Page 1
Undercounter Ice and Water Dispenser with Chewblet Ice Icemaker ® 7UC100A, 7UD100A Installation, Operation and Service Manual Serial numbers before D17618 7UC100A 7UD100A Following installation, please forward this manual to the appropriate operations person. 801 Church Lane • Easton, PA 18040, USA Order parts online: Toll free (877) 612-5086 •...
After uncrating and removing all packing material, inspect the equipment for concealed shipping damage . If damage is found, immediately notify the shipper and contact Follett Corporation so that we can help in the filing of a claim, if necessary .
31 .50" (800 mm) Unit Shipping Weight 110 lb (50 kg) 110 lb (50 kg) Ambient Information CAUTION! The 7UC100A and 7UD100A are for indoor use only. Maximum Minimum Air Temperature* 100 F (38 C) 50 F (10 C) Water Temperature 90 F (32 .2 C)
14.55 " dispenser for the electrical and optional drain connection . (369.6 mm) 33.50 " (850.9 mm) 18.15 " (461 mm) 7UC100A 14.55 " (369.6 mm) 31.50 " (800.1 mm) 18.15 " (461 mm) 7UD100A Undercounter Dispenser and Icemaker 7UC100A/7UD100A...
Page 7
. Do not attach the bracket to the dispenser . 5 . Connect the water line . Connect power supply . 6 . Sanitize the dispenser prior to use (see Cleaning and Sanitizing on page 10) . 18.15” (461 mm) Undercounter Dispenser and Icemaker 7UC100A/7UD100A...
5 . Remove and set aside the front panel (Fig . 5 .4) - do not disengage the plug on the back of the User Interface or the tubing at the water dispenser chute (if so equipped) . Undercounter Dispenser and Icemaker 7UC100A/7UD100A...
Filter Display Indicator Activation ––––––––––––––––––––––––––––––––––––– If you purchased your dispenser with a Follett filter, the filter display indicator Fig . 6 activation has been preset at the factory . If you are using an “after market filter,” an adjustment may be made to activate the “Fresh Filtered Ice &...
Caution: Some sanitizing solution will remain and drain out when cap is removed . Reposition cap on bin lid spout . 8 . Reinstall front panel, ice dispense chute, and drip tray . 9 . Press and hold maintenance/clean switch to exit Maintenance Mode . * Calgon is a licensed trade name . Undercounter Dispenser and Icemaker 7UC100A/7UD100A...
Internal leak in dispenser . High amps Auger gearmotor has exceeded 0 .55 amps . Service 8000 hour bushing check (call Follett technical service group at (877) 612-5086 or +1 (610) 252-7301) . Maintenance Yellow Enter Maintenance Mode by pressing and holding maintenance/clean switch for 5 seconds .
Service –––––––––––––––––––––––––––––––––––––––––––––––––––– (continued) Water Feed Schematic Evaporator Float Water Chute (optional) Water Solenoid Valve Filter (optional) (optional) Water Solenoid Valve Undercounter Dispenser and Icemaker 7UC100A/7UD100A...
Service –––––––––––––––––––––––––––––––––––––––––––––––––––– (continued) Bin Melt Water/Evaporator Feed/Clean Out System Schematic Storage Bin Vent System Schematic Storage Bin Vent Tube Reservoir Undercounter Dispenser and Icemaker 7UC100A/7UD100A...
Service –––––––––––––––––––––––––––––––––––––––––––––––––––– (continued) Condenser Fan Motor Removal Undercounter Dispenser and Icemaker 7UC100A/7UD100A...
Press and hold for 5 seconds until displays . Press and release clean switch to display “FRESH FILTERED ICE” . Press and hold clean switch for 5 seconds to reset your selection . Undercounter Dispenser and Icemaker 7UC100A/7UD100A...
Page 17
–––––––––––––––––––––––––––––––––––––––––––––––––––– (continued) Service Display Condition Procedure High amps Contact Follett Technical Service . Internal leak in dispenser Locate leak and repair - Press reset on control board . Contact Follett if icemaker is leaking . Undercounter Dispenser and Icemaker 7UC100A/7UD100A...
Parts –––––––––––––––––––––––––––––––––––––––––––––––––––––– (continued) Evaporator Assembly Undercounter Dispenser and Icemaker 7UC100A/7UD100A...
Page 25
00957878 Housing, Bushing with Insulation 00957886 Hardware kit, Gearmotor 00957894 Reservoir and Float Complete Assembly 00957902 Lid, Reservoir with Insulation and O-Ring 00957910 Float Valve 00957928 “T” Fitting - 1/4" 502923 Tubing - 1/4" 502079 Undercounter Dispenser and Icemaker 7UC100A/7UD100A...
Page 26
Undercounter Dispenser and Icemaker 7UC100A/7UD100A...
Page 27
Undercounter Dispenser and Icemaker 7UC100A/7UD100A...
Page 28
SafeCLEAN and SensorSAFE are trademarks of Follett Corporation. Chewblet and Follett are registered trademarks, and Horizon is a trademark of Follett Corporation, registered in US. 801 Church Lane • Easton, PA 18040, USA 00966879R01 Toll free (877) 612-5086 • +1 (610) 252-7301 02/11 www.follettice.com...