E-Z-GO FLEET 1999 Technician's Repair And Service Manual page 175

(5) Miscellaneous Items Used in Above Systems
(i) Fuel hoses, clamps and sealing gaskets
I. MAINTENANCE STATEMENTS
It is your responsibility to have all scheduled inspection and maintenance services performed at the times
recommended in the 1995 and later Owner's Manual and to retain proof that inspection and maintenance
services are performed at the times when recommended. FUJI will not deny a warranty claim solely be­
cause you have no record of maintenance; however, FUJI may deny a warranty claim if your failure to per­
form required maintenance resulted in the failure of warranted part. The proof which you maintain should
be given to each subsequent owner of the engine. You are responsible for performing the scheduled main­
tenance described below based on the procedures specified in the 1995 and later Owner's Manual. The
scheduled maintenance below is based on the normal engine operating schedule.
a) Check for sealing of fuel cap and proper operation of
fuel gauge (at each fueling). Check that fuel cap vent is
free of dirt.
b) Check engine for unusual noise, vibration acceleration.
c) Check engine electrical system for coil/spark plug wire
for cracks/loose connections.
d) Check fuel system for leaks at tank cap, lines, filters,
pump, carburetor. Check lines for cracks/deterioration.
e) Check air cleaner filter element.
f) Replace engine oil, DO NOT OVERFILL.
g) SAE 1 0W-30/1 0W-40 SF,SG,CC oil.
h) Clean oil filter in solvent (at oil change).
Replace O-rings if required.
i) Replace air cleaner filter element if required.
Check fuel filter for dirt build up. (Replace as required)
j)
k) Check the spark plugs for gap 0.030. (Replace if
required)
I) Check timing belt tension, signs of wear/damage.
Replace only if worn or damaged.
PROCEDURE
Repair and Service Manual
LIMITED WARRANTY
INTERVAL
WEEKLY
MONTH (20 HOURS)
3 MONTH (50 HOURS)
3 MONTH (50 HOURS)
SEMIANNUAL (125 HOURS)
SEMIANNUAL (125-150 HOURS)
SEMIANNUAL (125-150 HOURS)
ANNUAL (250-300 HOURS)
ANNUAL (250-300 HOURS)
ANNUAL (250-300 HOURS)
ANNUAL (250-300 HOURS)
Page S-5