Replacing Fuel Hose; Replacing Intake Air Line; Replacing Master Cylinder Kit; Replacing Equalizer Kit - Kubota M8540 NARROW Operator's Manual

BReplacing Fuel Hose
Consult your local KUBOTA Dealer for this service.
BReplacing Intake Air Line
Consult your local KUBOTA Dealer for this service.
BReplacing Master Cylinder Kit
Consult your local KUBOTA Dealer for this service.
BReplacing Equalizer Kit
Consult your local KUBOTA Dealer for this service.
BReplacing Brake Seal 1 and 2
Consult your local KUBOTA Dealer for this service.
BReplacing Lift Cylinder Hose
Consult your local KUBOTA Dealer for this service.
BReplacing Air Conditioner Hose
Consult your local KUBOTA Dealer for this service.

SERVICE AS REQUIRED

BBleeding Fuel System
Air must be removed:
1. When the fuel filter or lines are removed.
2. When water is drained from water separator.
3. When tank is completely empty.
4. After the tractor has not been used for a long period of
time.
C Bleeding procedure is as follows:
1. Fill the fuel tank with fuel, and open the fuel cock.
(1) Fuel cock
2. Pump the fuel pump knob(1) located on the top of the
fuel filter. The fuel pump knob will pump easily at first
and with added resistance as air is purged from the
system. To make sure air is completely purged, pinch
the fuel overflow hose with fingers, if a pulsation is felt
when the knob is pumped, then, no air remains.
(1) Fuel pump knob
(2) Fuel overflow hose
3. Set the hand throttle lever at the maximum speed
position, turn the key switch to start the engine and
then reset the throttle lever at the mid speed (around
1500 rpm) position.
If engine doesn't start, try it several times at 30 second
intervals.
PERIODIC SERVICE
(A) "CLOSE"
(B) "OPEN"
(A) "UP"
(B) "DOWN"
83