Table of Contents
Advertisement
chamberlaindiy.com.au
chamberlaindiy.co.nz
Garage Roller Door Opener
Installation and Operating Instructions
Owners Copy: Please keep these instructions for future reference
CR625EVO
This manual contains IMPORTANT SAFETY information
DO NOT PROCEED WITH THE INSTALLATION UNTIL READING THE
INSTRUCTIONS THOROUGHLY
Advertisement
Table of Contents
Related Manuals for Chamberlain CR625EVO
Summary of Contents for Chamberlain CR625EVO
- Page 1 CR625EVO Garage Roller Door Opener Installation and Operating Instructions Owners Copy: Please keep these instructions for future reference This manual contains IMPORTANT SAFETY information DO NOT PROCEED WITH THE INSTALLATION UNTIL READING THE INSTRUCTIONS THOROUGHLY...
- Page 2 Warranty Registration Register your warranty at: chamberlaindiy.com.au/warranty chamberlaindiy.co.nz/warranty...
-
Page 3: Table Of Contents
START BY READING THESE IMPORTANT SAFETY INSTRUCTIONS WARNING • Failure to comply with the following instructions may result in serious injury or property damage. • Read and follow all instructions carefully. • The garage door opener is designed and tested to offer safe service provided it is installed and operated in strict accordance with the instructions in this manual. -
Page 4: Carton Inventory
Quick Start Guide 5.5 mm DOOR REQUIREMENTS The HandyLift Plus 2.0 (CR625EVO) is suitable for spring balanced Residential Rolling garage doors with: • Maximum door height of 4.5 m • Maximum curtain area of 13 m • Maximum door mass of 80 kg The obstruction detection beams must be installed if the force at the edge of the closing door exceeds 400 N (40 kgf). -
Page 5: Control Panel
CONTROL PANEL 1. Terminal Block: used for external accessories (see chart below). Colour Polarity Comment Ref Function Push button Dry contact input for push button wired wall controls White Common Common terminal for push button, obstruction detection beams & accessory power B Common White Common terminal for push button, obstruction... -
Page 6: Operating Manual Release
THE RELEASE HANDLE & CORD Do not disengage the opener to manual operation with children, persons or other objects including motor vehicles within the doorway. The door is under significant tension and if the door has developed a fault or incorrect tension, it may be unsafe and may fall rapidly. The manual release mechanism enables the door to be manually operated during power outages or in an emergency. -
Page 7: Prepare & Test The Door
TESTING THE DOOR Complete the following test to ensure your door is well balanced, and not sticking or binding: • Disable all locks and remove any ropes connected to the garage door. • Lift the door to about halfway and then release it. The door should remain spring balanced. -
Page 8: Pinning The Door
PINNING THE DOOR Note: A ballooning door may delay the safety reversal response and can compromise garage door security. • To remedy any ballooning, insert the supplied self tapping Free curtain Ballooning Add fasteners here metal screws (inset 3) into where the curtain leaves the roll. Secure these through the curtain into the drum wheel at each end of the roll. -
Page 9: Installation Procedure
INSTALLATION PROCEDURE Do not allow people to walk under or around the door during the installation process as serious injury can occur. NOTE: The opener can be installed on either side of the door. The following instructions are for Rope RIGHT HAND INSTALLATIONS (as illustrated i.e. -
Page 10: Adjustment & Testing
Courtesy light: During the programming sequence, the courtesy light will flash at half strength NOTE: The HandyLift Plus 2.0 (CR625EVO) opener is factory configured for right hand installation. The opener will operate during this procedure. Make sure the door is clear of obstruction. - Page 11 TESTING THE SAFETY REVERSE SYSTEM The safety reverse system test is important. The garage door must reverse on contact with a 40 mm obstacle laid flat on the floor. Failure to properly adjust the opener may result in serious personal injury from a closing garage door.
-
Page 12: Install Obstruction Detection Beams
• Turn the power ON and check the opener operates OK without the obstruction detection beams SAFETY FIRST! Whilst Chamberlain have engineered safety features into your garage door opener, we urge you to consider fitting obstruction detection beams to your new garage door opener. In many countries these devices are compulsory to assist in preventing serious injury or property damage. -
Page 13: Audible Beep
AUDIBLE BEEP (OPTIONAL) The HandyLift Plus 2.0 (CR625EVO) has been factory set for Audible “BEEP”. The Audible beep can be turned OFF by using the following method. • Start with the door fully CLOSED. • Press and Hold both “S” and “DN” buttons... -
Page 14: Wireless Programming
WIRELESS PROGRAMMING (REMOTE ACCESSORIES) Activate the opener only when door is in full view, free of obstruction and properly adjusted. No one should enter or leave the garage while the door is in motion. Do not allow children to operate push buttons or remotes. Do not allow children to play near the door. NOTE: The transmitters supplied with your opener are preprogrammed by the factory. -
Page 15: Operating Your Opener
Drive: DC gear motor permanent lubrication Max. Drum Rotations: 1/ 2 Memory Registers: Operating Frequency: 433.30/433.92/434.54 MHz Operating Temperature: C to -25 SPECIAL NOTE: Chamberlain strongly recommends that obstruction detection beams be installed on all garage door openers. -
Page 16: Wiring
TYPICAL WIRING DIAGRAM HANDYLIFT PLUS 2.0 (CR625EVO) Information for Service Personnel green (4) grey (3) white (2) red (1) External Receiver 24 vdc white white/black Wired Wall Button Obstruction Detection Beams Battery of the remote control: REPLACE BATTERIES IN REMOTES The batteries in the remote have a long life. -
Page 17: Troubleshooting
TROUBLESHOOTING 1. The opener will not operate from either the 8. The door opens but will not close (or reverses UP/DOWN activation button or the transmitters : while closing): • Does the opener have electric power? Plug a lamp into •... -
Page 18: Accessories
ACCESSORIES 1. Model E940C Car visor remote 4. Model 1702AML Outside quick release 2. Model E950C Keyring remote 5. Model 774AML Obstruction beams - safety beams to 3. Model E840C Wireless keypad - open the garage door protect your family, pets and property from a closing door with a four button key code DIAGNOSTIC CHART Your garage door opener is programmed with self-diagnostic capabilities. -
Page 19: Warranty
Unit to you. purchaser, with this Chamberlain Limited Warranty. This Chamberlain Limited Warranty does not cover any failure of, or defect in, the Unit due to: The benefits given to you under this Chamberlain Limited Warranty are... -
Page 20: Warranty
Warranty Registration Register your warranty at: chamberlaindiy.com.au/warranty chamberlaindiy.co.nz/warranty Trademark of The Chamberlain Group, Inc. ® Registered Trademark of The Chamberlain Group, Inc. 114A4891A © 2016 The Chamberlain Group, Inc...