Page 1
Vaccine/Water-pack Freezer (Deep Freezer) Operation Manual Model: HBD-116 HBD-286 Read the Operation Manual carefully before using your appliance. Keep the Operation Manual in a safe place. Appearance , color and layout of the door may vary. This freezer is designed for storage of vaccines and water-pack frozen.
Page 2
Type Designation/Trademark: HBD-116 Haier HBD-286 Manufactures Name : Haier Medical and Laboratory Products Co.,Ltd. Manufactures Address : Haier Industrial Park, Economic Technology Development Zone. Qingdao 266510.P.R.China Refer to in this declaration confirms with the following directive(s)/standards: 2006/42/EC, EN60335-1, EN60335-2-89 EN62233...
5℃~45℃ Humanity design such as drainage pipe line, safe lock, etc. We apologize that the Haier vaccine freezer provided for you may be a little different from the figure in the manual due to product improvement.
Safety Precautions Dear users: Hello! Thanks for your choice of Haier vaccine freezer; please make sure you have carefully read and observed the contents with following signs in the manual, for better understanding of this manual and better use of this product, so as to prevent personal injuries and freezer damage.
Page 6
Do not place containers with water or heavy stuffs on the freezer. Personal injuries may be caused by falling articles and electrical leakage or shock may be caused by out flowed water due to deterioration of insulation. Do not ground the freezer through gas pipes, water supply pipes, telephone lines or lightning conductors.
Page 7
Check freezer settings when restarting the freezer after power outage or the power is shut off. Changes of settings may damage the articles stored. The freezer shall be reconnected after more than 5 minutes once it is shut off, to prevent damage to compressor or system.
Precautions for Use If the freezer has been out-of-service for a long time and the battery of freezer controller has run out, the power failure alarm will not work. After the freezer is powered on, the battery of controller will charge automatically. After continuous operation for 24 h, the freezer will be fully charged then.
Product Installation Installation environment Ambient temperature: 5℃ ~ 45℃. Ambient humidity: 15% ~ 90%. Avoid excessive dust. Avoid mechanical swing or vibration. Rated power supply: 220V ~ 240V/50 Hz. As it is sensitive to ambient temperature. Normal operation will be impossible for freezer if it is installed in environments other than those described above.
Page 10
Preparation before use 1. Remove the packaging materials and strings Remove all packaging materials and strings for transport. To handle the freezer before unpackaging, forklift or package carrier may be used. If the forklift is used, it shall be inserted at the bottom of blocking from the front or back of the freezer to move the freezer.
Page 11
Initial Power-on Observe the rules below for initial start-up and continuous operation: When the freezer is empty, connect the power line to dedicated socket that meets the standard. Make sure that the power supply is 220~240V/50Hz. After power-on, turn on the power switch. The audible alarm may ring and this is normal. Press any button to cancel the alarm.
Page 12
This product is vaccine freezer. The temperature in the freezer is set as -15~-25°C. Please make sure that the articles stored comply with environment within the cabinet, to avoid article damage and economic loss. Due to refrigeration inertance, temperature and humidity displayed have certain difference with the practical value in the freezer.
Component Names Component Names Door handle Inner cover plate Door lock Blue ice rafts (Different quantity for different models) Foam freezer Drain hole Control panel Storage basket...
Introduction to Components To ensure best performance of this series of vaccine freezers, please read and understand structure of your equipment and precautions to avoid any loss. Handle and door lock Please use the handle to open or close the door to avoid hand pinching. There is safety lock on the handle, please use it appropriately to guarantee the safety of articles in the freezer.
Application method Description of temperature controller Up-regulation button Function button Set button Down-regulation button : Power-on mark - indicates that the power is switched on : Refrigerating mark - indicates that the refrigerating system is being operated : Lock mark - indicates that the screen is locked : Alarm mark - indicates that there is an alarm (be accompanied with buzzing alarm in normal condition) When there is a buzzing alarm, it can be canceled by pressing any button.
Page 16
Default set temperature of this series of product is different due to difference of actual volume and refrigerating system. Under normal condition, the best performance will be obtained if it is operated in accordance with temperature set in the table below. Model HBD-116 HBD-286 Default set temperature Enquiry of historical data 1,Enquiry of highest &...
Page 17
Use of the drain pipe Please follow the following steps in case of draining: 1. First, place a water container under the drain plug and pull out the drain plug in the front of the refrigerator. To accelerate the process of defrosting, a flat container with hot water of less than 50℃...
Cleaning and Maintenance Component Cleaning In order to prevent electrical shock or personal injury, make sure that the power of freezer is cut off before conducting any repair to the freezer. Make sure that you do not intake any drug or suspended particulate around the freezer when you are maintaining the freezer, or else it may be harmful to your health.
Page 19
Defrosting If the frost is too thick, it will influence the refrigeration effect of freezer. When the frost thickness reaches 6-8mm, it is necessary to conduct defrosting. In button unlock state, press both “Fn” and “ ” for 3s, it will enter “forecd defrost” mode. The display will show the controller temperature and “dF”...
This chapter explains to you various faults and phenomena that are potential to happen and their solutions. Call the Haier after-sale service if the question hasn’t been resolved after operation. Do not disassemble and repair the freezer without authorization.
Specification Specification Vaccine/Water-pack Freezer (Deep freezer) Name Model HBD-116 HBD-286 Gross volume 121 L 298 L Door Foaming door Foaming door Foaming Agent CP/IP Totally enclosed imported compressor Compressor Number of blue ice rafts 2 on the top; 2 on the bottom 3 on the top;...
Page 23
Packing List HBD-286 HBD-116 Name Manual Plastic bag Number of blue crafts 2 on the top; 2 on the bottom 3 on the top; 5 on the bottom Storage basket Defrosting shovel Alcohol stem thermometer...
Page 24
Certificate of Quality Checker: Manufacturer: Haier Medical and Laboratory Products Co., Ltd. Address: Haier Industrial Park, Economic Technology Development Zone. Qingdao 266510.P.R.China Web:www.haiermedical.com Revision date:10/2017 Version:1st,2017 Dedicated code:0270501281 V13026...