Summary of Contents for Blaze Outdoor Products BLZ-4LTE2
Page 1
INSTALLER: PLEASE LEAVE THESE INSTRUCTIONS WITH THE CONSUMER. CONSUMER: PLEASE READ & RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE AND BEFORE INSTALLING OR OPERATING. - CONTACT INFORMATION - Blaze Outdoor Products: 6620 Greenwell Springs Rd, Baton Rouge, LA 70805 USA Phone: 866-976-9510 CustomerService@BlazeGrills.com BLAZEGRILLS.COM...
Outdoor Kitchen Ventilation 22-23 ii. Building BBQ Specifications and Instruction 23-25 iii. Installation Diagrams VII. First Time Operation i. Lighting the Appliance 27-28 ii. Manually Lighting the Appliance 28-29 iii. Flame Adjustment 29-30 Blaze Outdoor Products Instructional Book Page | 2...
Page 3
Preheating the Infrared Burner iii. Infrared Burner Cleaning Fuel Conversion i. Gas Regulator 33-34 Main Burner iii. Rear Burner XI. Warranty Registration XII. Grill Parts XIII. Product Serial Number XIV. Blaze Product Registration Blaze Outdoor Products Instructional Book Page | 3...
Page 4
THIS MANUAL APPLIES TO THE FOLLOWING BLAZE GRILLS Model: BLZ-5LTE2 / 5 BURNER Model: BLZ-4LTE2 / 4 BURNER Cutout Dimensions 30 5/8”W x 21 1/4”D x 8 1/2”H* Cutout Dimensions 38 3/8”W x 21 1/4"D x 8 1/2”H* *These dimensions create the required air *These dimensions create the required air gap underneath this appliance.
*These dimensions create the required air gap underneath this appliance. This air gap serves multiple purposes, such as preventing a build-up of heat in the island cavity and helping provide proper airflow for combustions and/or cabinetry Blaze Outdoor Products Instructional Book Page | 5...
Any non-approved alterations made to the appliance will void the product’s warranty. NOTE: The manufacturer cannot be held responsible for damage or injury caused by improper use of this appliance. Blaze Outdoor Products Instructional Book Page | 6...
Page 7
“T” handle type manual gas valve must be installed in the gas supply line to this appliance. This applies to permanently installed natural gas and propane installations. This does not apply to propane portable installations using a 20 pound tank. Blaze Outdoor Products Instructional Book Page | 7...
Page 8
Although an obstructed burner tube is not the only cause of “FLASH- BACK” it is the most common cause, and frequent inspection and cleaning of the burner tubes is necessary. Blaze Outdoor Products Instructional Book Page | 8...
Page 9
Never lean over the cooking surface when lighting or operating the appliance. • Use cooking utensils with wood handles and insulated oven mitts when operating the appliance. • Blaze Outdoor Products Instructional Book Page | 9...
DO NOT obstruct the flow of combustion and ventilation air to this appliance. • Keep any electrical supply cords and the fuel supply hoses away from any heated surfaces and/or sharp and aggressive edges. Blaze Outdoor Products Instructional Book Page | 10...
Page 11
When using a vent hood, the area above the cooking surface of the grill must be covered with a vent hood larger than the cooking area of the grill, and with a minimum of 1200 CFM for proper outdoor application. Blaze Outdoor Products Instructional Book Page | 11...
This appliance conforms to all uniform electrical safety codes and electrical grounding regulations. Install unit according to I.A.W. local codes or with National Electrical Code ANSI/NFPA 70 or CSA C22.1 in their absence. Blaze Outdoor Products Instructional Book Page | 12...
CHECK TO ENSURE THAT THE GAS SUPPLY HOSE DOES NOT COME IN CONTACT WITH ANY HOT SURFACE, SHARP OR ROUGH EDGES OF THE GRILL OR OUTDOOR KITCHEN CONSTRUCTION. DO NOT KINK THE GAS LINE WHEN INSTALLING. Blaze Outdoor Products Instructional Book Page | 13...
Page 14
Ensure that the service supplying the appliance is fitted with a shut off valve conveniently positioned near the appliance and giving ease of access. The appliance and its individual shutoff valve must be disconnected from the gas supply piping system during any pressure testing of that system. Blaze Outdoor Products Instructional Book Page | 14...
Check to ensure that flexible hoses do not have any cuts and wear that may affect the safety before each use. Only the factory supplied hose and regulator must be used. Use only replacement regulator and hose assemblies specified by BLAZE OUTDOOR PRODUCTS. Checking for Gas Leaks Perform a leak test before each use whether the gas supply cylinder has been disconnected or not.
Page 16
Open the valve (shut-off or ‘ON’ LP tank). Test for leaks by applying liquid soap solution to all joints. Bubbles forming indicate gas leak. Blaze Outdoor Products Instructional Book Page | 16...
• Never store any spare or extra gas cylinder(s) around or in the outdoor kitchen containing the BLAZE GRILL or any other open flame, heat-producing appliance(s) or heat source. Blaze Outdoor Products Instructional Book Page | 18...
Transport only one cylinder at a time. Ensure the cylinder is secured in an upright position with the control valve turned off and the dust cap in place. Store cylinders outdoors and out of the reach of children. Do not store cylinders in a building, garage, or any other enclosed area. Blaze Outdoor Products Instructional Book Page | 19...
Page 20
6. To disconnect after you have used the appliance, turn the burner knobs to the OFF position. 7. Close the Cylinder Valve by turning the Hand Wheel counter-clockwise until it stops. 8. Disconnect the regulator from the LP cylinder after use. Blaze Outdoor Products Instructional Book Page | 20...
This can back up the heat behind the control panel potentially creating a gas leak, damage to the product, and injury. A wind block behind the grill may be necessary. Blaze Outdoor Products Instructional Book Page | 21...
NG/Natural Gas: Natural gas is lighter than air and will rise to the highest levels of the outdoor kitchen. It is imperative to provide adequate cross ventilation for the areas where gas can accumulate at these higher levels of the island cavity. Blaze Outdoor Products Instructional Book Page | 22...
Before installing the grill into the island cutout, the main burner cotter pins may be removed for convenience of service, adjustments, and maintenance in the future. These are accessible from the outside rear of the grill. Blaze Outdoor Products Instructional Book Page | 23...
Page 24
Perform the leak test procedure as described earlier in this manual. • Connect the transformer to the grill, then into the electrical outlet. Be sure to follow all of the electrical safety and instructions found on page 12. Blaze Outdoor Products Instructional Book Page | 24...
Page 25
*These dimensions create the required air gap underneath this appliance. This air gap serves multiple purposes, such as preventing a build-up of heat in the island cavity and helping provide proper airflow for combustions and/or cabinetry Blaze Outdoor Products Instructional Book Page | 25...
You will hear a loud click as the electronic lighter produces a spark. Listen for the sound of the gas igniting and look for a flame through the cooking grids. If the burner does not light on the first try, repeat Blaze Outdoor Products Instructional Book Page | 27...
Wait five minutes until the gas clears before attempting to light it again. If the burner does not light after several attempts, immediately close all gas valves and consult an authorized service technician. Blaze Outdoor Products Instructional Book Page | 28...
With the cooking grids and flame tamers removed, light the main burners and run them on the high setting. d. Inspect burners for proper flame appearance. The ideal flame appearance is one that is mostly blue Blaze Outdoor Products Instructional Book Page | 29...
Before installing the cover, always allow the surface to dry. DO NOT cover a damp appliance. Blaze Outdoor Products Instructional Book Page | 30...
Page 31
Failure to meet these conditions can cause dangerous conditions that can cause personal injury and/or property damage. Blaze Outdoor Products Instructional Book Page | 31...
This allows any food particles or grease drippings to burn away. Once your appliance has cooled completely, use a soft brush or vacuum to remove any ash accumulation on the burner if necessary. Blaze Outdoor Products Instructional Book Page | 32...
2. If converting to Natural Gas, a low pressure regulator with an outbound pressure set to 4” of Water Column pressure must be used. 3. With either setup, remember to always check for gas leaks after the job is complete (see checking for gas leaks). Blaze Outdoor Products Instructional Book Page | 33...
Page 34
Blaze Outdoor Products Instructional Book Page | 34...
For the Blaze 4 & 5 Burner, replace the back burner orifice by removing the plate on the rear of the BBQ and carefully removing the fitting. Replace with the provided conversion back burner orifice – large brass fitting (differs from small main burner orifice). Blaze Outdoor Products Instructional Book Page | 35...
Blaze Outdoor Products shall not be liable under this or any implied warranty for incidental or consequential damages and Blaze Outdoor Products liability is limited to the purchase price of the appliance only. This warranty gives you specific legal rights, and you may also have other rights, which may vary from state to state. This warranty is applicable in the United States and Canada only.
Blaze 4 & 5 LTE (4-burner pictured) Note: BLZ-4LTE2 is depicted above. Add one burner, one flame tamer, one heat separator and one grid for the Blaze 5 LTE. Blaze Outdoor Products Instructional Book Page | 37...
Appliance model: Appliance serial number: Type of fuel being used: □ Propane □ Natural Gas Date purchased: Date installed: Blaze dealer’s name: Blaze dealer’s address: Blaze dealer’s phone number: Blaze Outdoor Products Instructional Book Page | 38...
What is the model number of the Blaze Product purchased? What is the serial number on the Blaze product? Where did you buy your Blaze product? Mail To: Blaze Outdoor Products, Warranty Registration, 6620 Greenwell Springs Rd Baton Rouge, LA 70805 Blaze Outdoor Products Instructional Book Page | 39...