Table Of Contents - Toro Reelmaster 2000-D 03431 Operator's Manual

Warning
CALIFORNIA
Proposition 65 Warning
Diesel engine exhaust and some of its constituents
are known to the State of California to cause
cancer, birth defects, and other reproductive harm.
Contents
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safe Operating Practices
Toro Riding Mower Safety
Sound Power Level . . . . . . . . . . . . . . . . . . . . . . . .
Sound Pressure Level . . . . . . . . . . . . . . . . . . . . . . .
Vibration Level . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety and Instruction Decals
Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Specifications . . . . . . . . . . . . . . . . . . . . .
Measurements . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Optional Equipment . . . . . . . . . . . . . . . . . . . . . . . .
Setup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Loose Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Installing the Rear Wheel
Adjusting the Rear Carrier Frame Height
Mounting the Carrier Frames to the Cutting Units
Installing the Front Lift Arms
Mounting the Cutting Unit Drive Motors
Mounting the Cutting Units
Installing the Counterbalance Springs
Adding Rear Ballast . . . . . . . . . . . . . . . . . . . . . . . .
Activating and Charging the Battery
Before Operating . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking the Crankcase Oil
Filling the Fuel Tank . . . . . . . . . . . . . . . . . . . . . . .
Checking the Cooling System
Checking the Hydraulic System
Checking the Tire Pressure
Checking the Reel to Bedknife Contact
Checking the Torque of the Wheel Nuts
W 2006 by The Toro Company
8111 Lyndale Avenue South
Bloomington, MN 55420-1196
Page
3
3
. . . . . . . . . . . . . . . . . . . . 3
. . . . . . . . . . . . . . . . . . . 5
6
6
6
. . . . . . . . . . . . . . . . . 7
11
11
12
12
13
13
. . . . . . . . . . . . . . . . . . . . 14
. . . . . . . 14
14
. . . . . . . . . . . . . . . . 15
. . . . . . . 16
. . . . . . . . . . . . . . . . . . 16
. . . . . . . . . . 17
19
. . . . . . . . . . . 19
21
. . . . . . . . . . . . . . . . . . 21
22
. . . . . . . . . . . . . . . . 22
. . . . . . . . . . . . . . . 23
. . . . . . . . . . . . . . . . . . 24
. . . . . . . . . 24
. . . . . . . . 24
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Starting and Stopping the Engine
Bleeding the Fuel System
Checking the Operation of the Interlock Switches
Towing the Traction Unit
Operating Characteristics
Selecting the Clip Rate
(Reel Speed) . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Training Period . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Before Mowing . . . . . . . . . . . . . . . . . . . . . . . . . . .
Transport Operation . . . . . . . . . . . . . . . . . . . . . . . .
Inspection and Clean-Up After Mowing
Standard Control Module (SCM)
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Recommended Maintenance Schedule
Daily Maintenance Checklist
Service Interval Chart
Greasing the Bearings and Bushings
Removing the Hood . . . . . . . . . . . . . . . . . . . . . . . .
General Air Cleaner Maintenance
Cleaning the Radiator and Screen
Changing Engine Oil And Filter
Changing the Hydraulic System Fluid and Filter
Hydraulic System Test Ports
Fuel System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adjusting the Traction Drive for Neutral
Adjusting Neutral Switch
Adjusting the Belts . . . . . . . . . . . . . . . . . . . . . . . . .
Adjusting the Traction Pedal
Adjusting the Traction Pedal Damper
Adjusting the Hand Brake
Battery Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Storing the Battery . . . . . . . . . . . . . . . . . . . . . . . . .
Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Backlapping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Electrical Schematic . . . . . . . . . . . . . . . . . . . . . . . .
Hydraulic Schematic
Evaporative Emission Control Warranty Statement
The Toro General Commercial Products Warranty
2
. . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . .
. . . . . . . . . . . . . .
. . . . . . . . .
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . .
. . . . . . . . . . . . .
. . . . . . . . . . . . .
. . . . . . . . . . . . . .
. .
. . . . . . . . . . . . . . . . .
. . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .
. . . . . . . . . .
. . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. .
. . .
All Rights Reserved
Printed in the USA
25
25
27
27
28
28
29
29
31
31
31
31
32
34
34
35
36
37
38
38
39
39
39
40
40
41
42
42
42
43
43
43
44
44
45
46
47
51
52