reduce staining of the non-combustible wall caused by the smoke exiting the grill. See grill dimensions
on pages 12-13 for reference.
•
The outdoor kitchen construction must be made completely out of non-combustible materials.
•
Do not install underneath a combustible surface. This grill should only be used in an open air space.
•
Check to make sure the grill is level.
•
You will need a second person to help you avoid damaging the grill or your grill island
•
Allow for air flow to the lower draft door. This is critical to the function of the grill.
•
The motor of the optional rotis kit mounts onto the left hand outside of the grill body. Please allow enough
space for this accessory if it will be used (roughly 7" ). See grill dimensions on pages 12-13 for reference.
NOTE: Check with City and Fire department for Local Building Codes. A Permit may
be required for Outdoor Kitchen Construction.
Blaze Outdoor Products Instructional Book
Page | 11
Advertisement
Table of Contents
