Table of Contents
Advertisement
Document Type: Service Manual
Version 1.1 12192017
SERVICE MANUAL
15" Built-In Kegerator
MODEL:
BR1500SS, BR1500SSOD, BR1500BL
CAUTION: READ ALL SAFETY PRECAUTIONS IN THIS
MANUAL BEFORE SERVICING THE UNIT
EdgeStar, 8606 Wall St, Suite 1800, Austin, TX 78754
support.edgestar.com • service@edgestar.com • edgestar.com
*Warranty service should be performed by an authorized service representative only.
Advertisement
Table of Contents
Related Manuals for EdgeStar BR1500SSOD
Summary of Contents for EdgeStar BR1500SSOD
- Page 1 BR1500SS, BR1500SSOD, BR1500BL CAUTION: READ ALL SAFETY PRECAUTIONS IN THIS MANUAL BEFORE SERVICING THE UNIT EdgeStar, 8606 Wall St, Suite 1800, Austin, TX 78754 support.edgestar.com • service@edgestar.com • edgestar.com *Warranty service should be performed by an authorized service representative only.
-
Page 2: Table Of Contents
CONTENTS SAFETY PRECAUTIONS ................................2 PARTS IDENTIFICATION ................................3 DISASSEMBLY..................................4-7 DOOR .....................................4 LAMP………… ..................................4 DISPLAY BOARD& CONTROL BOARD & CONTROL BOARD...................4-5 POWER BOARD & TRANSFORMER ............................. 5 SENSOR & FAN..................................6- COMPRESSOR PTC STARTER & OVERLOAD PROTECTOR..........…………………………….…….6-7 TROUBLESHOOTING................................7-10 COMPRESSOR COMPONENTS ............................7 ANOTHER ELECTRIC COMPONENT ..........................8 SERVICE DIAGNOSIS CHART.............................9 REFRIGERATING CYCLE ..............................10 DESCRIPTION OF PCB ................................11... -
Page 3: Parts Identification
2. PARTS IDENTIFICATION Model：BR1500SS，BR1500SS0D，BR1500BL Front View - 3 -... -
Page 4: Disassembly
3. DISASSEMBLY 3-1 DOOR Pull out the LED light. The LED light is like below. (Models：BR1500SS，BR1500SS0D，BR1500BL ) (figure 5) Loosen 2 bolts fixing the lower door axis to the lower hinge to remove the door. (Figure 1) Figure 5 Lower Door 3-3 DISPLAY BOARD &... -
Page 5: Power Board & Transformer
3. DISASSEMBLY Pull out the display board assembly (figure 9) Figure 9 Disassemble the display board。 (figure 10) 2． Loosen three screws. (figure 13) Figure 10 Figure 13 The control board is like below. (figure 11) 3. The power board & transformer are like below. (figure 14) Figure 11 3-4 POWER BOARD &... -
Page 6: Sensor & Fan
3. DISASSEMBLY 3-5 SENSOR & FAN Loosen 1 screw. You can replace the sensor & fan.(figure (Models：BR1500SS，BR1500SS0D，BR1500BL) wire housing Loosen screws. (figure 1 5 ) screw screw evaporator defrost sensor Figure 17 3-6 COMPRESSOR PTC STARTER & OVERLOAD PROTECTOR (Models：BR1500SS，BR1500SS0D，BR1500BL) Figure 15 1. -
Page 7: Troubleshooting
3. DISASSEMBLY 3. The compressor PTC starter and overload protector is like below. (figure 20) Figure 20 4-1 COMPRESSOR COMPONENTS Check the Check the resistance resistance of among M-C, S-C and Motor M-S in Motor Replace Compressor. Compressor. Compressor. Is it normal? Check the resistance Check the of two terminals in... -
Page 8: Another Electric Component
4. TROUBLESHOOTING 4-2 ANOTHER ELECTRIC COMPONENTS ▼ Cooling is impossible Compressor doesn't run. Check if current flows to the Cause. following components. a. Starting devices Shorted or broken. Poor contacting b. OLP or shorted. c. Compressor coil Coil shorted. Replace Poor contacting d. -
Page 9: Service Diagnosis Chart
4. TROUBLESHOOTING 4-3 SERVICE DIAGNOSIS CHART Problem Possible Cause Appliance does not operate. Not plugged in. The appliance is turned off. The circuit breaker tripped or a blown fuse. Appliance is not cold enough. Check the temperature control setting. External environment may require a higher setting. -
Page 10: Refrigerating Cycle
4. TROUBLESHOOTING 4-4 REFRIGERATING CYCLE ▼ Troubleshooting Chart CAUSE STATE OF UNIT STATE OF EVAPORATOR TEMPERATURE COMMENTS OF COMPRESSOR • A little refrigerant discharges Appliance does PAR TIAL Low owing sound of A little high - • Normal cooling is possible when not get cold LEAKAGE Refrigerant is heard and... -
Page 11: Description Of Pcb
5. DESCRIPTION OF PCB (Models：BR1500SS，BR1500SS0D，BR1500BL) - 11 -... - Page 12 DATE REVISION NOTES: 11/14/2017 Initial Document 12/19/2017 Formatting edits EdgeStar, 8606 Wall St, Suite 1800, Austin, TX 78754 support.edgestar.com • service@edgestar.com • edgestar.com *Warranty service should be performed by an authorized service representative only.
Need help?
Do you have a question about the BR1500SSOD and is the answer not in the manual?
Questions and answers