JLG 600SC Operator's And Safety Manual page 27

Number/Type
Components
Lube Points
Lubrication
1 Swing Bearing 2 Grease Fittings
2 Swing Drive Hub Level/Fill Plug
3 Final Drive Hub Level/Fill Plug
4 Hydraulic Return Filter
5
Hydraulic Charge Filter
6 Hydraulic Oil
7 Suction Strainers (in
tank)
Engines
8 Fill Cap/Spin-on Element
Oil Change w/Filter -
Deutz
9 Fuel Filter - Deutz Replaceable Element
10 Replaceable Element
Air Filter - Deutz
NOTES:
Lubrication intervals are based on machine operation under normal
conditions. For machines used in multi shift operations and/or
exposed to hostile environments or conditions, lubrication frequen-
cies must be increased accordingly.
3120897
Table 2-1. Lubrication Chart
Capacity
A/R
0.5 liters (1/2 Full)
7.9 liters (1/2 Full)
N/A N/A
N/A N/A
Fill Cap 115.8 liters Tank
123.8 liters System
2 N/A
10.4 liters Crankcase
**4.7 liters Cooler
N/A
N/A
** When changing oil in the Deutz oil cooled engine, drain both the crankcase and
the cooler. When refilling it is acceptable to overfill the crankcase (15.1 liters.,
capacity of both crankcase and cooler combined). Start engine, allow the engine
to run until the thermostat opens (approximately 105 degrees C) cooler will fill up
within minutes; shut down and wait for approximately two minutes. Check oil
level, fill oil to max marking on the dipstick.
SECTION 2 - PREPARATION AND INSPECTION
Interval
Lube
3 Months 6 Months 1 Year
150 hrs 300 hrs 600 hrs
MPG X
EPGL X
EPGL X
N/A X
N/A X
HO
N/A
EO
N/A
N/A X
– JLG Lift –
Hours
Comments
2 Years
1200 hrs
Remote Access
Check level every 150 hrs/change 1200 hours
Check level every 150 hrs/change 1200 hours
Change after first 50 hrs. and every 300 hrs.
thereafter or as indicated by Condition Indica-
tor.
Change after first 50 hrs. and every 300 hrs.
thereafter or as indicated by Condition Indica-
tor.
X Check level daily/change 1200 hours
X Remove and clean at time of hydraulic oil
change.
X Check level daily/Change in accordance with
engine manual.
X
Or as indicated by Condition Indicator.
KEY TO LUBRICANTS
EO Engine Oil
EPGL Extreme Pressure Gear Lube
HO Hydraulic Fluid (Mobil #424 or equivalent)
MPG Multi-Purpose Grease
2-13