Page 1
FP430, FP630, FP861 CAUTION: READ ALL SAFETY PRECAUTIONS IN THIS MANUAL BEFORE SERVICING THE UNIT EdgeStar, 8606 Wall St, Suite 1800, Austin, TX 78754 support.edgestarFRP VHUYLFH#HGJHVWDr.com HGJHVWDUFRP *Warranty service should be performed by an authorized service representative only.
Always check line voltage and amperage. Always use exact replacement parts. Any attempt to repair a major appliance may result in personal injury and property damage. 1. Specifications Model FP430 FP630 FP861 Voltage / AC: 115V~60 Hz AC: 115V~60 Hz AC: 115V~60 Hz...
Page 3
2. Connection Note: Fuse is located within the DC plug connector. NOTE: Due to the difficulty in replacing a faulty temperature probe this unit comes pre-installed with two (2) probes. If a faulty temperature probe is suspected simply connect the unused probe in place of the faulty probe.
Page 4
4. Unit Not Cooling Troubleshooting Flow TROUBLESHOOTING TIPS AND NOTES: - Use of a multi-meter / voltage reader is recommended for proper diagnosis. Determining the point at which power is not properly passing into or through a component is the best method for determining component failure. If the unit does not appear to be receiving power: - Ensure that the power source is providing the proper voltage to the unit.
Page 5
5. Disassembly for Temperature controller 3.Remove screws(2) from the cabinet 4.Remove screws(2) from the box 5.Pull out the wire connector as the picture 6.Replace the new one...
Page 6
7. Cooling System Brief Description of System Flow Chart The refrigerant flows in the sequence: Compressor>Condenser>Filter>capillary Tube>Evaporator>compressor 1.Compressor 2.Control unit / Compressor Control Box 3.Power Supply 4.DC connector 5.AC connector 6.Condenser 7.Condenser fan...
Page 7
8. Power Supply and Compressor control 1.Remove screws(2) from the cabinet 2.Remove the grill 3.Remove screws(4) from the plate 4.Remove the power supply 5.Pull out the wire connector as the piceure...
Page 8
6.Remove the screw as the picture 7.Pull out it control...
DATE REVISION NOTES: 10/07/17 Initial Document - V1.0 10/16/2017 Text and Title Edits - V1.1 EdgeStar, 8606 Wall St, Suite 1800, Austin, TX 78754 support.edgestarFRP VHUYLFH#HGJHVWDr.com HGJHVWDUFRP *Warranty service should be performed by an authorized service representative only.