Page 1
DiVA Service Manual Issue 1.0 DV78 DVD Player ARCAM Bringing music & movies to life...
Page 2
DV78 Contents List Circuit Description Power Supply L959AY ! CCT diagram ! Component layout diagram ! Parts list Main Board L960AY ! CCT diagram ! Component layout diagram ! Parts list Display Board L961AY ! CCT diagram ! Component layout diagram ! Parts list Transformers ! L924TX...
Page 3
Diva Dv78 circuit description Overview Fig 1 PSU clock control The DiVa DV78 is a completely new design platform that share a similar circuit topology to the earlier PSUFS1 PSUFS0 PSUCLK released Vaddis V based players such as the Diva...
Page 4
The 1V8 rail is derived from the 3V3 rail and is Main Board electronics DV78. regulated by the adjustable regulator at location REG1003. Zoran Vaddis V. The Analogue supply stages arrive at the main board The main processor/control chip on the main board is the as +15V3 and –15V3 rails these are filtered L1002 and Zoran Vaddis V at location IC202, this is the latest L1015 before being regulated by the adjustable...
Page 5
Display Board interface Clocks The display board interface is on the 16 way FFC flexi CLK27MV is the 27Mhz clock for video. It is used to foil connector at location CON202. Power for the generate the 135Mhz clock for the Vaddis microprocessor and DSP.
Page 6
Clocks and SPDIF stage. The circuit will also switch the PSUCLK off when switching between sample rates (the PSU will free run when the IC300 is a PLL1700E clock generator IC the chip is PSUCLK is not present). powered from the +5V(D) rail. The Chip runs in SPDIF Output software mode and is slaved from the Vaddis V (data coming in on the MD line).
Page 7
Video Output stage The DV78 video output stage makes use of the VADDIS V’s on board video DAC stages and as such does not use the superior Analogue devices video encoder DV79/DV29 and is fed by the following video lines from the Vaddis V. Composite SVID_C SVID_Y...
Page 13
Audio Master clock frequency for different sample rates Master clock frequency +5VD AUDIO CLOCK BUFFER R312 44.1kHz 16.9344MHz (384 x Fs) 48kHz 18.432MHz (384 x Fs) C303 88.2kHz 33.8688MHz (384 x Fs) C306 0W125 96kHz 36.864MHz (384 x Fs) 0805 176.4kHz 33.8688MHz (192 x Fs)
Page 14
+12VA OUTPUT BUFFER Audio outputs are inverted so as to be compatible with DV88. This is compenstaed for in software by setting a Gain of -2.2 for HDCD, otherwise -1.1 register in the DAC to invert the signal Cheapo version could have bipolar op-amp, but without feedback round coupling cap D400 R420 BAT54S...
Page 15
ALL PARTS ON THIS SHEET ARE NOT FITTED Audio outputs are inverted so as to be compatible with +12VA DV88. This is compenstaed for in software by setting a OUTPUT BUFFER register in the DAC to invert the signal Gain of -1.1 Cheapo version could have bipolar op-amp, but without feedback round coupling cap D500 BAT54S...
Page 16
ALL PARTS ON THIS SHEET ARE NOT FITTED +12VA Audio outputs are inverted so as to be compatible with OUTPUT BUFFER DV88. This is compenstaed for in software by setting a register in the DAC to invert the signal Gain of -1.1 Cheapo version could have bipolar op-amp, but without feedback round coupling cap D600 R616...
Page 18
SCART_RIGHT AUDIO SCART_LEFT C800 C801 100V 100V R800 0805 0805 DGND 0W125 0805 SCART_BLUE VIDEO SCART_GREEN SCART_RED SCART_COMPOSITE SCART OUTPUT C802 C803 C804 C805 100V 100V 100V 100V 0805 0805 0805 0805 SKT800 SCART RIGHT DGND SCART_LEFT SCART_AGND SCART_BLUE 0/6/12 SCART control signals SCART_GREEN ENABLE_AV: 0 in when standby mode, 1 when on...
Page 19
The remote bus is demodulated To front panel using an LED and the IR receiver on Capacitors near front panel interface the display board. The demodulator circuit here can optionally be used REMOTE_BUS_P instead. C922 RC5 REMOTE BUS DEMOD 100V R904 P914 0805...
Page 25
DV78 DVD player Main board L960AY issue 1.2.4 Designator Part Description C711 2L112 Capacitor SM 0805 NPO Ceramic 5% 100V 120P C712 2L882 Capacitor SM 0805 NPO Ceramic +/-0.25pF 100V 8P2 C713 2L882 Capacitor SM 0805 NPO Ceramic +/-0.25pF 100V 8P2 C714 2L882 Capacitor SM 0805 NPO Ceramic +/-0.25pF 100V 8P2...
Page 26
DV78 DVD player Main board L960AY issue 1.2.4 Designator Part Description C912 2L110 Capacitor SM 0805 NPO Ceramic 5% 100V 100P C913 2L110 Capacitor SM 0805 NPO Ceramic 5% 100V 100P C914 2L110 Capacitor SM 0805 NPO Ceramic 5% 100V 100P C915 2Z710B Capacitor Low Impedance Radial Electrolytic Dia 5mm Pitch 5mm 100UF 10V...
Page 27
DV78 DVD player Main board L960AY issue 1.2.4 Designator Part Description D400 3F54S Diode Schottky BAT54S SOT-23 Package D401 3F54S Diode Schottky BAT54S SOT-23 Package D403 3F54S Diode Schottky BAT54S SOT-23 Package D404 3AS16W Diode Surface Mount Small Signal BAS16W SOT-23 Package D500 3F54S Diode Schottky BAT54S SOT-23 Package...
Page 28
DV78 DVD player Main board L960AY issue 1.2.4 Designator Part Description L502 7E101 Common Mode Choke 1000R@100MHz L600 7F007 Ferrite Bead SM0805 120R@100MHz L601 7E101 Common Mode Choke 1000R@100MHz L602 7E101 Common Mode Choke 1000R@100MHz L700 7B810 Inductor Surface Mount 1U0 L701 7B810 Inductor Surface Mount 1U0...
Page 29
DV78 DVD player Main board L960AY issue 1.2.4 Designator Part Description R225 1N210 Resistor 0603 Surface Mount 0.063W 1% 1K0 R226 1M210 Resistor 0805 Surface Mount 0.125W 1% 1K0 R227 1M210 Resistor 0805 Surface Mount 0.125W 1% 1K0 R228 1M210 Resistor 0805 Surface Mount 0.125W 1% 1K0 R229 1M210...
Page 30
DV78 DVD player Main board L960AY issue 1.2.4 Designator Part Description R415 1M310 Resistor 0805 Surface Mount 0.125W 1% 10K R416 1M310 Resistor 0805 Surface Mount 0.125W 1% 10K R417 1M310 Resistor 0805 Surface Mount 0.125W 1% 10K R418 1M310 Resistor 0805 Surface Mount 0.125W 1% 10K R419 1M347...
Page 31
DV78 DVD player Main board L960AY issue 1.2.4 Designator Part Description R614 1M310 Resistor 0805 Surface Mount 0.125W 1% 10K R615 1M347 Resistor 0805 Surface Mount 0.125W 1% 47K R616 1M311 Resistor 0805 Surface Mount 0.125W 1% 11K R617 1M311 Resistor 0805 Surface Mount 0.125W 1% 11K R618 1M510...
Page 32
DV78 DVD player Main board L960AY issue 1.2.4 Designator Part Description R810 1M133 Resistor 0805 Surface Mount 0.125W 1% 330R R811 1M210 Resistor 0805 Surface Mount 0.125W 1% 1K0 R812 1M075 Resistor 0805 Surface Mount 0.125W 1% 75R R900 1M000 Resistor 0805 Surface Mount 0.125W 1% 0R0 R901 1M233...
Page 33
DV78 DVD player Main board L960AY issue 1.2.4 Designator Part Description SKT102 8D232 Phono Skt 2 Way Vert Gold Individual Gnds SKT100 8D232 Phono Skt 2 Way Vert Gold Individual Gnds SKT101 8D232 Phono Skt 2 Way Vert Gold Individual Gnds SKT104 8D232 Phono Skt 2 Way Vert Gold Individual Gnds...
Page 36
DV78 DVD player Display board L961AY issue 1.3.0 Designator Part Description 2J410 Capacitor SM 0805 X7R Ceramic 10% 50V 100N 2J410 Capacitor SM 0805 X7R Ceramic 10% 50V 100N 2J410 Capacitor SM 0805 X7R Ceramic 10% 50V 100N 2J410 Capacitor SM 0805 X7R Ceramic 10% 50V 100N 2MA610 Capacitor Surface Mount Electrolytic 10UF 50V 6.3 X 4.5MM 2MA610...
Page 37
Transformer Specification for 115/230V 50/60Hz mains transformer. Arcam Part Number L924TX The transformer is extremely cost sensitive. It is to employ the most cost effective techniques to achieve the specification. The transformer output voltage will be regulated by a switch mode power supply.
Page 38
WINDING DETAILS NOTE. TRANSFORMER IS TO BE USED ON SECONDARY SIDE OF MAINS No PER START NOTES WINDING TURNS WIRE DETAILS CABLE PIN # PIN # ISOLATION BARRIER (I.E. THIS TRANSFORMER IS NOT REQUIRED TO PROVIDE MAINS ISOLATION BARRIER) PRIMARY2 ENAMELLED COPPER WIRE 0.8mm 0.86mm...
Page 39
VIII 24 x7 VI & VII VIII USE TO SECURE TRANSFORMER WIRES (TYP 2 PLACES)
Page 40
M Screw Torx M4x6MM ST BLK Designator Part Packing Accessories E966SL Diva DV78 Carton Label SH131 Handbook Diva DV78 DVD Player Multi E822PK Poly Sheet 915x900MM 350 Gauge L415RC DVD Remote Control CR415 P3020 Poly Bag 10x14 Grippa Seal Clear...
Page 41
ARCAM All parts can be ordered via spares@arcam.co.uk Pembroke Ave, Waterbeach, Cambridge, CB5 9PB, ENGLAND TEL: +44(0) 1223 203 200 FAX: +44(0) 1223 863 384...