Related Manuals for HomComfort HCPHTTM
Summary of Contents for HomComfort HCPHTTM
- Page 1 Model: HCPHTTM United States Stove Company 227 Industrial Park Road South Pittsburg, TN 37380 www.usstove.com FOR TECHNICAL ASSISTANCE: PHONE: (800) 750-2723 853162---0802H...
- Page 2 Precautions WARNING: DANGER: The powder coating paint process has become the CARBON MONOXIDE HAZARD most common application in the outdoor furniture This appliance can produce carbon monoxide which category. Unfortunately powder coating is extremely has no odor. Using it in an enclosed space can kill you. sensitive to humidity and moisture.
- Page 3 d. Any guard or other protective device removed for servicing the heater must be replaced prior to operation the heater e. Installation and repair should be done by a qualified service person. The heater should be inspected before use and cleaning may be required at least once a year or as necessary. It is imperative that control compartment burner and circulation air passageways of the heater be kept clean.
- Page 4 Assembly WARNING: Proper assembly is the responsibility of the installer. Place the heater in a well-ventilated space and do not place in a building, garage, or any other enclosed area. An appliance must be installed with shelter no more inclusive than: 1.
- Page 5 STEP 5 STEP 7 Put the emitter screen on the burner. Use (4) four 3/16” Put (3) three washers on each pins of the 60mm bolts to connect the emitter screen to the burner. length. Tighten the bolts. STEP 8 STEP 6 Put the reflector through the pins and on the washers.
- Page 6 STEP 10 STEP 11 Turn off the control knob of the burner. Fix the 1 lbs. gas Close the door plate and lock it with the handle tank (not included) to the regulator (rotate the gas (rotate the handle 90 degrees) tank clockwise toward the regulator until tighten it).
-
Page 7: Operation
Operation WARNING: WARNING: DO NOT attempt to operate the heater until you have FOR YOU SAFETY read and understood all precautions. Failure to do so If at any time you are unable to light burner and smell can result in serious personal injury, death, and property gas, wait 5 minutes to allow gas to dissipate before damage. -
Page 8: Before Leaving
If you experience any ignition problem, turn off the heater and gas supply, and consult the troubleshooting section of this manual. CAUTION: Avoid inhaling fumes emitted form the heater’s first use. Smoke and odor from the burning of oils used in manufacturing will appear. -
Page 9: Maintenance
Maintenance CHECK YOUR HOSE ASSEMBLY The installation shall only be carried out by competent persons and be in accordance with the relevant codes of practice. WARNING: This appliance requires regulator. Check with your gas supplier and or products supplier. Prior to use, check for damaged parts such as regulator, pilot or burner. Never replace or substitute the regulator with any regulator other than the factory suggested replacement. -
Page 10: During Periods Of Extended Inactivity Or When Transporting
Storage BETWEEN USES • Turn the control knob to the “OFF” position. • Open the door and disconnect the cylinder. • Store the heater upright in an area sheltered from direct contact with inclement weather (such as rain, sleet, hail, snow, dust and debris). •... - Page 11 Parts Key Part No. Description Qty. 892958 Reflector 892959 Emitter Screen 892960 Guard 81299 Burner Assembly 81300 Regulator ATTENTION: In order to maintain warranty, components must be replaced using original manufacturers parts purchased through your dealer or directly from the appliance manufacturer. Use of third party components will void the warranty.
- Page 12 Notes...
-
Page 13: Service Record
Service Record It is recommended that this unit is serviced regularly and that the appropriate Service Interval Record is completed. Service Provider: Before completing the appropriate Service Record below, please ensure you have carried out the service as described in the manufacturer’s instructions. - Page 14 Distributed By: United States Stove Company www.usstove.com 227 Industrial Park Rd (800) 750-2723 South Pittsburg, TN 37380 1 year limited warranty - Customers in the Continental US All components are warranted for a period of 1 year after date of purchase by the original owner against defects in materials and workmanship under normal use.