Fluids - Audi RS 3 LMS SEQ User Manual

Fluids

Area Fluid
Engine RAVENOL VMP SAE 5W-30
Gearbox RAVENOL Racing gear oil
Clutch RAVENOL Racing brake fluid R325+
Drive shaft GKN grease
RAVENOL LGC
Coolant
VW AG G13 10% add./90% dist. water
Brake fluid RAVENOL Racing brake fluid R325+
Fuel Min 98 RON
Windscreen Free
Notes:

Standard fuel minimum 98 RON from petrol stations may be used.

Is recommended not to mixt fuels, they could contaminate one from the other.

Gearbox is delivered with correct oil level. It is not necessary any level control if there is no leakage.
Engine
Control routine before start to run:

Check the oil level: with oil temperature up to 70°C, stop the engine and wait 2 minutes, then check
the oil dipstick. The oil level must be at the top of the marked zone.

Check the water level before start.

With the engine running, check that there is not any oil, water or fuel leakage.

Check the fan functionality. Operating range 92°C to 87°C.
Maintenance routine:

Change the engine oil and oil filter at the indicated mileage.

Engine spare parts must be from VW group or Audi Sport original parts, detailed on the Audi RS 3
LMS Spare Parts Catalogue.

Use always the fluids detailed above, User Manual point 5.4.

Clean and check the air filter at least once per event. At urban circuits, clean or replace it more
frequently. It is recommended to have two or three air filters and replacing it during the weekend.
Changing it is strongly recommended in case of rain.

Check that the alternator belt is clean and that there are not small stones inside the Poly-V.

Clean the radiator and intercooler panel often.

If any doubt, contact Audi Sport technical assistance department.

Check that the seals are in good conditions, if a replacement is needed contact Audi Sport.
Parts subject to frequent service:
Engine
Oil drain plug
Oil filter plastic cover
Oil filter
Spark plug
For detailed parts substitution information download the Workshop Manual from Audi Sport website.
Air filter
Standard air filter cleaning procedure:
1. Remove the air filter from the car and plug opening to throttle body with a clean rag to stop any
crud getting where it shouldn't.
Torque Remarks
By hand
25 Nm
Moisten the O-ring
28 Nm Use only original parts
Quantity
5,7 l
1,75 l
-
100 gr
5 l
-
-
-
44