Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Southworth PPA
Summary of Contents for Southworth PPA
- Page 1 Owner’s Manual Air Bag Lift Tables Airbag Lift Manual for PPA, GTA, GLSA & GLTA Models SOUTHWORTH PRODUCTS CORP PO Box 1380, Portland, ME 04104-1380 Distributed by Ergonomic Partners Email: sales@ergonomicpartners.com Web: www.ergonomicpartners.com PH: 314-884-8884 | FAX: 800-570-5584 August 2017...
- Page 2 Please note: This manual was current at the time of printing. To obtain the latest, most updated version, please contact Southworth’s Customer Service Department or go to our website: www.SouthworthProducts.com, under Parts & Service you will find a complete list of current owner’s manuals to print.
-
Page 3: Table Of Contents
Figure 1: Safe Servicing of Lift ..............9 Figure 2: Lift Assembly - 2,000 ..............14 Figure 3: Tilt Assembly - 2,000 ..............15 Figure 4: Lift/Tilt Assembly- 2,000 ..............16 Figure 6: Foot Control Schematic ..............17 Southworth Air Bag Lift Tables... -
Page 4: Introduction
5.) The cfm is best expressed as “free air.” Meaning it is measured (or calculated) as a volume blowing out an open line. 6.) Southworth capacity ratings and speed estimates on all models are based on 80 psi at 80 cfm, free air. -
Page 5: Responsibility Of Owners And Users
It is the responsibility of the user/purchaser to advise the manufacturer where deflection may be critical to the application. Repairs All repairs shall be made by qualified personnel in conformance with Southworth’s instructions. Operators Only trained personnel and authorized personnel shall be permitted to operate the lift. -
Page 6: Safety Alert Symbols And Signal Words
SAFETY INSTRUCTIONS (or equivalent) signs indicate specific safety- related instructions or procedures. NOTE: DANGER, WARNING or CAUTION should not be considered for property damage accidents unless personal injury risk appropriate to these levels is involved. Southworth Air Bag Lift Tables... -
Page 7: Rise Times
The following chart should be helpful. These speeds are all approximate. CONDITION LIFT TILTER RAISE-LOADED 30 SECONDS 20 SECONDS LOWER-EMPTY 30 SECONDS 30 SECONDS RAISE-EMPTY 15 SECONDS 15 SECONDS LOWER-LOADED 15 SECONDS 20 SECONDS Air Bag Reference Chart Southworth Air Bag Lift Tables... -
Page 8: Safety
Therefore, throughout this manual, Southworth has identified certain hazards that may occur in the use of this machine and provided appropriate instruction or precautions that should be taken to avoid these hazards. In some cases, Southworth has also pointed out the consequences that may occur if Southworth’s instructions or... -
Page 9: Safe Servicing Of The Lift
7. Once inspection or work is complete, reverse the performance of the steps above to raise the lift off the maintenance device(s) and place the device(s) back into its/their designated storage position(s). Southworth Air Bag Lift Tables... -
Page 10: Installation Instructions
Complete Installation 1. Test the lift with the rated load. If the lift does not move contact Southworth for instructions. WARNING! Do not continue to use the lift if this happens. This can cause the lift to fail suddenly and you may be hurt. -
Page 11: Maintenance
They should be able to troubleshoot live pneumatic circuits safely and in accordance with accepted practice. FOR SAFETY’S SAKE, if in doubt, please contact your dealer or Southworth Products Corporation Customer Service Department at (207)878-0700 or (800)743-1000. -
Page 12: Troubleshooting
FOR SAFETY’S SAKE, if in doubt, please contact your dealer or Southworth Products Corporation Customer Service Department at (207) 878-0700 or (800) 743-1000. Before servicing the lift, read and understand this entire section and the section entitled “Operating Instructions.”... -
Page 13: Ordering Replacement Parts
ORDERING REPLACEMENT PARTS Southworth has carefully chosen the components in your lift to be the best available for the purpose. Replacement parts should be identical to the original equipment. Southworth will not be responsible for equipment failures resulting from the use of incorrect replacement parts or from unauthorized modifications of the machine. -
Page 14: Figure 2: Lift Assembly - 2,000
ITEM DESCRIPTION AIRBAG SCREW SCREW WASHER FITTING Figure 2: Lift Assembly - 2,000 RELIEF VALVE FITTING HOSE TEC FITTING FITTING CLIP FITTING HOSE FITTING Southworth Air Bag Lift Tables... -
Page 15: Figure 3: Tilt Assembly - 2,000
Figure 3. Tilt Assembly -- 2,000 Southworth Air Bag Lift Tables... -
Page 16: Figure 4: Lift/Tilt Assembly- 2,000
Figure 4: Lift/Tilt Assembly - 2,000 Southworth Air Bag Lift Tables... -
Page 17: Figure 6: Foot Control Schematic
Figure 6. Foot Control Schematic Southworth Air Bag Lift Tables... -
Page 18: Warranty
Labor is not included. This is buyer’s sole remedy. Except as stated herein, Southworth Products Corp will not be liable for any loss, injury or damage to persons or property, nor for direct, indirect, or consequential damage of any kind, resulting from failure or defective operation of said product.
Need help?
Do you have a question about the PPA and is the answer not in the manual?
Questions and answers