Maintenance And Repair; Correct Disposal; 10 Warranty - Wetrok DISCOMATIC SAMBA XT Operating Instructions Manual

6 SAFETY INFORMATION FOR BATTERY-OPERATED CLEANING MACHINES
• Batteries contain corrosive sulphuric acid. Not to be taken internally! Avoid any contact with skin and eyes.
• During wet-cell charging, the battery compartment must be open without fail, otherwise there is a danger of
explosion by electrolytic gas. There is the risk of serious injury!
• Batteries may be charged using only a suitable original charger.
• Never have naked flames or incandescent object near the batteries.
• Do not generate sparks near batteries.
• Strictly no smoking.
• Do not open batteries.
• Do not touch battery terminals.
• The contacts must be covered to prevent short circuiting by metal jumpers (e.g. hybrid connections).
• For cleaning and maintenance, or when changing accessories and spares, always isolate the machine from
the battery by detaching the battery-charging plug.
• Do not clean machine with high-pressure or steam-pressure cleaners or liquid spray.
• No modifications to the 230V wires are permitted! In particular, do not remove or open any electrical
terminals or remove the earth cable! Do not operate appliances with damaged cables!
Preventing total discharge of batteries
Before periods of prolonged non-use, the battery must be fully charged to protect it from total discharge, and thereafter the electrical
components from the battery must be isolated by pulling the charging plug from the battery. Discharges of more than 80 % of the
nominal capacity, i.e. when the battery charge is 20 % or less, are regarded as total discharges. The outcome is a shortened battery life
or complete destruction of the battery. Claims under guarantee involving flat batteries or destruction can therefore not be validated.
7

MAINTENANCE AND REPAIR

Our products have been inspected for safety at the factory. To ensure their operational safety and to maintain their value, a service must
be carried out once every twelve months or after 400 hours of operation. Service may only be performed by our service department or by
approved experts.
8 TRANSPORTATION AND STORAGE
Temperature must not exceed 50°C when transporting and storing machine.
At temperatures below 0°C, the water system must be enriched with anti-freeze.
When machine is transported, it must be properly packed and secured. If the machine is stored,
the fresh water and dirty water must be emptied and the tank must be cleaned.
9

CORRECT DISPOSAL

• Packaging, unused cleaning agents and dirty water must be disposed of in accordance with regulations in force at national level.
• Return batteries unopened to the manufacturer for professional disposal.
• The machine must be disposed of after decommissioning in accordance with regulations in force at national level.

10 WARRANTY

• The valid warranty conditions can be found on the current price list, offer, invoice and/or can be enquired at your sales agency.
• Where damage occurs because of disregarding these instructions as well as improper treatment or using machine other than for its
intended purpose, claims under the warranty will be void. No liability will be accepted for consequential damage arising therefrom.
• Damage resulting from natural wear, overloading or improper handling are likewise not covered by the warranty.
• Complaints will only be acknowledged if the machine has been repaired each time by an approved service agency.
41
EN