Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for hestan Aspire ECD30
Summary of Contents for hestan Aspire ECD30
- Page 1 OUTDOOR COOKING Grill Cart Use & Care Manual Installation & Operation...
- Page 2 Electrical Parts & Components – disconnect all power supplies and batteries before servicing. READ THIS MANUAL CAREFULLY AND COMPLETELY BEFORE USING YOUR GRILL TO REDUCE THE RISK OF FIRE, BURN HAZARD, OR OTHER INJURY. KEEP THIS MANUAL FOR FUTURE REFERENCE. ©2017 Hestan Commercial Corporation...
-
Page 3: Table Of Contents
TABLE OF CONTENTS MODEL NUMBERS INTRODUCTION PRECAUTIONS REGULATORY / CODE REQUIREMENTS PORTABLE LP CYLINDERS CART & GRILL ASSEMBLY GAS CONNECTIONS PARTS LIST SERVICE WARRANTY ©2017 Hestan Commercial Corporation... -
Page 4: Model Numbers En
MODEL NUMBERS Double Door Model CART MODELS Model No. Description ECD30 30” DOUBLE DOOR TOWER CART ECD36 36” DOUBLE DOOR TOWER CART ©2017 Hestan Commercial Corporation... -
Page 5: Introduction
INTRODUCTION Thank you for choosing the Aspire by Hestan Outdoor Grill Cart. We have written this Installation Guide to help you properly install an Aspire Grill for years of safe and enjoyable use. Keep this guide handy, as it will help answer questions that may arise as you use your new Cart. -
Page 6: Precautions
13. Do not overload the side shelves of the cart as this may result in damage to the unit, or personal injury. Do not sit, step, or push down on the side shelves. The maximum load rating of the side shelf is 25 lbs. (11.3 kg). ©2017 Hestan Commercial Corporation... -
Page 7: Regulatory / Code Requirements
IF THE INFORMATION IN 1 AND 2 ABOVE IS NOT FOLLOWED EXACTLY, A FIRE CAUSING DEATH OR SERIOUS INJURY MAY OCCUR. The LP cylinder must be disconnected and stored OUTSIDE in a well-ventilated area, out of the reach of children. Do not store a full cylinder in direct sunlight. ©2017 Hestan Commercial Corporation... -
Page 8: Cart & Grill Assembly
If any tie-down wires are on the burners, leave them on until grill installation is complete. Remove the rear access panel from the cart by removing all the Phillips screws securing it to the cart. ©2017 Hestan Commercial Corporation... - Page 9 Snap the strain relief together with a pair of large pliers. Push the strain relief into the rear panel of the cart until it snaps in. ©2017 Hestan Commercial Corporation...
- Page 10 The rear edge of the grill head must be flush with the rear of the cart. Check for interferences at the wire harness or any power cables. PANELS TO BE FLUSH AT REAR PANELS TO BE FLUSH ©2017 Hestan Commercial Corporation...
- Page 11 11. Reach inside the right front area of the cart wall and install 2 flat washers and hex bolts as shown here using a 7/16” wrench or socket wrench. Do not tighten yet. Repeat this on the opposite side of the cart. ©2017 Hestan Commercial Corporation...
- Page 12 Note: If the holes do not wish to align, a large bar-clamp may be used as shown below to help pull everything together. Use rags or small pieces of cardboard to cushion the clamp and not scratch the finish on your grill and cart. ©2017 Hestan Commercial Corporation...
- Page 13 Aspire grill. Follow all instructions for regulator installation, gas connections, leak testing, burner adjustment, etc. before using your grill. After all these steps are completed, you can re- install the control panel and knobs, and the rear access panel on the cart. ©2017 Hestan Commercial Corporation...
- Page 14 Loosen the top & bottom screw on each mounting base, then use the height adjustment screw shown below to fine-tune the vertical height of the door in the cart. Tighten the top and bottom screws when done. HEIGHT ADJUSTMENT ©2017 Hestan Commercial Corporation...
- Page 15 DEPTH ADJUSTMENT ADJUSTMENT 19. To re-install the door, follow the instructions shown below. MOUNTING MOUNTING BASE BASE PUSH HINGE UNTIL REAR CLIP ENGAGES CART WALL CART WALL ATTACH AT THIS STRUCTURE STRUCTURE NOTCH FIRST DOOR DOOR ©2017 Hestan Commercial Corporation...
-
Page 16: Gas Connections
Periodically check the whole system for leaks, or immediately check if the smell of gas is detected. Please read the Aspire Grill manual for complete instructions on proper leak testing of your grill before using. ©2017 Hestan Commercial Corporation... -
Page 17: Parts List
Hestan Commercial Service Provider, Purchaser will pay the difference between regular rates and overtime or premium rates. Purchaser is required to pay all travel costs for travel beyond 50 miles (one way) from the nearest authorized Hestan Commercial Service Provider. - Page 18 Product; damage from service by someone other than an authorized agent or representative of the Hestan Commercial Service Network; normal wear and tear; damage from exposure of the Product to a corrosive atmosphere containing chlorine, fluorine, or any other damaging chemicals; damage resulting from the failure to provide normal care and maintenance to the Product;...
- Page 19 This warranty gives you specific legal rights, and you may also have other rights which vary depending on location. Any questions about this Limited Warranty may be directed to Hestan Commercial Corporation at (888) 905-7463. ©2017 Hestan Commercial Corporation...
- Page 20 RETAIN THIS MANUAL FOR FUTURE REFERENCE Hestan Commercial Corporation 3375 E. La Palma Ave Anaheim, CA 92806 (888) 905-7463 ©2017 Hestan Commercial Corporation P/N 014117 REV A...
Need help?
Do you have a question about the Aspire ECD30 and is the answer not in the manual?
Questions and answers