Table Of Contents - Toro 03550 Reelmaster 5500-D Operator's Manual

Warning
CALIFORNIA
Proposition 65 Warning
Diesel engine exhaust and some of its constituents
are known to the State of California to cause
cancer, birth defects, and other reproductive harm.
Important The engine in this product is not equipped
with a spark arrester muffler. It is a violation of California
Public Resource Code Section 4442 to use or operate this
engine on any forest-covered, brush-covered, or
grass-covered land as defined in CPRC 4126. Other states
or federal areas may have similar laws.
Contents
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safe Operating Practices
Toro Riding Mower Safety
Sound Pressure Level . . . . . . . . . . . . . . . . . . . . . . .
Vibration Level . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety and Instruction Decals
General Specifications . . . . . . . . . . . . . . . . . . . . .
Measurements . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Optional Equipment . . . . . . . . . . . . . . . . . . . . . . . .
Setup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Connecting the Battery . . . . . . . . . . . . . . . . . . . . . .
Mounting the Hood Latch
Replacing the Floor Panel Fastener
Checking the Tire Pressure
Installing the Cutting Units
Alternate the Adjustments
Adjusting the Cutting Unit Stabilizer
Rear Ballast . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Before Operating . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking the Engine Oil
Checking the Cooling System
Filling the Fuel Tank . . . . . . . . . . . . . . . . . . . . . . .
Checking the Transmission Fluid
Checking the Hydraulic Fluid
Checking the Rear Axle Lubricant
Checking the Reel to Bedknife Contact
Check the Torque of the Wheel Nuts
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Starting and Stopping . . . . . . . . . . . . . . . . . . . . . . .
W 2005 by The Toro Company
8111 Lyndale Avenue South
Bloomington, MN 55420-1196
Page
3
3
. . . . . . . . . . . . . . . . . . . . 3
. . . . . . . . . . . . . . . . . . . 5
6
6
. . . . . . . . . . . . . . . . . 7
12
13
13
14
15
. . . . . . . . . . . . . . . . . . . 16
. . . . . . . . . . . 16
. . . . . . . . . . . . . . . . . . 16
. . . . . . . . . . . . . . . . . . 16
. . . . . . . . . . . . . . . . . . . 18
. . . . . . . . . . . 19
19
20
. . . . . . . . . . . . . . . . . . . . 20
. . . . . . . . . . . . . . . . 20
21
. . . . . . . . . . . . . . 21
. . . . . . . . . . . . . . . . 21
. . . . . . . . . . . . 22
. . . . . . . . . 22
. . . . . . . . . . . 22
23
23
25
Bleeding the Fuel System
Setting the Reel Speed
Adjusting the Rear Lift Arm Counterbalance
Towing the Traction Unit
Diagnostic Light . . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnostic ACE Display
Checking the Interlock Switches
Hydraulic Valve Solenoid Functions
Operating Characteristics
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Recommended Maintenance Schedule
Lubricating the Mower
Service Interval Chart
Daily Maintenance Checklist
Servicing the Air Cleaner
Servicing the Engine Oil and Filter
Servicing the Fuel System
Replacing the Fuel Pre Filter
Bleeding Air from the Injectors
Servicing the Engine Cooling System
Servicing the Engine Belts
Adjusting the Throttle
Changing the Hydraulic Fluid
Replacing the Hydraulic Filter
Checking Hydraulic Lines And Hoses
Using the Hydraulic System Test Ports
Adjusting Traction Drive For Neutral
Adjusting the Cutting Unit Drop Rate
Checking and Adjusting Traction Linkage
Hydraulic Schematic
Adjusting the Service Brakes
Changing the Transmission Fluid
Replacing the Transmission Filter
Changing Rear Axle Lubricant
Checking and Adjusting the Rear Wheel Toe-In
Servicing the Battery
Servicing the Fuses . . . . . . . . . . . . . . . . . . . . . . . .
Adjusting the Parking Brake Switch
Installing Optional Lighting
Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . .
Backlapping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Maintaining the Cutting Unit
Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Traction Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
The Toro General Commercial Products Warranty
2
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
. . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . .
. . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . .
. . . . . . . . . .
. . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .
. . . . . . . . . .
. . . . . . . . .
. . . . . . . . . .
. . . . . . . . . .
. . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . .
. . . . . . . . . . . . .
. . . . . . . . . . . . . . .
. .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . .
. . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .
. . .
All Rights Reserved
Printed in the USA
25
25
26
27
27
28
28
29
30
31
31
32
34
35
35
36
37
37
38
38
39
40
40
40
41
41
41
42
43
44
45
45
45
46
46
46
47
47
47
48
49
50
51
51
51
52