Federal Signal Corporation UltraVoice Remote Interface Installation, Operation And Service Manual
  1. Manuals
  2. Brands
  3. Federal Signal Corporation Manuals
  4. Controller
  5. UltraVoice
  6. Installation, operation and service manual
Federal Signal Corporation UltraVoice Remote Interface Installation, Operation And Service Manual

Federal Signal Corporation UltraVoice Remote Interface Installation, Operation And Service Manual

Hide thumbs Also See for UltraVoice Remote Interface:
Table of Contents

Advertisement

Quick Links

Download this manual See also: Installation Manual
!
!
UltraVoice
Remote Interface
®
Model: UVRI
!
Installation, Operation, and
Service Manual
255385
Rev. C3 0718
Printed in U.S.A.
© Copyright 2018 Federal Signal Corporation
!
!

Advertisement

Table of Contents
loading

Related Manuals for Federal Signal Corporation UltraVoice Remote Interface

Summary of Contents for Federal Signal Corporation UltraVoice Remote Interface

  • Page 1 UltraVoice Remote Interface ® Model: UVRI Installation, Operation, and Service Manual 255385 Rev. C3 0718 Printed in U.S.A. © Copyright 2018 Federal Signal Corporation...
  • Page 2 This product is subject to and covered by a limited warranty, a!copy!of!which! can!be!found!at!www.fedsig.com/SSG9Warranty. A copy of this limited warranty can also be obtained by written request to Federal Signal Corporation, 2645 Federal Signal Drive, University Park, IL 60484, email to info@fedsig.com or call +1 708-534-3400.

  • Page 3: Table Of Contents

    1! TABLE!OF!CONTENTS! Section! Page! TABLE!OF!CONTENTS!....................! 3 ! SAFETY!MESSAGE!......................! 6 ! GENERAL!DESCRIPTION! ....................! 9 ! 3.1! Model!Number!Descriptions! ..................! 1 0! 3.2! Recommended!Cables.....................! 1 0! 3.3! UVRI!Part!Locations:....................! 1 1! 3.4! Initial!Configuration!....................! 1 3! 3.5! Programming!Methods! .....................! 1 8! 3.6! Status!Monitoring!.....................! 1 8! SPECIFICATIONS!......................! 1 9! 4.1!
  • Page 4 7.10! Remote!Mounted!Magnetic!Base!Antenna!Installation..........! 4 5! PRE9OPERATION!CHECKOUT!AND!TEST! ..............! 4 6! 8.1! Visual!Inspection!......................! 4 6! 8.2! Pre9Operation!Checkout!..................! 4 6! 8.3! Radio!Transceiver!Adjustment!Procedure! ..............! 4 7! 8.4! Control!and!Status!Monitoring! ..................! 4 8! MAINTENANCE!......................! 5 0! 9.2! Troubleshooting!.......................! 5 3! OPTIONS!........................! 5 4! 10.1! Radio!Control!......................! 5 4! 10.2! Digital!Voice!Recording! .
  • Page 5 TABLE!OF!FIGURES Figure!3.1!9!UVRI!Inside!View!....................! 1 1! Figure!3.2!9!UVRI!Parts!Layout!....................! 1 2! Figure!4.1!9!Motherboard!Outline!Drawing!................! 2 7! Figure!7.1!9!Typical!UVRI!Installation!Drawing!...............! 3 4! Figure!7.2!9!UVRI!Cabinet!Dimensional!Outline!Drawing!............! 3 5! Figure!7.3!9!UVRI!Wiring!Diagram! ..................! 3 6! Figure!7.4!9!UVRI!Remote!System!Sense,!Audio!Output!and!DC!Power!Connections!..! 4 4! Figure!7.5!9!Relay!Output!.......................! 4 4! Figure!8.1!9!Field!Test!Data!Sheet!..................! 4 9! Figure!9.1!9!UVRI!Motherboard!Connections!.................! 5 2! Figure!9.2!9!UVRI!Battery!Location!and!Cover!Plate!Mounting!Screws! ........! 5 2! Figure!11.1!9!UVRI!Final!Assembly!and!Parts!List!..............! 6 0!

  • Page 6: 2! Safety!Message

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 2! SAFETY!MESSAGE! It!is!important!to!follow!all!instructions!shipped!with!this!product.!This!device!is!to!be! installed!by!trained!personnel!who!are!thoroughly!familiar!with!the!country!electric!codes! and!will!follow!these!guidelines!as!well!as!local!codes.! Listed!below!are!important!safety!instructions!and!precautions!you!should!follow.! Important!Notice Federal!Signal!reserves!the!right!to!make!changes!to!devices!and!specifications! detailed!in!the!manual!at!any!time!in!order!to!improve!reliability,!function!or!design.!The! information!in!this!manual!has!been!carefully!checked!and!is!believed!to!be!accurateb! however,!no!responsibility!is!assumed!for!any!inaccuracies! PUBLICATIONS! Federal!Signal!recommends!the!following! !from!the!Federal!Emergency! publications Management!Agency!for!assistance!with!planning!an!outdoor!warning!system: •! The!“Outdoor!Warning!Guide”!(CPG!1917)! •! “Civil!Preparedness,!Principles!of!Warning”!(CPG!1914)! •! FEMA9REP91,!Appendix!3!(Nuclear!Plant!Guideline)! •! FEMA9REP910!(Nuclear!Plant!Guideline)! PLANNING! •! If!suitable!warning!equipment!is!not!selected,!the!installation!site!for!the!siren!is!not! selected!properly!or!the!siren!is!not!installed!properly,!it!may!not!produce!the! intended!optimum!audible!warning.!Follow!Federal!Emergency!Management!Agency! (FEMA)!recommendations •! If!sirens!are!not!activated!in!a!timely!manner!when!an!emergency!condition!exists,! they!cannot!provide!the!intended!audible!warning.!It!is!imperative!that! knowledgeable!people,!who!are!provided!with!the!necessary!information,!are! available!at!all!times!to!authorize!the!activation!of!the!sirens •! When!sirens!are!used!out!of!doors,!people!indoors!may!not!be!able!to!hear!the! warning!signals.!Separate!warning!devices!or!procedures!may!be!needed!to! effectively!warn!people!indoors •! The!sound!output!of!sirens!is!capable!of!causing!permanent!hearing!damage.!To!
  • Page 7 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! •! Activating!the!sirens!may!not!result!in!people!taking!the!desired!actions!if!those!to!be! warned!are!not!properly!trained!about!the!meaning!of!siren!sounds.!Siren!users! should!follow!FEMA!recommendations!and!instruct!those!to!be!warned!of!correct! actions!to!be!taken •! After!installation,!service,!or!maintenance,!test!the!siren!system!to!confirm!that!it!is! operating!properly.!Test!the!system!regularly!to!confirm!that!it!will!be!operational!in! an!emergency •! If!future!service!and!operating!personnel!do!not!have!these!instructions!to!refer!to,! the!siren!system!may!not!provide!the!intended!audible!warning!and!service! personnel!may!be!exposed!to!death,!permanent!hearing!loss,!or!other!bodily!injury.! File!these!instructions!in!a!safe!place!and!refer!to!them!periodically.!Give!a!copy!of! these!instructions!to!new!recruits!and!trainees.!Also!give!a!copy!to!anyone!who!is! going!to!service!or!repair!the!siren.! INSTALLATION!&!SERVICE! •! Electrocution!or!severe!personal!injury!can!occur!when!performing!various! installation!and!service!functions!such!as!making!electrical!connections,!drilling! holes,!or!lifting!equipment.!Therefore!only!experienced!electricians!should!install!this! product!in!accordance!with!national,!state!and!any!other!electrical!codes!having! jurisdiction.!Perform!all!work!under!the!direction!of!the!installation!or!service!crew! safety!foreman •! The!sound!output!of!sirens!is!capable!of!causing!permanent!hearing!damage.!To! prevent!excessive!exposure,!carefully!plan!siren!placement,!post!warnings!and! restrict!access!to!areas!near!the!sirens.!Sirens!may!be!operated!from!remote!control! points.!Whenever!possible,!disconnect!all!siren!power!including!batteries!before! working!near!the!siren •! After!installation!or!service,!test!the!siren!system!to!confirm!that!it!is!operating! properly.!Test!the!system!regularly!to!confirm!that!it!will!be!operational!in!an! emergency •! If!future!service!personnel!do!not!have!these!warnings!and!all!other!instructions! shipped!with!the!equipment!to!refer!to,!the!siren!system!may!not!provide!the! intended!audible!warning!and!service!personnel!may!be!exposed!to!death,! permanent!hearing!loss,!or!other!bodily!injury.!File!these!instructions!in!a!safe!place! and!refer!to!them!periodically.!Give!a!copy!of!these!instructions!to!new!recruits!and! trainees.!Also,!give!a!copy!to!anyone!who!is!going!to!service!or!repair!the!sirens...
  • Page 8 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! OPERATION! Failure!to!understand!the!capabilities!and!limitations!of!your!siren!system!could!result!in! permanent!hearing!loss,!other!serious!injuries!or!death!to!persons!too!close!to!the! sirens!when!you!activate!them!or!to!those!you!need!to!warn.!Carefully!read!and! thoroughly!understand!all!safety!notices!in!this!manual!and!all!operations9related9items! in!all!instruction!manuals!shipped!with!equipment.!Thoroughly!discuss!all!contingency! plans!with!those!responsible!for!warning!people!in!your!community,!company,!or! jurisdiction WARNING! Read!and!understand!the!information!contained! in!this!manual,!before!attempting!to!install!or!! service!this!product.! Pay!careful!attention!to!the!following!notices!located!on!the!equipment.! A.!NOTICES!M!EXTERNALLY!PLACED! B.!NOTICESMINTERNALLY!PLACED!

  • Page 9: General!Description

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 3! GENERAL!DESCRIPTION! The!UltraVoice!Remote!Interface!(UVRI)!provides!remote!control!and!status!monitoring! of! Fire! Alarm! and! PA! systems! to! create! a! fully! integrated! indoor! and! outdoor! Mass! Notification!System!when!used!with!the!Federal!Commander!Digital!Control!System.!The! UVRI! has! a! built9in! radio! transceiver! interface,! an! RS232! port,! and! optional! ethernet,! satellite,! and! telephone! line! interfaces! for! tying! into! communication! networks.! Built9in! warning!tone!generation,!live!voice!and!up!to!8!minutes!of!local!digital!voice!storage!is! included!in!all!models.!! The! UVRI! is! housed! in! a! non9metalic! indoor/outdoor! NEMA4X! /! UL50! rated! enclosure!

  • Page 10: Model!Number!Descriptions

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 3.1! Model!Number!Descriptions! All!UVRI!models!are!set!up!for!29way!control!and!status!monitoring!using!the!Federal! Commander!Digital!Control!system.!All!models!include!8!minutes!of!digital!voice! storage.!Custom!digital!voice!recording!requires!a!model!DVR.!! !CONTROLLER!OPTIONS!! !!!!!!!UVRI!MODEL!#! NO!RADIO!(RF)! UVRI! !UHF!BAND!Transceiver! UVRIU! !HIGH!BAND!Transceiver! UVRIH! Landline!Control! UVRI9LL! Ethernet!Control! UVRI9IP! Satellite!Control! UVRI9ISAT! Option!Exclusions:! The!UVRI9IP!and!UVRI9SAT!options!cannot!be!used!with!any!other!options!listed!above! at!the!same!time.! 3.2! Recommended!Cables! When!equipped!with!a!Vertex!Radio!(Model!VX92100)!in!your!two9way!RTUs,!Federal! Signal!recommends!purchasing!the!following!cables!for!computer!programming:! •! RIB!FIF912A!USB!interface!cable! •! CT9104A!interface!cable! Use!the!RIB!FIF912A!USB!cable!to!connect!to!your!computer.!Use!the!CT9104A!cable! to!connect!from!the!RIB!FIF912A!USB!cable!to!the!radio.! GENERAL!DESCRIPTION!

  • Page 11: Uvri!Part!Locations

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 3.3! UVRI!Part!Locations:! Figure!3.1!M!UVRI!Inside!View! GENERAL!DESCRIPTION!
  • Page 12 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! Power!Supply! Transceiver! Out! 120VAC!Sensor!Relay! (240VAC!w/9240!option)! Fuses AC!Input! Local!Activation!Buttons! Audio!Out! Antenna!Bulkhead! OuytOut! BiulBulkhead! Relay!Output! Ground! OupOutput! Lug! !!!!! Figure!3.2!M!UVRI!Parts!Layout! GENERAL!DESCRIPTION!

  • Page 13: Initial!Configuration

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 3.4! Initial!Configuration! Each!modular!UVRI!controller!contains!the!following!configuration!parameters!that!must! be! initially! configured.! Additional! programming! configuration! is! required! before! placing! the! UVRI! into! service.! Refer! to! the! programming! software! reference! manual! for! programming!information.! 1.! Unit!Type! 2.! RF!Frequency! 3.! Security!Key! 4.! 1289bit!Encryption!Key! 5.! Unit!Address!(see!below)! 6.! Configuration!Jumper!Settings! 3.4.1! Unit!Type! The!UVRI!unit!type!is!used!to!tell!the!front9end!control!system!how!to!communicate!with! the! UVRI.! This! is! configured! within! the! Federal! Commander! software! and! sent! to! the!
  • Page 14 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 3.4.4! 128Mbit!Encryption!Key! 1289bit!data!encryption!provides!security!against!malicious!operation!or!monitoring.!The! 1289bit!key!is!programmed!during!the!flashing!of!the!microprocessor!and!must!match! the!encoder!(SS2000+!or!SFCDWARE)!being!used!to!activate!the!unit.!A!key!value!of! zero!disables!1289bit!encryption!and!must!be!used!if!the!encoder!does!not!support!1289 bit!encryption.!All!sites!in!the!system!must!use!the!same!encryption!key.! 3.4.5! Unit!Address!! Site!Address!Switch:! The!unit!address!sets!the!UVRI!site!number!and!is!used!to!numerically!identify!the!site! within!the!system!network.!The!Unit!Address!is!a!three9digit!number!with!a!range!of!0019 1023.!The!unit!address!is!set!via!dip!switch!S1.!S1!Off!position!indicates!active!position.! Add!binary!active!switch!positions!to!get!ID!address.!! Switch!! No.! 1! 2! 3! 4! 5! 6! 7! Binary!! No.! 1! 2! 4! 8! 16! 32! 64! 128! 256! 512! Example:!The!illustration!above!shows!Switch!numbers!1,!2!&!3!in!the!active!position.! The!switch!in!the!example!above!represents!the!binary!numbers!1,!2!&!4,!which!when! added,!would!equal!unit!address!7.! Note:!The!address!must!be!set!to!address!(one)!to!program!a!controller!board!to!program! a! DTMF,! non9digital! unit.! When! the! programming! is! completed,! change! the! dip! switch! setting!to!the!actual!site!address.!Programming!details!are!in!the!Commander!software!
  • Page 15 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! address!is!changed,!cycle!power!to!the!control!board!by!removing!the!connector!at!JP3! on!the!motherboard!for!five!seconds.! 3.4.6! Control!Board!Configuration!Jumper!Settings! JP12!9!Short!to!force!radio!Carrier!Detect!of!External!transceiver!1! •! Jumper!out!=!Default!Setting! JP9!9!External!Transceiver!#1!VOX!(Audio!level!dependent!Carrier!Detect)! •! Jumper!OFF!=!VOX!Disabled!(Default!setting)! •! Jumper!ON!=!Carrier!detect!in!<!20mS!when!received!audio!exceeds!15%! deviation.! JP10!9!Dual!receiver!priority!jumper:! •! Jumper!"EXT"!side!to!give!external!receiver!#1!priority! •! Jumper!"INT/EXT2"!side!to!give!on9board!receiver!or!external!receiver!#2!priority!! •! Jumper!neither!side,!first!carrier!detect!has!priority! JP7!–!600!Ohm!Audio!Output! •! Jumper!pins!2!and!3,!Output!radio!transmit!audio!(Default!Setting)! •! Jumper!pins!1!and!2,!Output!siren!audio! JP6!–!600!Ohm!Audio!Input! •! Jumper!pins!2!and!3,!Input!audio!to!decoders!as!from!a!receiver!(Default!Setting)! •! Jumper!pins!1!and!2,!Input!audio!to!Amps!when!600!Ohm!PTT!is!asserted.! GENERAL!DESCRIPTION!
  • Page 16 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 3.4.7! User!Programs! The!UVRI!has!the!capacity!to!store!up!to!fifty!(50)!user!programs.!Each!user!program! contains!the!following!elements:! 1)! Optional!DTMF!Activation!Code!! 2)! Optional!Two9Tone!Activation!Code! 3)! Optional!EAS!Event!Code! 4)! POCSAG!code! 5)! Digital!activation!Code! 6)! List!of!up!to!20!functions! The!ability!to!assign!more!than!one!function!to!each!activation!code!or!user!program!is!a! new! feature! not! previously! found! in! electronic! sirens.! This! allows! the! user! to! run! a! sequence! of! functions! without! sending! additional! activation! commands,! greatly! enhancing! flexibility! while! reducing! operator! involvement! and! communication! channel! traffic.!! 3.4.8! Available!Functions:!!
  • Page 17 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! Power! Report! Record!PA!Message! Play!Recorded!PA!Message! RelayN!On!(Not!used!with!UVRI)! RelayN!Off!(Not!used!with!UVRI)! 3.4.9! Low!Power!Mode,!Hi!Power!Mode! This!causes!the!siren!to!operate!at!a!greatly!reduced!volume!level.!Upon!activation!of!a! user!program,!the!siren!defaults!to!Hi!(normal)!volume!level.!This!command!must!follow! an! ARM! command.! Reduced! volume! mode! will! remain! in! effect! for! all! subsequent! functions!in!a!user!program!that!follow!the!Low9Power!function!or!until!a!Hi9Power!function! occurs!or!an!ARM!command!is!sent.! 3.4.10!Delay!! The!delay!function!causes!the!siren!to!pause!(wait)!for!2!9!512!seconds!before!starting! the!next!function!of!the!user!program!currently!running.!When!selecting!the!delay!function,! the!user!will!be!prompted!to!enter!the!desired!delay!time!in!seconds.!A!default!delay!of!4! seconds!is!present!between!functions,!without!adding!a!delay.! 3.4.11!Power!Level! The!Power!function!allows!the!user!to!control!the!volume!level.!The!volume!can!be! adjusted!from!0!to!920!dB!in!1!dB!steps.!Reduced!volume!mode!will!remain!in!effect!for! all!subsequent!functions!in!a!user!program!that!follow!the!Power!function,!or!until! another!Power!function!occurs,!or!an!ARM!command!is!sent. GENERAL!DESCRIPTION!

  • Page 18: Programming!Methods

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 3.5! Programming!Methods! There!are!two!methods!of!entering!and!reviewing!the!user!programming!information!in!an! UltraVoice!electronic!siren!controller:! ® 1.! FSPWARE! Windows ! based! programming! software! for! 29tone! and! DTMF! controlled!systems.!This!software!requires!a!direct!connection!between!the!siren! and!the!computer’s!RS232!port.! ® 2.! SFCDWARE!Windows !based!digital!control!and!status!monitoring!software.!This! software!may!be!used!over!a!landline!or!wireless!radio!channel!as!well!as!over!an! RS232!port.!! Detailed!information!on!the!operation!of!the!Windows ® !program!is!beyond!the!scope!of! this!document!and!can!be!found!in!the!software’s!Help!file.!! 3.6! Status!Monitoring! The!UVRI!monitors!various!diagnostic!conditions!for!reporting!back!to!a!central!monitoring! station!using!optional!control!and!status!monitoring!hardware!and!software.! 3.6.1! Items!monitored! Siren!Type! Function!State!(code!running)! Unit!ID! Audio!A*! Audio!B*! Master!Current!/!Remote!System!Operation*! Battery!Voltage!

  • Page 19: Specifications

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 4! SPECIFICATIONS! 4.1! Electrical!! Battery!Voltage! On!at!11.5!VDC!/!off!at!10!VDC,! 13.7!volts!(nom.)! Battery!Current! <!80!mA.!standby!current,! <!120!mA!during!a!function! <7A!during!radio!transmit! Stand!By!Time!(with!minimum! 59minute!full!signal!reserve)! Greater!than!24!hours!! (With!radio!transceiver,!10!W,! 8!Tx!/!day)! 4.2! Power!Supply! AC!Input! 889264!VAC,!50960!Hz,!! Input!Current!(115/230!VAC)! 2.2/1.2!A! DC!Output! ! 13.5916.5VDC!(14VDC!Nom.),!7A! Immunity! IEC610009492,93,94,95,96,98,911! Conducted/Radiated!EMI! ! EN55011/EN550229B,!FCC9B! Terminal!Block!Wiring! 14922!AWG! Terminal!Block!Torque! 191.4!Nm!torque! SPECIFICATIONS!

  • Page 20: Battery

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 4.3! Battery! Rating:! 12!V,!12!A/H! Type:! PowerSonic!PS129120l!Absorbed! Glass!Matt!Valve!Regulated!Lead! Acid!(AGM!9!VRLA)! CAUTION:!!Substituting!batteries!may!be!hazardous!and!will!void!warranty.!! Use!specified!batteries!only.! 4.4! Relay!Output! Contacts!! DPDT,!28!VDC,!277!VAC,!10!A!! 4.5! Control!Board!(2005698M01)! 4.5.1! Serial!&!I C!Ports! Serial!Port!Protocol! ! RS232C!1200,N,8,1! C!Port!Protocol! Philips!Standard!I 4.5.2! Signaling!Formats! Number!of!codes! Up!to!50!activation!codes!maximum! Number!of!Functions!allowed!stacked! ! Up!to!20! under!each!code! Two9Tone!Sequential!or!Single!Tone! 282!Hz!9!3000!Hz! 0.5!sec!(A)!9!.25!sec!(B)!minimum! to!8!sec!maximum! DTMF!! 3!to!12!digits!standard! 50!ms/50!ms!timing!or!greater! FSK! Baud!rate!

  • Page 21: Controller!Front!Panel!Controls,!Jacks,!Switches!And!Indicators

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! EAS! ! AFSK,!520.83!baud Modem!Tones! 2083.3!Hz!and!1562.5!Hz! POCSAG! Supports!Binary!frequency!shift!keyed,!512!Baud!numeric!messages.! 4.6! Controller!Front!Panel!Controls,!Jacks,!Switches!and!Indicators! 4.6.1! Controls:! DV!GAIN! Internal!Digital!Voice!Level!sufficient!to!drive! TP3!or!TP4!into!clipping! TX!GAINs! Transmitted!Audio!outputs!adjustable!from!! 50!mV!to!1!Vpp! EXTERNAL!REC!GAINs! Received!Audio!Level!inputs!300!mV!to!3!Vpp! ! MIC!GAIN! Local! PA! Level! range! sufficient! to! drive! amplifiers! into!clipping!w/50!mV!nominal!input!level! 4.6.2! Jacks:! MIC! ! 10!k!ohms!input!impedance,!! 50!mV!nominal!input!level! External!Transceivers! External!Transceiver!Connectors!Pins!! Upper!and!Lower:!!!! RX!Audio!in,!300!mVpp!to!3!Vpp!! TX!Audio!out,!50!mVpp to!3!Vpp...
  • Page 22 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! Microcontroller!Reset Serial!Port!9!Upper! ! 8!Pin!Auxiliary!Serial!Port:! TX!Data!!!! RX!Data!!!! Ground!!! 5!volts!peak9to9peak!+/9!1!volt!input!! 5!volts!DC!+/9!.2!volts!250!mA!!! ! Ground!250!mA!maximum!sink! ! 4.6.3! Manual!Activation!Switches:! QTY!8,!activate!with!a!hold!time!>0.50!seconds! 4.6.4! Indicators:! RXD! ! Receive!Serial!Data!&!receipt!of!! ! radio!channel!modulation! TXD! ! Transmit!Serial!Data!&!DTMF!&!Digital! AUDIO!A! Audio!present!on!Channel!A! AUDIO!B! Audio!present!on!Channel!B!! ARM! ! Unit!Armed!indicator! Public!Address!mode!indicator! CPU! ! Microprocessor!Heartbeat! CARRIER! RF!Carrier!indicator!on!w/carrier!present! RECEIVE!LEVEL! ! 3!stage!LED!bar!graph! SPECIFICATIONS!
  • Page 23 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 4.6.5! Control!Unit!Connector!Configuration! Connectors!for!2005698M01!PCB! CONNECTOR!!! DESIGNATION!!!!!!!!!!!!!!!! PURPOSE!!!!!!!! Microphone!jack! k!!input!impedance,! 50!mV nominal!input!level. JP1! ! microSD!FLASH!card!holder! Slave!Select!Not! Master!Out!/!Slave!In! Switched!3.3V!power! Serial!Clock! Ground! Master!In!/!Slave!Out! JP4! ! Options!Connector:! microcontroller!Input! Ground! JP3! ! On9Board!Receiver!Module!Connector!Pins:!!!! Ground! +8!VDC! Clock! Data!!!! Latch!Enable! Carrier!Detect!Not! De9Emphasized!Receive!Audio! Flat!Receive!Audio! JP4! ! SINAD!Sensor!Input!Pins:! Ground! Sensor!Input! JP5! !
  • Page 24 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! JP7!! ! 600!Ohm!Output!Configuration!Jumper!Pins:! 192!! Output!siren!audio! 293! Output!radio!transmit!audio! JP8!! ! CTCSS!Connector!Pins:!!!! RX!Audio!in!! Ground!!!! 8!VDC!for!CTCSS!board!!! Audio!Switch!!!! TX!CTCSS!tone! JP9! ! Transceiver!#1!VOX!Jumper! Jumpered!to!use!VOX!for!Carrier!Detect! JP10! ! Dual!receiver!priority!jumper! Jumper!"EXT"!side!to!give!external!receiver!#1!priority! Jumper!"INT/EXT2"!side!to!give!on9board!receiver!or! !external!receiver!#2!priority.! Jumper!neither!side,!first!carrier!detect!has!priority! JP11! ! Jumpered!when!SINAD!option!is!used! JP12! ! Short!to!force!Carrier!Detect!of!External!transceiver!1! JP13! ! External!Transceiver!Connector!Pins!! Upper!and!Lower:!! RX!Audio!in! Receive!audio!level!for!300!m!V !to!3!! !to!make!1!V !at!TP16!
  • Page 25 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! P19Lower! 8!Pin!Serial!Port:! Digital!Receive!/!Serial!Port!Not! TX!Data!!!! RX!Data!!!! Ground!!! SCK!Microcontroller!Programming!Line!!! Microcontroller!Reset P19Upper! 8!Pin!Auxiliary!Serial!Port:! TX!Data! RX!Data! GND!!!! SPECIFICATIONS!
  • Page 26 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 4.7! Motherboard!(2005320)! JP1!–!Relay!Output!Control! 1!A,!30!VDC! 1!9!ground! 2!9!switched!10!9!15!Volts!! ! (Switches!on!when!a!function!is!active)! JP2!9!Switched!Radio!Power!Output! 10!A,!30!VDC! 1!9!ground! 2!9!switched!10!9!15!Volts! (Switches!on!when!control!board!is! operating!above!low!voltage!cutoff!point)! JP3!–!12VDC!Power!Input! 1!9!ground! 2!9!11!9!15!Volts! JP4!–!Audio!Signal!Output! 1!9!ground! 2!9!signal! Output!voltage!Swing!! >4.5!V!Peak!to!Peak! Maximum!Load! 2K!Ohms! Total!Harmonic!Distortion! ! <!10%!w/!1KHz!Sine9wave! JP5!–!Control!Board!Connection! JP6!–!Sensor!Inputs! 1.! GND! 2.! Activation!Detect!(SPR#1)! 3.! GND! 4.! Intrusion! 5.! GND! 6.! Solar! 7.! GND! 8.! AC!
  • Page 27 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! JP7!9!Audio!Channel!Select!Jumper! •! Jumper!pins!1!&!2!to!select!channel!A! •! Jumper!pins!2!&!3!to!select!channel!B! JP8!9!Charger!Sense!Input! 1!9!ground! 2!9!charger!input! Fuses! (F1)!Relay!Coil!at!JP1! ATO,!1!A,!32!VDC! (F2)!12!VDC!Radio!at!JP2! ATO,!10!A,!32!VDC! Figure!4.1!M!Motherboard!Outline!Drawing! SPECIFICATIONS!

  • Page 28: Environmental

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 4.8! Environmental! Operating!Temperature! 913°F!to!140°F!/!925°C!to!+60°C! Humidity! 0998%!non9condensing! Notes:! 1.! The!UVRI!can!operate!throughout!this!temperature!range!provided!the! battery!temperature!is!maintained!at!918°C!or!higher.! 2.! The!UVRI!housing!carries!a!NEMA!4X!/!UL50!rating! 4.9! Physical! Enclosure! 16"!x!15"!x!893/8"!(H!x!W!x!D)! 40.64!cm!x!38.1!cm!x!21.27!cm! Weight! 29.6!lb!/!13.43!kg!(including!battery)! SPECIFICATIONS!

  • Page 29: 5! Uvri!Operation

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 5! UVRI!OPERATION! 5.1! Hardware!General!Description All!relay!control,!audio!generation!and!remote!communication!functions!are!handled!by!a! single! microcontroller! board.! The! back9plane! (motherboard)! contains! connectors! and! terminal!blocks!for!interconnection!to!other!system!components.!! The! UVRI! receives! remote! control! signals! and! responds! to! the! Federal! Commander! remote! monitoring! system! to! provide! live! and! recorded! voice,! warning! tones,! and! a! remote!control!relay!contact!output.!The!UVRI!provides!a!contact!closure!to!activate!the! remote!system!and!provide!an!audio!output!at!JP4!on!the!motherboard.! Operation!is!supervised!and!status!information!is!transferred!back!to!the!control!station(s)!

  • Page 30: Local!Public!Address

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 5.3! Local!Public!Address! The!operator!has!the!ability!to!give!local!Public!Address!(PA)!messages!using!the!model! MNC9MC!microphone!provided.!PA!mode!can!be!entered!simply!by!pressing!the!push9 to9talk!(PTT)!button!on!the!MIC!while!the!MIC!is!plugged!into!the!¼"!receptacle!on!the! front!panel.!The!PA!LED!will!be!lit!anytime!the!PTT!button!on!the!microphone!is!pressed.! The!local!PA!volume!level!is!set!by!adjusting!the!MIC!GAIN!knob!located!directly!above! the!MIC!jack.! NOTE:!Local!PA!overrides!ALL!siren!functions!activated!either!remotely!or!locally.! 5.4! Relay!Output! A!DPDT!relay!output!is!located!in!a!socket!at!the!bottom!of!the!control!cabinet.!This!relay! closes!whenever!a!alert!tone,!digital!or!live!voice!message!is!active!and!can!be!used!to! trigger!remote!devices.!! 5.5! Sensor!Inputs! Terminal!block!JP6!on!the!motherboard!accepts!contact!closure!inputs.!These!inputs!are! activated!by!a!short!to!“Common”.! Sensor!Connections! JP15! Function! Terminal! “Common”! Remote!Activation! “Spare!#1”! “Common”! “Intrusion”! “Common”! “Solar”! “Common”! “AC!Power”! “Common”! “600!PTT”! “Common”! “Spare!#2”! UVRI!OPERATION!
  • Page 31 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 5.5.1! Intrusion! Alerts!the!controller!when!one!of!the!unit’s!doors!has!been!opened.!! 5.5.2! Solar:!Used!to!sense!operation!of!solar!power!system.! Jumper!JP15:!pins!5!to!6!and!to!enable!solar!sensing.!Solar!mode!latches!power! sense!to!prevent!low!light!conditions!from!causing!failures.!For!solar!panel!test,! initiate!a!reset,!and!then!a!poll.!Immediate!good!power!input!required!after!a!reset! to!pass.!! Jumper!JP15!pins!7!to!8!AC!sense!is!required!if!solar!only!unit.! 5.5.3! Spare#1! Remote!system!operation!detect.!Shorting!this!input!verifies!that!the!remote! system!is!active.! 5.5.4! Spare!#2! Unused!inputs!for!special!functions.! 5.5.5! AC!Power!!! ! Alerts!the!controller!when!the!AC!Power!has!failed.!Open!is!fail.!Closed!is!pass.! 5.5.6! 600!Ohm!PTT!!! Puts!the!unit!in!Local!PA!mode!for!input!of!external!audio.!Closed!is!active! 5.6! TwoMWay!Status!Monitoring!! The!UVRI!uses!a!variety!of!sensors!in!the!UVRI!Series!Controller,!which!when!equipped! with!a!two9way!radio,!allows!the!remote!unit!to!communicate!its!status!back!to!the!base! station.!This!reduces!station!downtime!by!quickly!alerting!operating!personnel!to!potential! problems!at!remote!units.!! The!following!status!points!are!monitored:! 1.! AC!Power!(AC!sense!relay)! 2.! Battery!Voltage!(built!in)! 3.! Charger!Operation!(built!in)! 5.! Signal!A!!(built!in)! 6.! Signal!B!!(built!in)! 7.! Remote!System!Operation!(Motherboard!JP691&2)!! 8.! Intrusion!!

  • Page 32: Quiet!Test

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 5.7! Quiet!Test! This!option!enables!acoustically!quiet!tests!to!be!performed!on!the!UVRI!control!and!the! remotely! controlled! devices.! Quiet! Test! uses! a! 20! kHz! tone! to! quietly! test! the! tone! generators!and!the!remote!amplifiers!(if!applicable).!To!perform!this!test!the!Quiet!Test! must!be!programmed!under!one!of!the!activation!codes.!If!it!is!one!of!the!first!7!codes! then! it! can! be! activated! manually! through! the! switches! on! the! front! panel! or! with! the! remote!activation!inputs.!Normally!once!the!Quiet!Test!is!programmed!under!one!of!the! activation!codes,!the!code!is!activated!over!the!radio!channel,!the!panel!switches,!or!with! a!local!laptop!computer!running!SFCDWARE.!! Operation! The!results!of!a!Quiet!Test!can!be!obtained!remotely!using!the!SS2000+!printout!or!the!

  • Page 33: 6! System!Planning

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 6! SYSTEM!PLANNING! 6.1! Control!Unit! Select!a!suitable!mounting!location!that!is!secure,!and!away!from!high!voltage!wiring!and! high!power!RF!systems.!The!Control!Unit!can!be!mounted!indoors!or!outdoors!depending! on!what!equipment!it!will!be!connected!to!as!long!as!the!unit!is!kept!within!the!operating! temperature!limits.! Refer! to! the! specification! section! to! obtain! the! weight! of! the! UVRI.! Insure! that! the! mounting!surface!and!fasteners!can!safely!sustain!the!weight!of!the!assembly.! In! order! to! reduce! the! possibility! of! introducing! noise! in! the! audio! path,! the! controller! should!be!placed!as!close!as!possible!to!the!Fire!Alarm!or!remote!PA!system.! The!controller!should!be!located!out!of!the!reach!of!vandals.!The!controller!is!supplied! with!padlock!hasps!that!will!accept!user!provided!padlocks!for!security.!

  • Page 34: 7! Installation

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 7! INSTALLATION WARNING! Read!all!Safety!Notices!at!the!beginning!of!this!manual!before!installation.! This!section!contains!reference!drawings!to!assist!with!installation.!A!list!of!typical! installation!materials!required!may!be!obtained!by!reviewing!the!cabinet!mounting! details!and!the!electrical!installation!material!list!below.! 7.1! UVRI!Controller!Installation!Reference!Drawings! Figure!7.1!M!Typical!UVRI!Installation!Drawing! INSTALLATION!
  • Page 35 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! Figure!7.2!M!UVRI!Cabinet!Dimensional!Outline!Drawing! INSTALLATION!
  • Page 36 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! Figure!7.3!M!UVRI!Wiring!Diagram! INSTALLATION!

  • Page 37: General!Mounting!Guidelines

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 7.2! General!Mounting!Guidelines! These! general! installation! instructions! are! pertinent! to! all! installations.! Specific! mounting! methods! and! required! installation! materials! are! described! in! the! next! section.! 1.! There!are!four!cabinet!mounting!flanges!available!for!bolting!the!UVRI!to!a!flat!surface,! (see!Figure'7.2).'! 2.! The!total!weight!of!the!UVRI!is!listed!in!the!specifications!section.!It!is!imperative!that! the!mounting!surface!and!mounting!method!selected!can!safely!sustain!the!weight!of! the!assembly.!! 3.! Prepare!the!mounting!surface!for!hanging!the!cabinet!by!predetermining!the!location! of!the!mounting!holes.!The!cabinet!should!be!attached!to!a!wall!or!other!substantial! vertical!surface!using!the!four!mounting!flanges.!Lag!bolt!the!cabinet!to!the!wall!using! the!prepared!holes!and!anchors.! 4.! If!the!UVRI!model!being!installed!has!a!29way!radio,!ensure!the!radio!antenna!cable! is!installed!before!applying!power!to!the!UVRI!to!avoid!damaging!the!radio.! 7.3! UVRI!Installation!Material!List!and!Installation!Guidelines! The!following!material!lists!and!guidelines!describe!basic!installation!details!required!
  • Page 38 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 7.3.1! Concrete!or!Filled!Cement!Block!Wall!Mounting!Guidelines:! 1.! Mark!the!mounting!hole!locations!on!the!wall!for!the!cabinet.! 2.! Install!the!anchor!bolts!for!the!four!cabinet!corners!according!to!the!manufacturer’s! instructions.! 3.! Mount!the!cabinet!to!the!wall.! 4.! Proceed!to!following!section.! Note:'If'wall'is'not'straight,'use'shims'to'insure'enclosure'maintains'square'and'structural' integrity.' Hollow!Block!Wall!Mounting!Materials! Material! Description! Purpose! Qty! ¼"!x!2"!Heavy!Duty! Anchor! !!4! Toggle!Bolts! Bolts! 7.3.2! Hollow!Block!Wall!Mounting!Guidelines:! 1.! Mark!the!mounting!hole!locations!on!the!wall!for!the!cabinet.! 2.! Install! the! anchor! bolts! for! the! four! cabinet! corners! according! to! the! manufacturer’s! instructions.! 3.! Mount!the!cabinet!to!the!wall.! 4.! Proceed!to!following!section.!
  • Page 39 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! Wood!Stud!Wall!Mounting! Materials! Material! Description! Purpose! Qty! ¼"!x!1"!Lag! Backboard!&! bolts! cabinet! mounting!bolts!! 2'!x!2'!x!¾"! Mounting! B/C!or!better! backboard! plywood! Construction! Mounting! adhesive!! backboard! attachment! 7.3.3! Wood!Stud!Wall!Mounting!Guidelines:! 1.! Locate!the!wall!studs!for!attaching!the!mounting!backboard!to!the!wall.!The!backboard! should!attach!to!at!least!two!studs.! 2.! Mark!the!wall!stud!location!on!the!mounting!backboard!and!drill!four!pilot!holes!for!the! lag!bolts.! 3.! Apply!construction!adhesive!to!the!back!of!the!mounting!backboard.! 4.! Attach!the!mounting!backboard!to!the!wall!with!four!lag!bolts.!! 5.! Locate!the!mounting!position!of!the!cabinet!on!the!mounting!backboard.! 6.! Drill!pilot!holes!for!the!lag!bolts.! 7.! Mount!the!cabinet!to!the!mounting!backboard.! 8.! Proceed!to!the!following!section.! INSTALLATION!
  • Page 40 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! Metal!Stud!Wall!Mounting!Materials! Material! Description! Purpose! Qty! ¼"!x!2"!lag!bolts! Cabinet! mounting! bolts!! 2'!x! ¾ "!x!2'!B/C!or! Mounting! backboard! better!plywood #14!x!2"!metal! Backboard! stud!screws! mounting! Construction! Backboard! adhesive!! mounting! 7.3.4! Metal!Stud!Wall!Mounting!Guidelines:! 1.! Locate!the!wall!studs!for!attaching!the!Mounting!Backboard!to!the!wall.!! 2.! Mark!the!wall!stud!location!on!the!mounting!backboard!and!drill!pilot!holes!for!the!#14! metal!stud!screws.!Three!screws!should!be!placed!in!each!stud!evenly!spaced!apart.! 3.! Apply!construction!adhesive!to!the!back!of!the!mounting!backboard.! 4.! Attach!the!mounting!backboard!to!the!wall!with!#14!metal!stud!screws.!! 5.! Locate!the!mounting!position!of!the!cabinet!on!the!mounting!backboard.! 6.! Drill!pilot!holes!for!the!¼"!lag!bolts.! 7.! Mount!the!cabinet!to!the!mounting!backboard.! 8.! Proceed!to!the!following!section.! INSTALLATION!

  • Page 41: Installer!Supplied!Uvri!Electrical!Installation!Material!List

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 7.4! Installer!Supplied!UVRI!Electrical!Installation!Material!List Material!Description! Purpose! Qty! 30!amp/250V/!2!Pole!Solid! Optional!Electrical!Disconnect! Neutral/Fused!Disconnect!w/! Ground!Kit/!NEMA!1!Rating/! Lockable!Cover!Tang/!Lockable! Operator! 10A!FRNR!Fuse! Fuses!For!120!V!Service! 5A!FRNR!Fuse! Fuses!For!240!V!Service! 12!9!14!AWG!White!Wire! AC!Neutral!from!disconnect! !8'! 12!9!14!AWG!Black!Wire! AC!Load!from!disconnect! !8'! 12!9!14!AWG!Green!Wire! Equipment!ground!from! !8'! disconnect! 1/2”!Seal!Tight!Conduit!&!Fittings! Electrical!conduit!from!disconnect! Varies! and!to!Fire!Panel/PA!System! Metal!Ground!Bushings! Equipment!ground!connections! Screws,!appropriate!to!mounting! Disconnect!mounting! surface! 15!A!Breaker! Service!panel!breaker!serving!unit! White!Wire!appropriately!sized! AC!neutral!from!breaker!panel!to! Varies! disconnect! Black!Wire!appropriately!sized!

  • Page 42: Electrical!Connections

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 7.5! Electrical!Connections! Make! all! electrical! connections! in! compliance! with! local! electrical! codes! and! NEC! recommendations.! Disconnect! all!power! and!read! all! warnings! at! the!beginning! of! this! manual!and!on!the!batteries!before!making!connections.! 7.5.1! Grounding!Requirements! 1.! The! UVRI! cabinet! must! be! properly! connected! to! an! earth! ground.! The! cabinet! contains!an!external!¼"!ground!stud!for!making!this!connection.!! 2.! Externally! installed! antennas! require! a! dedicated! ground! to! either! a! ground! rod! or! building!steel!below!grade!in!addition!to!the!UVRI!cabinet!ground.!
  • Page 43 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 7.5.4! 240!VAC!Electrical!Service!Wiring! 1.! Install!a!dedicated!29pole!15A!breaker!in!an!existing!breaker!panel!or!install!a!new! breaker!panel!if!necessary!for!the!UVRI.! 2.! Install!conduit!from!the!breaker!panel!to!a!conduit!entrance!in!the!bottom!of!the!UVRI.! Ensure!the!conduit!is!adequately!grounded.! 3.! Route!user9supplied!12914!AWG!wires!(2!black,!1!green!9!optional)!through!the!conduit! from! the! UVRI! Cabinet! and! the! fused! breaker! panel! (or! as! otherwise! specified! by! code).! 4.! Connect!one!line!wire!from!the!15A!breaker!panel!to!the!DIN!rail!mounted!terminal! block!labeled!L1!in!the!UVRI!control!cabinet.! 5.! Connect! the! other! line! wire! from! the! 15A! breaker! to! the! DIN! rail! mounted! terminal! block!labeled!L2!in!the!UVRI!control!cabinet.!! 6.! Connect!a!green!ground!wire!from!the!breaker!panel!earth!ground!to!the!green!ground! block!in!the!UVRI!cabinet!or!run!a!ground!lead!from!the!external!1/4”!ground!stud!on!

  • Page 44: Remote!System!Sense!Input

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 7.6! Remote!System!Sense!Input! Connect!the!remote!system!sense!contact!closure!to!the!UVRI!to!JP6!on!the!motherboard! as!shown!in!figure!7.5!below.!This!contact!is!used!by!the!UVRI!to!report!the!operational! status!of!the!remote!system! Remote!System!Sense!!!Audio!Output! ! !!!!!DC!Power! Figure!7.4!M!UVRI!Remote!System!Sense,!Audio!Output!and!DC!Power!Connections! 7.6.1! Relay!Output! The!relay!output!is!used!to!activate!the!remote!Fire!Alarm/PA!System!if!a!remote! contact!closure!input!is!available!in!the!remote!system.!The!relay!can!also!be!used!to! control!other!remote!devises!such!as!strobe!lights.!Two!sets!of!normally!open!and! normally!closed!contacts!are!available!as!shown!in!the!figure!below.! Figure!7.5!M!Relay!Output! INSTALLATION!

  • Page 45: Landline!Control!Connection

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 7.7! Landline!Control!Connection! If!the!UVRI9LL!wireline!control!option!is!used,!connect!the!telephone!wire!pair!from!the! TB9LL!base!line!driver!to!the!Landline!Interface!module!located!in!the!control!cabinet!on! top!of!the!control!board’s!protective!metal!cover.!Refer!to!the!Telco!Interconnect!System! manual!255377!for!further!installation!details. 7.8! Ethernet!Connection! If!the!UVRI9IP!Ethernet!control!option!is!used,!the!UVRI!Ethernet!module!will!be!located! in!the!control!cabinet!on!top!of!the!control!board’s!protective!metal!cover.!Make!the! Ethernet!connection!to!J1!on!the!UVRI!Ethernet!module.!Refer!to!the!Serial!to!Ethernet! User’s!Guide!part!number!2005457!for!further!connection!details.! The!UVRI!requires!an!IEEE!802.3,!10!Base9T,!half!duplex!connection!and!uses!ports! 16,887!(for!Codespear!TCP/IP)!and!port!80!(HTTP)!for!its!configuration!web!page.! Ethernet!wire!runs!must!be!less!than!328!feet!from!the!nearest!network!switch.! 7.9! Antenna!Types!! Determine!type!of!antenna!to!be!installed!if!a!wireless!RF!system!is!used:! 1.! Cabinet!Mounted!Magnetic!Base! 2.! Remote!Mounted!Magnetic!Base! 3.! Yagi!External!Antenna!Type!!! 4.! Omni!external!antenna!Type! For!installation!instructions!on!the!Yagi!and!Omni!Antennas!go!to!the!Federal!Signal’s! website.! 7.10! Remote!Mounted!Magnetic!Base!Antenna!Installation! A! remote! magnetic!base! antenna!may! be! installed! in! buildings! that! a! known! good! RF! signal!strength!inside!and!a!suitable!location!to!mount!the!antenna.!! 1.! Locate! a! suitable! location! for!the! antenna! that! is! away! from! any! electrical! devices,! high! voltage! and! computer! wiring.! The! location! should! be! as! high! as! possible! and!

  • Page 46: Visual!Inspection! 4

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 8! PREMOPERATION!CHECKOUT!AND!TEST! Warning! The!following!procedures!should!be!performed!by!a!properly!trained!technician!to! ensure!the!equipment!is!operating!properly.! 8.1! Visual!Inspection! 1.! Fill!out!the!Field!Test!Data!Sheet!at!the!end!of!this!section!to!document!the!following! inspections! and! tests.! The! completed! document! should! be! kept! on! file! for! future! reference.! 2.! Verify!all!connections!and!fasteners!are!tight.! 3.! Ensure!that!all!installation!debris!is!removed!from!the!cabinet.! 4.! Secure!all!wiring!with!wire9ties!to!provide!strain!relief!and!to!neatly!manage!the!wiring.! 5.! Verify!the!control!board!clock!LED!is!blinking.! 6.! Verify!the!power!supply!LED!is!on.! 8.2! PreMOperation!Checkout! 1.! Refer!to!Figure'7.4.!Measure!the!DC!voltage!across!the!DC!input!connector!on!the! control!board.!The!voltage!must!be!at!least!11.5!VDC!to!turn!on!the!control!board.! The!voltage!should!be!13.7VDC!when!AC!power!is!applied!to!the!UVRI.!! 2.! All!alert!signals!and!voice!messages!should!be!tested!at!this!time.!Verify!that!the! correct!audio!is!heard!at!the!proper!volume!for!each!function.!The!Audio!A,!Audio!

  • Page 47: Radio!Transceiver!Adjustment!Procedure! 4

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 8.3! Radio!Transceiver!Adjustment!Procedure!! Note:'This'procedure'previously'completed'at'factory.'Only'readjust'if'radio'reDalignment' is'required'or'if'the'radio'is'being'installed'in'the'field.' A.!Qualifications:! Requires!a!properly!trained!Radio!Technician.! B.!Equipment!Required:! 1.! Service!Monitor! 2.! Oscilloscope! C.!Setup:!! Connect!the!radio!to!the!service!monitor.! D.!Receive!Audio!Adjustment! 1.!Using!service!monitor,!modulate!the!correct!RF!signal!into!the!receiver!with!a!1!kHz! tone!at!3!kHz!deviation.!If!bandwidth!is!12.5,!then!modulate!at!1.5!kHz!deviation.!(If!using! private!line,!add!0.75!kHz!private!line!deviation!to!the!signal.)! 2.! Adjust! the! level! at! TP16! (2005698! controller! card)! for! 1V ! using! the! REC! gain! adjustment!R105!(2005698!controller!card!front!panel).! E.!Transmit!Deviation!Adjustment! 1.! Simultaneously!press!buttons!5!&!7!on!the!2005698!controller!card.!This!will!cause! the!controller!to!transmit!for!approximately!8!seconds.! 2.! Measure!the!deviation!level!using!service!monitor.!! 3.! Adjust! the! TX! level! (2005698! controller! card!front! panel)!for!3! kHz! deviation.! If! the! bandwidth!is!12.5!kHz,!then!adjust!for!1.5!kHz!deviation!(If!using!private!line,!add!0.75!

  • Page 48: Control!And!Status!Monitoring! 4

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 8.4! Control!and!Status!Monitoring! 1.! Use! The! Commander! Digital! System! (SFCDWARE)! to! verify! the! UVRI! has! been! properly! configured! for! the! application.!Make! any!required! changes! prior! to! placing! the!UVRI!into!service.! 2.! The!control!and!status!monitoring!features!should!be!tested!from!each!control!point.! Test!each!control!function!and!all!status!indications!using!SFCDWARE.!Verify!each! status!point!provides!the!proper!indication!of!both!pass!and!fail!conditions.! PRE9OPERATION!CHECK9OUT!AND!TEST!
  • Page 49 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! UVRI!Field!Test!Data!! Customer:!! ! ! ! ! Project!Number:!! ! ! ! ! Date:!! ! ! ! ! Contact!Person:!! ! ! ! ! Phone:!! ! ! ! ! Second!Phone:!! ! ! ! ! Radio!Shop:!! ! ! ! ! Contact:!! ! ! ! ! Phone:!! ! ! ! ! Siren!Type:!! ! ! ! ! S/N:!! ! ! ! !

  • Page 50: Maintenance! 5

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 9! MAINTENANCE!! WARNING! Service! and! maintenance! should! be! performed! by!qualified! personnel!familiar! with! the! UVRI,! associated! controls,!and! power! sources! being! used! and! in! conjunction! with! the! authorities!having!jurisdiction.! The! sound! output!of! speakers! is! capable! of!causing! permanent! hearing! damage.! Use! adequate!hearing!protection!and!avoid!excessive!exposure.! If!you!are!experiencing!any!difficulties,!contact!Federal!Signal!Customer!Care!at:!! 800954897229!or!708953493400!extension!5822!or!Technical!Support!at:!800952493021! or!708953493400!extension!7329!or!through!e9mail!at:!techsupport@fedsig.com.!For!
  • Page 51 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! GENERAL!MAINENANCE! 9.1.1! Signal!Operational!Check! 1.! Activate!each!of!the!signals!from!the!control!point!and!observe!the!signal!indicators! on! the! control! module! and! the!remote! PA! system.! Verify! each! function! sounds! the! correct!signal!at!the!proper!volume!level!for!the!application.!! 2.! Verify! that! the! system! status! is! reported! correctly! at! the! control! point.! Check! each! status!point!to!verify!both!pass!and!fail!conditions!are!correctly!reported.!Verify!that! the!relay!output!closes!with!each!function!activated.! 9.1.2! Battery!Inspection!! 1.! Remove!AC!power!and!measure!the!DC!voltage!across!the!DC!input!connector!on! the!control!board.!This!voltage!should!be!above!12.75!VDC!if!the!battery!has!been! charging!for!at!least!24!hours.!
  • Page 52 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! Figure!9.1!M!UVRI!Motherboard!Connections! Figure!9.2!M!UVRI!Battery!Location!and!Cover!Plate!Mounting!Screws MAINTENANCE!

  • Page 53: Troubleshooting! 5

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 9.2! Troubleshooting! PROBLEM! ACTION! NO!RADIO!DECODE! A.!Unit!is!not!programmed!to!recognize!that! particular!code!sequence!(or)!Signal!is!not! being!received!properly.! B.!Verify!programming!is!correct.!Check!the! received!audio!signal!quality!at!the!RX!test! pin!on!the!front!of!the!control!board.! LOW!OUTPUT!FROM! Check!battery!voltage.!Also,!check!signal! SPEAKERS! indicators!on!amplifiers!during!a!function.!If! indicators!are!off,!remove!amplifier!for! service.! FUNCTION!STOPS!BEFORE! Batteries!may!require!further!charging.! NORMAL!TIME9OUT! Check!battery!voltage!under!load.!Check! charger!output.! LOCAL!P.A.!FEEDS!BACK! Lower!P.A.!volume!using!knob!above!MIC! connector.! LOCAL!P.A.!HAS!LITTLE!OR!NO! Hold!MIC!close!to!mouth.!Increase!PA! OUTPUT! volume!using!knob!above!MIC!connector.! BATTERIES!NOT!HOLDING! Check!that!charger!fuses!are!intact!and!!! CHARGE! check!charger!output.! Load!!!Test!batteries.! RELAY!OUTPUT!ON! Check!that!the!relay!on!the!system! MOTHERBOARD!DOESN’T! motherboard!is!operating!(indicated!by!LED! OPERATE! D2).!Also!check!fuse!F1!on!motherboard!(20! amp!slo9blow)!

  • Page 54: Options! 5

    Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! 10! OPTIONS!! 10.1! Radio!Control! The!UVRI!can!be!activated!by!a!radio!signal!when!the!optional!radio!transceiver!is! incorporated!into!the!Control!Unit.!Activation!by!radio!control!has!the!advantage!that! control!lines!are!not!required!between!the!control!site!and!the!UVRI.!Federal!Signal! offers!the!controller!with!a!full!line!of!transceivers!built!in!which!cover!the!VHF!and! UHF!bands.! 10.2! Digital!Voice!Recording! Four!minutes! of! digital! voice! storage! is! provided! as! a! standard! feature! with! the! UVRI.! When! the! Digital! Voice! Recording! option! (model! DVR)! is! purchased,! the! UVRI! will! be! factory! programmed! with! high! quality! voice! or! music! recordings! as! specified! by! the! customer.! Up! to! 250! individual! messages! may! be! programmed! into! the! UVRI.! Digital! Voice!
  • Page 55 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! RADIO!Connector,!8!pin!MOD!jackb! 1.!Receive!Audio,!300mV!9!10V 2.!Transmit!Audio,!50mV!9!3V 3.!Carrier!Detect!9!active!low! 4.!PTT! 5.!+8!VDC! 6.!GND! 7.!+8!VDC! 8.!GND! This! voltage! source! must! not! be! used! for! radios,! which! draw! more! than! 1.5! Amps! of! current!in!transmit.!Use!both!grounds!and!both!+8!VDC!connections!for!current!handling.! If! a! higher! current! output! is! required,! a! 24! VDC! –! 12! VDC! voltage! converter! must! be! purchased.!This!converter!is!provided!with!the!UVRI!series!models.!Do!not!use!one!of! the!12!VDC!batteries!to!run!the!radio!equipment.! 1.! AUDIO!–!The!ULTRAVOICE!controller!Receive!Audio!Input!should!be!connected!to!
  • Page 56 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! Ethernet! port! to! the! server’s! IP! address.! The! unit! also! contains! a! digital! to! analog! converter.! This! allows! specially! configured! incoming! data! packets! to! be! converted! to! audio,!which!is!then!filtered!and!sent!out!over!a!600!ohm!audio!port.! A.!Ethernet!Board!Specifications! Electrical! 10.4.1!! Input!Voltage!! 10.5!–!95!VDC! Current!Draw! <150!mA! Serial!Port! Serial!Port!Protocol! !!RS232C,!N,!8,!1! !!!!! !!baud!rate!! !!configurable!
  • Page 57 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! JP4! RS232!Serial!Port! !1!9! !2!9! 3!9!Ground,!0.5!amps!maximum!current!capacity! 4!9!Radio!transmit!data!from!! PC,!standard!RS232!levels! 5!9!Radio!receive!data!to!PC!standard!RS232!levels! 6!9!Ground,!0.5!amps!maximum!current!capacity! JP5! FLASH!Programming!and!Converter!Configuration!Port! !1!9! 2!9!TX!Data,!standard!RS232!levels! 3!9!RX!Data,!standard!RS232!levels! 4!9!Ground! 5!9!Serial!Clock!input!for!FLASH!programming,!standard!RS232!levels! 6!9!Processor!Reset!Not!line,!used!in!programming!FLASH,!10K!pull9up! JP6! 10.5M95!VDC!Power!Input! !1!9!(9)! !2!9!(+)! JP7! Resets!board!back!to!factory!default!settings.! Ethernet!Network!Port! 1!&!2!9!Transmit!data!pair,!balanced!line!3!&!6!9!Receive!data!pair,!! balanced!line! 4,!5,!7,!8!9!AC!coupled!ground! Indicators! D1!9!CPU!Heartbeat!indicator,!green! D2!9!Transmit!data!indicator,!red! D3!9!Receive!data!indicator,!yellow! D4!9!Power!indicator,!green! Controls! R1!–!600!ohm!audio!output!level!set! Environmental! Operating!Temp.! 930!°C!9!+65!°C! Humidity! 09!95%!non9condensing! OPTIONS! ! 57!
  • Page 58 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! Physical! Dimensions! about!(H!x!W!x!L)!2"!x!4”!x!6.5"! Weight! <!2!lb!! Serial'to'Ethernet'Board' B.!Network!Information! Protocols!Supported! •! TCP/IP! •! UDP!(optional)! •! XML!(optional)! •! XMPP!(optional)! IP!Ports!Used! 16,887!(Codespear!TCP/IP)! 80!(HTTP)! 3100!(optional!UDP!Serial!Over!IP)! 3101!(optional!UDP!Voice!Over!IP)! IP!Address! User!selectable! OPTIONS! ! 58!
  • Page 59 Federal!Signal!UltraVoice!Remote!Interface!(UVRI)! Installation,!Operation,!and!Service!Manual! TOS/DSCP!(Type!of!Service)! User!selectable!priority!level! Bandwidth!Requirements! Voice!Over!IP:!!150K!baud!per!Connection! Siren!Activation:!!!50!bytes!per!connection! Siren!Poll!Response:!!74!bytes!per!connection! OPTIONS! ! 59!
  • Page 60 2645 FEDERAL SIGNAL DRIVE - UNIVERSITY PARK,IL 60466 FINISH: UVRI-LL 2005548 PCB,LAND LINE MATERIAL DESCRIBED AND INFORMATION CONVEYED IS PROPRIETARY TO FEDERAL SIGNAL CORPORATION, IS OR MAY BE THE SUBJECT OF PATENT APPLICATIONS, AND SECTION UVRI-IP 2005457 PCB,SERIAL ETHERNET 2/23/18...

This manual is also suitable for:

Uvri

Table of Contents