Sony KD-32DX150U Service Manual
  1. Manuals
  2. Brands
  3. Sony Manuals
  4. TV
  5. KD-32DX150U
  6. Service manual
Sony KD-32DX150U Service Manual

Sony KD-32DX150U Service Manual

Trinitron color tv
Hide thumbs Also See for KD-32DX150U:
Table of Contents

Advertisement

Quick Links

See also: Instruction Manual

SERVICE MANUAL

MODEL
KD-32DX150U
COMMANDER
DEST
CHASSIS NO.
RM-933
UK
SCC-Q84P-A
KD-32DX150U
- 1 -
AE-6D
CHASSIS
RM-933

Advertisement

Table of Contents
loading

Related Manuals for Sony KD-32DX150U

Summary of Contents for Sony KD-32DX150U

  • Page 1: Service Manual

    SERVICE MANUAL AE-6D CHASSIS MODEL COMMANDER DEST CHASSIS NO. KD-32DX150U RM-933 SCC-Q84P-A KD-32DX150U RM-933 - 1 -...

  • Page 2: Table Of Contents

    NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN TANCE CRITIQUE POUR LA SÈCURITÈ DU FONCTIONNEMENT, SUPPLEMENTS PUBLISHED BY SONY. NE LES REMPLACER QUE PAR DES COMPSANTS SONY DONT LE NUMÈRO DE PIÈCE EST INDIQUÈ DANS LE PRÈSENT MANUEL OU DANS DES SUPPLÈMENTS PUBLIÈS PAR SONY.

  • Page 3: Caution

    Due to the higher melting point of Lead Free Solder the soldering iron tip temperature needs to be set to 370 degrees centigrade. This requires soldering equipment capable of accurate temperature control coupled with a good heat recovery characteristics. For more information on the use of Lead Free Solder, please refer to http://www.sony-training.com - 3 -...
  • Page 4 l l a . s l . s l . s l . s l . s l . s l e i l i n i WARNING (UK Models only) The flexible mains lead is supplied connected to a B.S. 1363 fused plug having a fuse of 5 AMP rating.

  • Page 5: Connectors

    21 pin connector Pin No Signal Signal level Audio output B Standard level : 0.5V rms (right) Output impedence : Less than 1kohm* Audio input B Standard level : 0.5V rms (right) Output impedence : More than 10kohm* Audio output A Standard level : 0.5V rms (left) Output impedence : Less than 1kohm*...

  • Page 6: Self Diagnostic Software

    AE-6D SELF DIAGNOSTIC SOFTWARE The identification of errors within the AE-6D chassis is triggered in one of two ways :- 1: Busy or 2: Device failure to respond to IIC. In the event of one of these situations arising the software will first try to release the bus if busy (Failure to do so will report with a continuous flashing LED) and then communicate with each device in turn to establish if a device is faulty.
  • Page 7 Error Detection Monitor Device acknowledge is used to check IIC errors. Device acknowledge is checked by sending an IIC start sequence during CRT power on. Each device is checked three times, if there is no acknowledge after each attempt, it will be regarded as an error. There are three steps to check for errors.
  • Page 8 2. Error Reader Display The error reader display is connected to the service connector to read actual error codes. The part number for the error reader display is S-188-900-10. Once an error has been detected it will then be displayed on the two digit error reader. The errors displayed refer to the following table.

  • Page 9: General

    SECTION 1 GENERAL - 9 -...
  • Page 10 - 10 -...
  • Page 11 - 11 -...
  • Page 12 - 12 -...
  • Page 13 - 13 -...
  • Page 14 - 14 -...
  • Page 15 - 15 -...

  • Page 16: Disassembly

    SECTION 2 DISASSEMBLY 2-1. Rear Cover Removal 2-2. Front Control Module Removal => Screws = > = > => => Remove the rear cover fixing screws indicated and pull the Remove the two screws fixing the user control module to the rear cover backwards.

  • Page 17: G1 Board Removal

    2-4. G1 Board Removal 2-5. G Board Removal Screw Clips Clips Clips To remove the G Board first remove the G1 bracket by removing the screw circled and releasing the four clips (two To remove the G1 board release the three clips circled and on each side of the bracket).

  • Page 18: Service Position

    2-8. Service Position 2-9. Wire Dressing 1 To place the chassis in the service position, remove the G1 and D2 brackets and position on the side of the main bracket as shown above. Insert the main bracket firmly into the T-slot located on the left corner of the beznet as indicated (see inset).

  • Page 19: Picture Tube Removal

    2-12. Picture Tube Removal WARNING: BEFORE REMOVING THE ANODE CAP High voltage remains in the CRT even after the power is disconnected. To avoid electric shock, discharge CRT before attempting to remove the anode cap. Short between anode and CRT coated earth ground strap.
  • Page 20 - 20 -...

  • Page 21: Set-Up Adjustments

    SECTION 3 SET-UP ADJUSTMENTS • When complete readjustment is necessary or a new picture tube Carry out the adjustments in the following order : is installed, carry out the following adjustments. 3-1. Beam Landing and Geometry. • Unless there are specific instructions to the contrary, carry out 3-2.

  • Page 22: Convergence

    Fig.3-4 Align both Purity Purity magnets Purity control magnets magnets to the vertical position Align pips on each magnet 3-2. Convergence (1) Screen centre convergence [Static convergence] Input a dot pattern signal from the pattern generator. GREEN Normalize the picture setting. [Moving vertically], adjust the V.STAT magnet so that the BLUE vertical red, green and blue dots coincide at the centre of the...
  • Page 23 Correction for HMC [Horizontal mis-convergence] and VMC HTIL correction can be performed by adding a THL correction [Vertical mis-convergence] by using the BMC [Hexapole] assembly to the Deflection yoke. magnet. a). HMC correction by BMC [Hexapole] magnet and movement of the electron beam.

  • Page 24: Focus Adjustment

    Layout of each control 3-3. Focus Adjustment Receive a cross hatch pattern from a video generator. Adjust the focus control located on the flyback transformer to the best level at the centre of the screen. Purity magnet Check left and right x-axis vertical line thickness and adjust to BMC (Hexaploe) magnet V STAT convergence magnet make them as thin as possible.

  • Page 25: Circuit Adjustments

    SECTION 4 CIRCUIT ADJUSTMENTS Initialising Menu 4-1. Electrical Adjustments Service adjustments to this model can be performed using the supplied remote Commander RM-933. s i l Programming the Remote Commander for Operation in Service Mode Press the VCR/TV/DVD button until the TV LED lights.
  • Page 26 Basic Setting t l i f a l i a l i a l i a l i Table.4-2 Feature Setting Table.4-5 Table.4-3 Device Register Setting c t i l r t l r t Table.4-4 Table.4-6 - 26 -...
  • Page 27 Table.4-7 Table.4-8 - 27 -...
  • Page 28 Table.4-9 t l i . f f Table.4-10 . f f . f f . f f l v l " 6 Table.4-11 Table.4-12 - 28 -...

  • Page 29: Volume Electrical Adjustments

    4-2. Volume Electrical Adjustments Deflection System Adjustment Enter into the service mode and select ‘Deflection’ from the Sub Colour Adjustment menu. The ‘Deflection’ adjustment menu will be displayed. Select and adjust each item to obtain the optimum image. Input a PAL colour bar signal. Connect an oscilloscope to CN9001 pin 5 located on the C1 Board.

  • Page 30: Test Mode

    4-3. TEST MODE 2: Whilst in Service Mode [See Page 25], Test Mode 2 is available by pressing the video standby button twice, OSD ‘TT’ appears. The functions described below are available by selecting the two numbers. To release the ‘Test mode 2’, press 0 twice, press the TV button or switch the TV set into Stand-by mode.

  • Page 31: Block Diagrams

    5-1. BLOCK DIAGRAMS (1) CN2000 TO G BOARD IC1811 IC1801 IC1804 IC1808 CN6006 QP OUTPUT AMP ANALOGUE PHASE CONTROL QP CONTROL COMPARATOR IC1402 DQP- TUNER TU1001 BACK END BLOCK DF-DRIVE DF-PHASE AC-AMP DQP-PHASE CN1803 CN1602 VM-OUT DQP-DC-LEVEL MAIN RY VM BOARD DPIC TO G BOARD CN5602...

  • Page 32: Block Diagrams

    5-1. BLOCK DIAGRAMS (2) IC4401 DIGITAL NOISE REDUCTION (DNR) IC4501 CN4473 H SYNC OUT H REF OUT D0 IN HDINB CPLD_VSYNC VDINB V SYNC OUT D1 IN CPLD_CLK CLKINB CLK OUT D2 IN CPLD_D(7) YINA7 D7 OUT D3 IN CN4472 IC4403 CPLD_D(6) YINA6...

  • Page 33: Block Diagrams

    5-1. BLOCK DIAGRAMS (3) TO D2 BOARD FV (T6800) J9002 IC8801 CN8500 IC9001 X-RAY TO A BOARD VIDEO OUT (RED) HD1 DELAY Q8806 CN1805 Q8807 BUFFER UPPER SWITCH HD2 OUT Q8010 H-OUT Q8100 T8100 Q8011 Q8102 HORIZONTAL OUTPUT STAGE IC9003 CN8614 CN9001 VIDEO OUT (BLUE)

  • Page 34: Block Diagrams

    5-1. BLOCK DIAGRAMS (4) CN4602 (1/2) CN4601 TO A BOARD ACT PWR RELAY SWITCH RELAY KICK VCC Q4600 CN1604 Q4601 TO G BOARD CN6013 STBY (+6V) T4601 RY4601 D4600 TRANSFORMER BRIDGE CN4602 CN4600 RECIFIER (2/2) AC IN PROTECTOR TO G BOARD MODULE PS4603 CN6007...

  • Page 35: Block Diagrams

    5-1. BLOCK DIAGRAMS (5) 5-2. CIRCUIT BOARD LOCATION Reference Information RESISTOR : METAL FILM : SOLID C1 Board FPRD : NON FLAMMABLE CARBON FUSE : NON FLAMMABLE FUSIBLE VM Board : NON FLAMMABLE METAL OXIDE D1 Board : NON FLAMMABLE CEMENT H6 Board M2 Board D2 Board...
  • Page 36 ~ A Printed Wiring Board Conductor side A ~ - 36 -...
  • Page 37 ~ A Printed Wiring Board Conductor side B ~ - 37 -...
  • Page 38 A Board Location Table (A Side) ~ A Board Waveforms ~ 10us/div 10us/div 10us/div 2ms/div 750 mVp-p (H) 650 mVp-p (H) 600 mVp-p (H) 2.8 Vp-p (V) 10us/div 10us/div 20us/div 10us/div A Board Location Table (B Side) ~ 5.2 Vp-p (H) 800 mVp-p (H) 700 mVp-p (H) 580 mVp-p (H)

  • Page 39: A Board Schematic

    A..-32DX150U R1274 C1273 100p 6.8k R1276 L1271 Q1271 Q1270 JR1245 2SC2412K-R C1275 C1276 2SC2412K-R JR1232 XX 0.01 R1290 L1272 FL1270 JR1233 CF1270 3.9k R1272 R1273 R1275 100uH Q1272 6.5MHZ 6.8k 2SC2412K-R JR1234 C1274 JR1238 R1270 JR1235 JR1236 R1250 R1288 R1289 R1277 R1278 R1279...
  • Page 40 A..-32DX150U R_MB C1505 BACKEND R_PJE R1521 R_MB R_TXT B_PJE G_TXT R1520 IC1502 B_TXT G_PJE RGB_TXT B_MB G_MB A 1/9 R1522 G_MB R1523 C1506 L1401 R1435 Q1405 10uH 2.2k R1404 R1407 BLK_MB BLK_TXT C1402 R1419 R1439 L1403 R1471 10uH R1513 PRE-RGB R1431 C1447 IC1501...
  • Page 41 A..-32DX150U R1131 C1837 R1854 470k 0.01 R1898 R1861 R1855 1/10W 4.7k D1811 3.3k R1807 C1807 C1802 R1826 RN-CP DAN202K-T-146 RN-CP 100k R1882 D1807 R1849 C1818 2.2k D1803 R1806 DAN202K-T-146 DAN202K C1822 0.47 C1803 C1806 C1800 0.22 R1845 0.047 4700p R1830 IC1811 R1802 R1803...
  • Page 42 A..-32DX150U ROTA DF_PARA A 3/9 MP_PARA A 3/9 HC_PARA H_DRIVE TO D1 BOARD AFC_PULSE CN8500 R1133 X_RAY ZOOM_COMP CN1805 R1199 R1862 C1823 R1857 Q1807 R1902 DEFLECTION, PICTURE ROTATION C1838 R1198 R1868 R1924 R1918 R1871 R1903 C1847 R1858 R1863 C1954 R1132 0.001 R1872 Q1812...
  • Page 43 A..-32DX150U INTERFACE +5V_STBY R1081 D1016 UDZS-5.6B Act9V D1022 D1NL20U-TR AOPP 3.3V_STBY A 6/9 D1017 IC1012 D1NL20U-TR BA033T A 7/9 REGULATOR D1012 +5V_STBY FL1010 UDZSTE-174.7B VIDEO 2.5V SCL-TV SDA-TV A 7/9 C1047 C1049 C1052 C1053 R1041 D1007 2200 DAP202K IC1008 PROT CXA1875AM-T4 AM, QSS I/O EXPANDER...
  • Page 44 TO G BOARD TO G BOARD CN6006 CN6008 CN1602 CN2000 A..-32DX150U REGULATORS +5V_STBY R1068 R1059 Q1012 4.7k 2SC2412K-R 4.7k AC_ON/OFF R1057 6.8k D1019 R1060 C1014 UDZS-5.6B ACT5V 0.22 ACT7V R1069 IC1013 IC1011 5V_JACT PS1012 4.7k PS1011 R1058 BA05T BA05T Q1011 L1013 10UH 2SC2412K-R...
  • Page 45 A..-32DX150U AOPP +5V_STBY D1003 A 5/9 DAN202K IC1201 5V_1 A 6/9 TDA7482 R1014 AUDIO AMPLIFIER WOOFER R1027 POWER-OFF-MUTE 4.7k Q1001 AUDIO PROTECTION R1079 D1201 2SC2412K DAN202K R1021 Q1003 Q1007 5V_1 DTA144EKA 2SC2412K C1205 Q1002 2200 D1004 R1205 2SC2412K DAN202K R1011 R1013 R1007 R1009...
  • Page 46 TO N BOARD CN3501 CN4000 A..-32DX150U C4086 C4085 C4084 ACT3.3V C4087 C4088 R4087 C4021 0.22 N-RESET FL4000 FL4001 FL4003 FL4004 FL4002 ACT5V ACT12V D.CVBS ACT5VD ACT2.5V ACT3.3V CN4001 FB4022 FB4023 FB4024 FB4025 FB4026 FB4027 FB4028 FB4029 C4046 ACT5VD FB4030 ACT5VD IC4005 R4078 TC74HC4066AF(EL)
  • Page 47 A..-32DX150U C4077 ACT9V 100p FB4011 C4010 C4004 ACT5VD R4002 R4015 10uH 10uH C4016 IC4000 R4024 TC74HC4066AF(EL) L4001 L4002 33VFE R4027 10uH 10uH 33VFE_T C4000 I/PA TU4000 D4000 R4022 L4000 Q4001 MTZJ-33A 22uH DTC144EKA ACT33V O/PA CONT A C4008 0.01 C4015 R4023 R4021 Q4000...
  • Page 48 ~ B5 Printed Wiring Board Conductor side A ~ ~ B5 Location Table A Side ~ ~ B5 Printed Wiring Board Conductor side B ~ ~ B5 Location Table B Side ~ - 48 -...

  • Page 49: B5 Board Schematic

    B5..-32DX150U CN4472 FL4405 D3.3V-AD POWER_INT POWER_INT C4463 L4411 C4459 C4464 R4447 D3.3V-AD 0.01 10uH 1/10W HP_100_OUT R4424 R4428 R4427 R4426 R4425 R4423 D3.3V-1 4.7k 2.2k 4.7k 2.2k 1/10W 1/10W 1/10W L4403 1/10W C4429 C4458 0.01 IC4402 SDA-MID TC7SET04F(TE85R) R4429 INVERTER Q4401 D3.3V-DCD 2SK2036...
  • Page 50 B5..-32DX150U 3.3VGR L4200 C4241 C4239 L4201 Q4201 R4251 IC4204 R4261 LOGIC VDD R4253 VCO VDD DDTB R4239 R4256 SELECT B5 1/7 Q4200 R BIAS R4262 C4243 FL4202 VCO IN FB4200 FINA +1.8V VCO GND R4254 R4257 R4263 FINB C4206 C4208 R4245 R4246 VCO INHBIT...
  • Page 51 B5..-32DX150U FL3203 FL3202 A5V-1 C3220 C3222 D5V-SCD R3226 C3212 C3208 C3217 R3201 C3219 C3235 Q3202 A5V-1 C3209 R3212 C3213 C3237 R3260 0.01 R3235 R3227 X3200 C3201 R3224 C3221 APC-FIL Cr OUT CN4474 Q3201 R3202 C3200 CVBS/Y3 Cb OUT R3213 ADD(8AH) Y OUT C3203 APL-FIL...
  • Page 52 B5..-32DX150U D[0-31] A[0-12] VDOYCLVL C4628 C4627 C4629 0.01 0.01 VDOCBCLVL 0.01 VDOCRCLVL SDDQM0 FL4607 C4630 0.01 D3.3V-MID C4636 C4635 C4637 IC4602 0.01 0.01 6.3V MT48LC2M32B2TG-6 64M_MEMORY RB4612 DQ15 D[0] D[15] VCCQ VSSQ VDOCIN7 SDADR3 D[1] D[14] D[16] DQ14 VDOCIN6 SDDAT16 D[2] D[13] D[17]...
  • Page 53 B5..-32DX150U DCDB COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL B5 1/7 C3114 C3129 C3131 0.01 0.01 0.01 C3134 0.01 DVD-14 DVS-7 XRST RSTX DVD-7 DVS-14 VTIM C3110 0.01 CHEN C3140 0.01 HTIM AVS-7 AVD-7 C3137 DTVVS DVS-6 0.01 DTVHS DVD-6...
  • Page 54 B5..-32DX150U VDMID HDMID CK54_OUT1 R4310 1/10W DSB[2-9],DSR[2-9],DSY[2-9] DS_OUT B5 2/7 FB4303 SCL-MID C4348 C4347 C4346 0.01 0.01 0.01 SDA-MID 1608 1608 1608 FB4302 C4349 0.01 1608 IP[0-7] IO_PORT B5 2/7 R4342 R4341 R4340 ADD_VSS2 IOPORT9 ADD_VDD4 R4311 IOPORT8 DRCVSOUT VDMID1 R4337 IP[7] 1/10W...
  • Page 55 B5..-32DX150U CPLD B5 1/7 CN4501 R4440 R4571 R4573 1/10W 1/10W C4513 HSYNCIN C4504 C4508 C4509 C4510 C4511 C4512 C4506 C4507 C4503 C4514 D3.3V-DCD RB4503 RB4504 R4570 R4572 R4574 1/10W 1/10W 1/10W D3.3V-DCD D3.3V-DCD +2.5V-DCD C4515 1608 FB4501 FB4502 D2-OUT D2-OUT R4576 1/10W C4502...

  • Page 56: C1 Board Schematic

    C1..-32DX150U CN9009 FV FOCUS CN9002 R9046 IC9001 OPEN 200V TDA6120Q/N2/S1 NL9002 R9056 C9031 C9032 R9092 4700p 680p 1/2W RED-VIDEO-OUT CHIP TO D1 BOARD R,G,B OUT CN8614 L9001 L9006 CN9003 R9031 R9037 1.5k C9048 R9028 R9103 22K 180k CHIP CN9004 Q9007 R9001 C9015 2SC3624A...
  • Page 57 ~ C1 Printed Wiring Board Conductor side ~ ~ C1 Board Waveforms ~ 10us/div 10us/div 2.0 Vp-p (H) 2.2 Vp-p (H) 5us/div 10us/div ~ C1 Board Semiconductor Voltage Table ~ 20.0 Vp-p (H) 2.2 Vp-p (H) 10us/div 5us/div 20.0 Vp-p (H) 20.0 Vp-p (H) 5ms/div 7.0 Vp-p (H)
  • Page 58 ~ H Board Schematic Diagram [ AV Link Processor ] ~ H..-32DX150U COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL CN301 +5V_STBY 3.3V_STBY AV LINK PROCESSOR +5V_STBY TO H6 BOARD CN7100 SIRCS R323 RESP_LED R322 R305 1608 D300 DTZ-TT11-6.8B D302 DAN202K-T-146...
  • Page 59 ~ D1 Board Semiconductor Voltages ~ ~ D1 Printed Wiring Board Conductor side ~ ~ D1 Board Location Table ~ ~ D1 Board IC Voltages ~ ~ D1 Board Waveforms ~ 10us/div 10us/div 10us/div ~ F Printed Wiring Board Conductor side ~ ~ H6 Printed Wiring Board Conductor side ~ 4.0 Vp-p (H) 20.0 Vp-p (H)

  • Page 60: D1 Board Schematic

    1.5kV 250V R8803 Q8106 R8217 R8218 STP5NB40FP R8118 D8802 T8101 PROT. REF R8223 Q8103 C8120 1SS355 C8807 R8607 R8104 R8105 2SC5696-SONY-CA 0.18UF D8206 C8111 C8113 R8219 4.7K 4.7K LOWER H-OUT 470p C8118 250V C8818 R8832 6200PF R8810 C8809 D8311 1.5KV 100k 0.01...

  • Page 61: G1 Board Schematic

    G1..-32DX150U CN4601 D4612 D1NL20U-TA2 STD-BY +6V TO G BOARD CN6013 DIGITAL POWER SUPPLY AND TIMER RECORD FUNCTION RELAY KICK VCC Q4600 D4611 DTA144ESA 1SS133 Q4601 2SC2785-HFE R4614 C4624 R4613 2.2M 1/4W 1/4W R4615 4.7k 1/4W RY4601 CN4602 C4600 4700p 250V D4607 D4600 FB4604...
  • Page 62 ~ G1 Printed Wiring Board Conductor Side~ ~ D2 Printed Wiring Board Conductor Side~ ~ D2 Board IC Voltages ~ ~ D2 Board Location Table ~ ~ D2 Board Semiconductor Voltages ~ - 62 -...

  • Page 63: D2 Board Schematic

    D2..-32DX150U C6852 0.01 R6865 SS RESET C6849 470p HV OVERSHOOT PROTECT 1608 Q6813 DYNAMIC PICTURE STABLISING CIRCUIT 2SB709A-QRS-TX R6862 R6897 470k R6870 D6820 R6867 220k MTZJ-7.5B 1/10W R6885 1/10W Q6817 1/10W 2SB709A-QRS Q6812 R6896 C6848 R6869 R6868 R6863 R6882 1/10W Q6814 1/10W 1/10W...
  • Page 64 ~ M2 Board IC Voltages ~ ~ M2 Board Semiconductor Voltages ~ ~ M2 Printed Wiring Board Conductor side A ~ ~ M2 Printed Wiring Board Conductor side B ~ - 64 -...

  • Page 65: M2 Board Schematic

    CN104 M2..-32DX150U R187 R215 R216 R217 +2.5VCORE +3.3V R213 R214 4.7k R188 +3.3V MICRO PROCESSOR AND TEXT DECODER 3.3k R100 R101 R189 C113 3.3k Q120 IC101 R102 C101 Q118 DTC114YKA Q116 RB113 PST6001MT RB111 Q100 DTC114YKA DTC114YKA IC104 M24C32-WMN6T(A) R124 /RESET Q119 C150...

  • Page 66: G Board Schematic

    32DX150U TO G1 BOARD CN4600 0.0015uF 2200pF 0.0015uF TO F3 BOARD CN7700 0.0015uF 0.0015uF 2200pF 15000UF 15000UF 100V RBA-406B RD15ESB2 S1VB40 ~ G Board Schematic Diagram [ Power Supply ] ~ - 66 -...
  • Page 67 ~ G Board IC Voltages ~ ~ G Board Semiconductor Voltages ~ ~ G Board Semiconductor Location Table ~ ~ G Printed Wiring Board Conductor side ~ ~ VM Printed Wiring Board Conductor side ~ ~ VM Board Waveforms ~ ~ VM Board Semiconductor Voltages ~ 500ns/div 500ns/div...

  • Page 68: Vm Board Schematic

    ~ VM Board Schematic Diagram [ Velocity Modulation ] ~ VM..-32DX150U +135V C5420 C5413 C5414 R5415 1/2W 250V C5400 C5401 R5404 Q5402 R5401 R5403 C5417 R5428 CN5402 L5400 3.3k 1.8k 2SC2785 R5430 0.18uH 1/4W 1/4W BUFFER 1/4W R5413 R5416 1/4W 1/4W +135V 1/4W...
  • Page 69 ~ J3 Printed Wiring Board Conductor side A ~ ~ J3 Printed Wiring Board Conductor side B ~ ~ J3 Board Location Table A side ~ ~ J3 Board Location Table B side ~ ~ F3 Printed Wiring Board Conductor side ~ ~ H5 Printed Wiring Board Conductor side ~ - 69 -...

  • Page 70: H5 Board Schematic

    H5..-32DX150U COMPONENTS MARKED AS XX ARE NOT FITTED ON THIS MODEL CN7103 HEADPHONE R IN GND (HP) HEADPHONE L IN GND (HP) AV3 CHROMA OUT TO A-BOARD CN1701 AV3 LUMINANCE OUT AV3 LEFT OUT D7902 C7925 C7926 D7901 0.022 0.022 AV3 RIGHT OUT D7900 D7903...
  • Page 71 J3..-32DX150U J3 2/2 R9256 V_M[2] R8817 RGB-SEL R9247 R9257 R9252 R9248 R9174 C9095 C9192 C9096 C9189 R9258 FL8811 C8992 C9099 C9094 C8991 C8990 C9097 C9098 0.047 0.047 0.047 0.047 0.047 0.047 R9259 R9245 Q9212 IMZ1A-T109 Q9211 GREEN IMZ1A-T109 C9191 C9190 R9203 R9254 R9251...
  • Page 72 J3..-32DX150U R_TV[1] R8931 R8937 CN8805 R_TV[1] C8914 R8934 4700p R9177 R8938 R8932 3.3k SCARTS R9121 RN-CP J3 1/2 R_IN[2] J3 1/2 BLK[5] F BLK C8913 L_TV[3] R8936 H- PULSE 1000p 470k R8933 R8939 Y_M[3] V PULSE IN L_TV[3] (CV02)VIDEO OUT H- PULSE IN J3 1/2 C8915...

  • Page 73: Semiconductors

    5-4. SEMICONDUCTORS BA09T PCF8591T STV9379 KA278R05-YDTU MCZ3001D SE-012N-LF4 PCF8593/T118 1 : V IN 2 : V OUT 3 : GND 4 : ON/OFF CONTROL PQ1CG2032FZ MSP3411G-QA-B10 TCET1103G LA6500-FA CSP1034AHJ-11-DB ( TOP VIEW ) TC55257DFTL-70V PST573IMT-T1 MC74F00M-T2 LM318P LM393PS-E20 CXA1875AM-T4 LM358DR M24C32-MN6T HE4094BT LM393DT...
  • Page 74 1673TV8-28RDD-DB BYV98-200-RAS 15/12 ERA38-06 MTZJ-33A MA3062M-TX ERA85-009 MTZJ-33B HZS9.1NB2 MTZJ-4.7C MTZJ-T-77-22 RD15ES-B2 CATHODE MTZJ-T-77-2.2A RD18ES-B2 MTZJ-13B RD5.6ESB2 MTZJ-15B 1SS119-25 MTZJ-8.2C ANODE CATHODE DTA144EKA-T146 2SA1037AK-T146 MA73-TX 2SA1037K-T-146-R DTC114EK 2SA1162-G DTC114YKA-T146 ANODE DTC144EKA 2SC1623-L5L6 DTC144EKA-T146 2SC12K-T-146-R 74LVC00-PW 74LVC32A-PW 74LVC08APW 74LVC374AD-T 74LVC163-PW 74LVC377D-T FBIU4D7MA-B 74LVC273PW 74LVC541APW...

  • Page 75: Ic Block Diagrams

    5-5 IC BLOCK DIAGRAMS J3 BOARD IC8810 TDA8601T DECODING SELECTABLE CLAMP SELECTABLE 3-STATE CLAMP SELECTABLE CLAMP SELECTABLE 3-STATE CLAMP SELECTABLE CLAMP SELECTABLE 3-STATE CLAMP 3-STATE G BOARD IC6001 MCZ3001D D2 BOARD IC6800 MCZ3001D Remote Internal DVLD Driver ref 5v Sel=34v Reg.
  • Page 76 A BOARD IC1231 MSP3411G SBUS Interface I2C Interface DEMODULATOR IDENT SCART Switching Facilities G BOARD IC6003 SE135N-LF4 A BOARD IC1801/IC1804/IC1808 LM393DT A BOARD IC1701 STV9379 A BOARD IC1802 LM358 FLYBACK GENERATOR POWER AMPLIFIER THERMAL PROTECTION - 76 -...
  • Page 77 A BOARD IC1002/IC1003/IC1006/IC1007/IC1010 PQ1CG2032FZ Vout ON/OFF PWM COMP ON/OFF ERROR AMP Oadj Vref A BOARD IC1012/IC1812 BA033T/BA12T D2 BOARD IC6801/IC6802 NJM2903/NJM2904 REFERENCE VOLTAGE D2 BOARD IC6803/IC6807 TLV431/TL1431 Cathode Vref Anode - 77 -...

  • Page 78: Exploded Views

    SECTION 6 EXPLODED VIEWS NOTE : Items with no part number and no description are not Items marked “*” are not stocked stocked because they are seldom required for routine since they are seldom required for service. routine service. Some delay should The construction parts of an assembled part are indicated be anticipated when ordering these items.

  • Page 79: Picture Tube

    6-2. PICTURE TUBE REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK - 79 -...

  • Page 80: Electrical Parts List

    SECTION 7 ELECTRICAL PARTS LIST PARTS LISTING TABLE OF CONTENTS Page D1 BOARD COMPLETE Parts List : ....................81 D2 BOARD COMPLETE Parts List : ....................83 G BOARD COMPLETE Parts List : ....................85 B5 BOARD COMPLETE Parts List: ....................
  • Page 81 H6 D1 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C8817 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V * A-1300-281-A D1 Board, Complete C8820 1-164-227-11 CERAMIC CHIP 0.022UF 10.00% 25V C8821 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V 4-382-854-01 SCREW (M3X8), P, SW (+) C8822 1-136-479-11 FILM 0.001UF...
  • Page 82 PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK Q8101 8-729-048-47 TRANSISTOR 2SC2688(5)-LK R8118 1-247-807-31 CARBON 1/4W Q8102 8-729-056-16 TRANSISTOR 2SC5698-SONY-CA R8119 1-247-807-31 CARBON 1/4W Q8103 8-729-056-17 TRANSISTOR 2SC5696-SONY-CA R8120 1-249-425-11 CARBON 4.7K 5% 1/4W Q8105 8-729-050-48 TRANSISTOR IRF614-005 R8121 1-249-425-11 CARBON 4.7K 5%...
  • Page 83 D1 D2 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R8831 1-216-829-11 METAL CHIP 4.7K 5% 1/10W C6820 1-130-495-00 MYLAR 0.1UF 5.00% 50V R8832 1-218-871-11 METAL CHIP 0.5% 1/10W C6821 1-126-964-11 ELECT 10UF 20.00% 50V R8833 1-218-879-11 METAL CHIP 0.5% 1/10W C6822 1-126-966-11 ELECT 33UF...
  • Page 84 F4 D1 D2 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK D6823 8-719-911-19 DIODE 1SS119-25 R6812 1-218-869-11 METAL CHIP 8.2K 0.5% 1/10W D6824 8-719-911-19 DIODE 1SS119-25 R6813 1-249-393-11 CARBON 1/4W D6825 8-719-911-19 DIODE 1SS119-25 R6814 1-249-393-11 CARBON 1/4W D6828 8-719-911-19 DIODE 1SS119-25 R6815 1-216-833-11 METAL CHIP 1/10W...
  • Page 85 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R6896 1-216-839-11 METAL CHIP 1/10W C6017 1-104-571-91 CERAMIC 0.0015UF 10.00% 2KV R6897 1-216-853-11 METAL CHIP 470K 5% 1/10W C6018 1-126-949-11 ELECT 220UF 20.00% 35V R6899 1-216-839-11 METAL CHIP 1/10W C6020 1-135-946-22 FILM 47000PF 800V R8949...
  • Page 86 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK D6008 8-719-063-70 DIODE D1NL20U Q6101 8-729-029-56 TRANSISTOR DTA144ESA D6009 8-719-110-41 DIODE RD15ESB2 Q6102 8-729-010-29 TRANSISTOR MSD601-RST1 D6010 8-719-085-24 DIODE FBIU4D7M1-B Q6103 8-729-029-56 TRANSISTOR DTA144ESA D6011 8-719-033-12 DIODE S3L40F Q6104 8-729-010-29 TRANSISTOR MSD601-RST1 D6012 8-719-033-12 DIODE S3L40F Q6105...
  • Page 87 G B5 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R6102 1-216-829-11 METAL CHIP 4.7K 5% 1/10W C3125 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V R6103 1-216-821-11 METAL CHIP 1/10W C3126 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V R6104 1-216-821-11 METAL CHIP 1/10W C3127 1-162-970-11 CERAMIC CHIP 0.01UF...
  • Page 88 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C4206 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V C4426 1-126-204-11 ELECT CHIP 47UF 20.00% 16V C4207 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V C4429 1-162-970-11 CERAMIC CHIP 0.01UF 10.00% 25V C4208 1-124-779-00 ELECT CHIP 10UF 20.00% 16V C4430...
  • Page 89 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C4510 1-162-905-11 CERAMIC CHIP 1PF 0.25PF 50V < DIODE > C4511 1-162-905-11 CERAMIC CHIP 1PF 0.25PF 50V C4512 1-162-905-11 CERAMIC CHIP 1PF 0.25PF 50V D4400 8-719-083-58 DIODE UDZSTE-173.9B C4513 1-162-905-11 CERAMIC CHIP 1PF 0.25PF 50V C4514 1-162-905-11 CERAMIC CHIP 1PF...
  • Page 90 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK FL4903 1-234-112-21 FILTER, LOW PASS Q3118 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R FL4904 1-234-112-21 FILTER, LOW PASS Q3119 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R Q3120 8-729-422-33 TRANSISTOR 2SD601A-Q-TX < IC > Q3122 8-729-422-33 TRANSISTOR 2SD601A-Q-TX Q3207 8-729-422-33 TRANSISTOR 2SD601A-Q-TX IC3100 8-752-413-28 IC CXD2096Q IC4201...
  • Page 91 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R3128 1-216-818-11 METAL CHIP 1/10W R3256 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R3129 1-216-864-11 SHORT CHIP R3257 1-216-821-11 METAL CHIP 1/10W R3130 1-216-818-11 METAL CHIP 1/10W R3258 1-216-821-11 METAL CHIP 1/10W R3131 1-216-809-11 METAL CHIP 1/10W R3259...
  • Page 92 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R4315 1-218-857-11 METAL CHIP 2.7K 0.5% 1/10W R4463 1-216-809-11 METAL CHIP 1/10W R4316 1-218-831-11 METAL CHIP 0.5% 1/10W R4465 1-216-833-11 METAL CHIP 1/10W R4317 1-218-831-11 METAL CHIP 0.5% 1/10W R4466 1-216-809-11 METAL CHIP 1/10W R4318 1-218-831-11 METAL CHIP...
  • Page 93 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R4600 1-216-827-11 METAL CHIP 3.3K 5% 1/10W RB4310 1-233-813-11 RES, NETWORK 150 (3216) R4601 1-216-864-11 SHORT CHIP RB4311 1-233-813-11 RES, NETWORK 150 (3216) R4602 1-216-825-11 METAL CHIP 2.2K 5% 1/10W RB4312 1-233-813-11 RES, NETWORK 150 (3216) R4603 1-216-864-11 SHORT CHIP...
  • Page 94 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C9021 1-107-961-91 ELECT 10UF 20.00% 250V < TRANSISTOR > C9022 1-101-004-00 CERAMIC 0.01UF C9023 1-101-004-00 CERAMIC 0.01UF Q9001 8-729-120-28 TRANSISTOR 2SC1623-L5L6 C9024 1-164-004-11 CERAMIC CHIP 0.1UF 10.00% 25V Q9007 8-729-141-73 TRANSISTOR 2SC3624A-T1L15L16 C9025 1-104-653-11 ELECT 220UF...
  • Page 95 C1 H REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R9051 1-202-557-00 SOLID 1/2W D305 8-719-069-54 DIODE UDZSTE-175.1B R9052 1-202-557-00 SOLID 1/2W D306 8-719-069-54 DIODE UDZSTE-175.1B R9056 1-202-549-00 SOLID 1/2W D307 8-719-069-54 DIODE UDZSTE-175.1B R9057 1-202-847-00 SOLID 560K 20% 1/2W D308 8-719-083-60 DIODE UDZSTE-174.7B R9059...
  • Page 96 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < CRYSTAL > C8891 1-126-947-11 ELECT 47UF 20.00% 35V C8892 1-164-346-11 CERAMIC CHIP 1UF X300 1-579-126-11 VIBRATOR, CERAMIC C8893 1-164-346-11 CERAMIC CHIP 1UF C8894 1-164-346-11 CERAMIC CHIP 1UF * A-1401-380-A J3 Board, Complete C8895 1-164-346-11 CERAMIC CHIP 1UF <...
  • Page 97 C J3 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C8988 1-164-156-11 CERAMIC CHIP 0.1UF D8811 8-719-083-82 DIODE UDZS-TE17-12B C8989 1-126-947-11 ELECT 47UF 20.00% 35V D8812 8-719-083-82 DIODE UDZS-TE17-12B C8990 1-165-176-11 CERAMIC CHIP 0.047UF 10.00% 16V D8813 8-719-083-82 DIODE UDZS-TE17-12B C8991 1-165-176-11 CERAMIC CHIP 0.047UF 10.00% 16V...
  • Page 98 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < TRANSISTOR > R8871 1-216-864-11 SHORT CHIP R8877 1-216-864-11 SHORT CHIP Q8300 8-729-120-28 TRANSISTOR 2SC1623-L5L6 R8880 1-216-809-11 METAL CHIP 1/10W Q8301 8-729-120-28 TRANSISTOR 2SC1623-L5L6 R8881 1-216-817-11 METAL CHIP 1/10W Q8302 8-729-120-28 TRANSISTOR 2SC1623-L5L6 R8882 1-216-817-11 METAL CHIP 1/10W...
  • Page 99 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R8942 1-218-285-11 METAL CHIP 1/10W R8994 1-218-859-11 METAL CHIP 3.3K 0.5% 1/10W R8944 1-216-071-00 RES-CHIP 8.2K 5% 1/10W R8996 1-216-017-91 RES-CHIP 1/10W R8945 1-218-285-11 METAL CHIP 1/10W R9004 1-218-285-11 METAL CHIP 1/10W R8946 1-216-813-11 METAL CHIP 1/10W...
  • Page 100 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R9147 1-216-809-11 METAL CHIP 1/10W R9253 1-216-817-11 METAL CHIP 1/10W R9148 1-218-871-11 METAL CHIP 0.5% 1/10W R9254 1-216-821-11 METAL CHIP 1/10W R9149 1-216-864-11 SHORT CHIP R9255 1-216-813-11 METAL CHIP 1/10W R9150 1-218-871-11 METAL CHIP 0.5% 1/10W R9256 1-216-864-11 SHORT CHIP...
  • Page 101 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < IC > C126 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V C127 1-162-927-11 CERAMIC CHIP 100PF 5.00% 50V IC101 6-702-313-01 IC PST600IMT C128 1-115-467-11 CERAMIC CHIP 0.22UF 10.00% 10V IC103 6-703-799-01 IC SDA6000-B12-GEG C129 1-115-467-11 CERAMIC CHIP 0.22UF 10.00% 10V...
  • Page 102 M2 A REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R146 1-216-812-11 METAL CHIP 1/10W R234 1-216-864-11 SHORT CHIP R158 1-216-825-11 METAL CHIP 2.2K 5% 1/10W R235 1-216-864-11 SHORT CHIP R159 1-216-833-11 METAL CHIP 1/10W R236 1-216-864-11 SHORT CHIP R161 1-216-825-11 METAL CHIP 2.2K 5% 1/10W...
  • Page 103 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C1003 1-126-935-11 ELECT 470UF 20.00% 16V C1061 1-164-004-11 CERAMIC CHIP 0.1UF 10.00% 25V C1006 1-136-495-11 FILM 0.068UF 5.00% 50V C1062 1-126-935-11 ELECT 470UF 20.00% 16V C1007 1-136-495-11 FILM 0.068UF 5.00% 50V C1070 1-126-960-11 ELECT 20.00% 50V C1008...
  • Page 104 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C1254 1-165-319-11 CERAMIC CHIP 0.1UF C1438 1-107-826-11 CERAMIC CHIP 0.1UF 10.00% 16V C1255 1-164-004-11 CERAMIC CHIP 0.1UF 10.00% 25V C1439 1-137-581-11 FILM 0.1UF 5.00% 100V C1256 1-107-823-11 CERAMIC CHIP 0.47UF 10.00% 16V C1440 1-164-004-11 CERAMIC CHIP 0.1UF 10.00% 25V...
  • Page 105 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK C1837 1-136-153-00 FILM 0.01UF 5.00% 50V < CERAMIC TRAP > C1843 1-137-499-11 FILM 0.015UF 5.00% 630V C1850 1-126-947-11 ELECT 47UF 20.00% 35V CF1270 1-781-328-21 TRAP, CERAMIC C1852 1-137-194-81 FILM 0.47UF 5.00% 50V C1853 1-164-222-91 CERAMIC CHIP 0.22UF <...
  • Page 106 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK D1023 8-719-069-55 DIODE UDZSTE-175.6B FB1009 1-414-766-22 FERRITE D1070 8-719-914-44 DIODE DAP202K FB1010 1-414-766-22 FERRITE D1201 8-719-914-43 DIODE DAN202K FB1011 1-216-295-91 SHORT CHIP D1202 8-719-914-44 DIODE DAP202K FB1012 1-216-295-91 SHORT CHIP D1203 8-719-914-44 DIODE DAP202K FB1013 1-535-303-00 LEAD, JUMPER (5.0MM) D1204...
  • Page 107 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < IC > L1018 1-419-249-11 INDUCTOR 15UH L1019 1-412-525-31 INDUCTOR 10UH IC1001 8-759-450-47 IC BA05T L1020 1-412-525-31 INDUCTOR 10UH IC1002 8-759-640-19 IC PQ1CG2032FZ L1201 1-416-857-11 INDUCTOR 65UH IC1003 8-759-640-19 IC PQ1CG2032FZ L1202 1-414-158-11 INDUCTOR 2.2UH IC1005...
  • Page 108 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK Q1271 8-729-901-81 TRANSISTOR 2SC2412K-T-146-R R1020 1-216-817-11 METAL CHIP 1/10W Q1272 8-729-901-81 TRANSISTOR 2SC2412K-T-146-R R1021 1-216-841-11 METAL CHIP 1/10W Q1402 8-729-901-81 TRANSISTOR 2SC2412K-T-146-R R1022 1-216-834-11 METAL CHIP 1/10W Q1406 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R R1023 1-218-867-11 METAL CHIP 6.8K 0.5% 1/10W Q1407...
  • Page 109 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R1076 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R1211 1-216-828-11 METAL CHIP 3.9K 5% 1/10W R1078 1-216-864-11 SHORT CHIP R1212 1-216-828-11 METAL CHIP 3.9K 5% 1/10W R1081 1-216-397-11 METAL OXIDE R1213 1-216-357-00 METAL OXIDE R1082 1-216-864-11 SHORT CHIP R1214...
  • Page 110 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R1293 1-216-864-11 SHORT CHIP R1494 1-216-821-11 METAL CHIP 1/10W R1297 1-216-864-11 SHORT CHIP R1495 1-218-889-11 METAL CHIP 0.5% 1/10W R1406 1-216-833-11 METAL CHIP 1/10W R1496 1-216-821-11 METAL CHIP 1/10W R1411 1-216-809-11 METAL CHIP 1/10W R1497 1-216-821-11 METAL CHIP...
  • Page 111 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R1823 1-216-809-11 METAL CHIP 1/10W R1967 1-218-903-11 METAL CHIP 220K 0.5% 1/10W R1825 1-216-809-11 METAL CHIP 1/10W R1968 1-218-887-11 METAL CHIP 0.5% 1/10W R1826 1-218-895-11 METAL CHIP 100K 0.5% 1/10W R1969 1-218-875-11 METAL CHIP 0.5% 1/10W R1828 1-216-864-11 SHORT CHIP...
  • Page 112 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < RESISTOR > R4049 1-216-833-11 METAL CHIP 1/10W R4050 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R1001 £ 1-202-719-00 SOLID 1/2W R4051 1-216-829-11 METAL CHIP 4.7K 5% 1/10W R4067 1-216-827-11 METAL CHIP 3.3K 5% 1/10W <...
  • Page 113 VM G1 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK * A-1636-052-A G1 Board, Complete < COIL > L5400 1-410-784-41 INDUCTOR 0.18UH 4-202-373-01 SPRING, IC L5401 1-414-930-21 INDUCTOR 2.2UH 4-382-854-01 SCREW (M3X8), P, SW (+) < TRANSISTOR > < CAPACITOR > Q5400 8-729-119-78 TRANSISTOR 2SC2785-HFE C4600 £...
  • Page 114 G1 F3 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK D4611 8-719-991-33 DIODE 1SS133T-77 R4615 1-249-425-11 CARBON 4.7K 5% 1/4W D4612 8-719-063-70 DIODE D1NL20U R4616 1-216-366-00 METAL OXIDE 0.56 5% R4617 1-249-415-11 CARBON 1/4W < FERRITE BEAD > R4618 1-249-420-11 CARBON 1.8K 5% 1/4W FB4601...
  • Page 115 REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK < SWITCH > MISCELLANEOUS S7100 1-771-947-11 SWITCH, TACTILE 1-529-408-11 SPEAKER (4.2X24CM) S7101 1-771-947-11 SWITCH, TACTILE 1-424-855-11 COIL, PFC CHOKE 29MMH S7102 1-771-947-11 SWITCH, TACTILE £ 1-776-204-11 CORD, POWER, FILTER 8-598-529-10 FRONTEND BTF-EU611 * A-1646-259-A H6 Board, Complete 8-598-627-00 TUNER UNIT, DIGITAL BTD-DU605 4-205-711-01 HOLDER, LED...
  • Page 116 • User programmable Functional Check through Infrared • Fast and documented Test Mode setting of all Sony TV chassis Additional features such as Adjustments and Troubleshooting are available in chassis-dependent software modules. Please contact your local Sony Service organisation for the latest information.

Table of Contents